Stinson L-5

The Stinson L-5 Sentinel is a World War II-era liaison aircraft used by the United States Army Air Forces, U.S. Army Ground Forces, U.S. Marine Corps and the British Royal Air Force. It was produced by the Stinson Division of the Vultee Aircraft Company (Consolidated-Vultee from mid-1943). Along with the Stinson L-1 Vigilant, the L-5 was the only other American liaison aircraft that was exclusively built for military use and had no civilian counterpart.

Design and development

The origins of the L-5 can be traced to the prewar civilian Stinson HW-75. This 75 horsepower civilian high-wing design was built by the Stinson Aircraft Company at Wayne, Michigan and first flew in 1939. It was marketed as the Model 105 and was first introduced to the public at the New York World's Fair. The three-place HW-75 featured two side-by-side seats and a third "jumpseat" in back on which a small passenger could sit facing sideways. Stylish, economical, spin resistant and easy to fly, the plane became an instant success with aircraft owners and flight schools across the United States and by the end of 1939 Stinson was building three per day. In 1940 the Model 105 was upgraded to an 80-horsepower Continental engine and with other small improvements this was marketed as the Model 10.Sentinel Owners & Pilots Association, Stinson L-5 History Page
/ref>

Stinson became a subsidiary of the Vultee Aircraft Corporation in August 1940. Under Vultee management, an improved version was fitted with a four-cylinder 90 hp Franklin engine for the 1941 model year and the type became known as the Model 10A. In the postwar era, the fuselage of the Model 10A was lengthened to accommodate four passengers and the four-cylinder powerplant was replaced with a Franklin 150 hp six-cylinder engine. This conversion became the Stinson Model 108 Voyager that was the only aircraft commercially produced by Stinson after WWII.

During the summer of 1940, Stinson built an experimental tandem-seat version of the HW-75, equipping it with a 100 hp Lycoming engine. This was known as the Model 75B. Under Vultee management it was re-designated V-75B. Soon increased to 125 horsepower for better performance, this became the Model V-75C that was demonstrated to the military in August and September 1940.

The V-75C failed to meet military requirements, so the Stinson engineers went back to the drawing board and came up with a clean-sheet design that was similar in concept to the V-75C but was a far stronger, more powerful and completely new tandem-seat airplane that met rigorous Army-Navy engineering standards for the design of military aircraft. This was called the Model 76 and was adopted as the L-5.

The experimental 175 hp Model 76, dubbed "the Flying Jeep" by factory personnel, was first flown at the Stinson factory airport on June 23, 1941, by chief pilot Al Schramm. Accepted by the military after accelerated service trials were completed in September, the first contract for 275 planes was issued in January 1942. Originally designated O-62 ('O' for observation), this was changed to L-5 ''Sentinel'' ('L' for liaison) in April 1942, seven months before the first production airplanes were delivered. With minor changes, the six-cylinder Lycoming O-435 engine was upped to 185 horsepower, becoming the O-435-1 that powered all production Sentinel models through the L-5E-1.

Adopted by the Army Air Forces as their standard liaison aircraft, replacing the larger and more costly L-1 Vigilant, the primary purpose of the L-5 was short range officer transport, courier work and artillery spotting. The fuselage was reconfigured in January 1944 and the modified aircraft, designated as the L-5B, could be used as an air ambulance or for light cargo transport. With a wider and deeper rear fuselage section and a large rear door that folded downward, a litter patient or 250 pounds of cargo could be quickly loaded. Later iterations of the cargo / ambulance version were the L-5C with provisions for mounting a K-20 aerial camera, the L-5E with drooping ailerons for better low-speed control, the L-5E-1 with larger tires and heavy-duty brakes for better short and soft-field performance, and the final L-5G with a 24-volt electrical system and 190 hp version of the Lycoming engine.

In addition to the previously listed uses, L-5's were employed in many diverse roles such as reconnaissance, search & rescue, aerial photography, forward air control of fighter-bombers, laying communication wire, spraying pesticides, dropping para-cargo, dropping leaflets, and aerial broadcasting with loudspeakers. It also served as a test bed for radar tracking, firing aerial rockets, and airborne remote television. In uncommon instances, L-5 crews dropped grenades and fired wing-mounted bazookas at enemy targets.

The L-5 series was manufactured between November 1942 and September 1945, during which time 3,590 of the unarmed two-seaters were delivered for military service, making it the second most widely used light observation liaison aircraft of the war behind the Piper L-4 Cub.

Construction

The fuselage was constructed using arc-welded chrome-moly steel tubing covered with doped cotton fabric and the wings and empennage were constructed of spruce and mahogany plywood box spars and plywood ribs and skins, also covered with fabric. The use of aluminum, which was in critically short supply and more urgently needed for other aircraft, was limited to the engine cowling, tail cone, framework for the ailerons, rudder and elevator and the landing gear fairings. The L-5 through L-5E were powered by a six-cylinder Lycoming O-435-1 engine. The L-5G used a 190 hp Lycoming O-435-11.

Operational history

Capable of operating from short unimproved airstrips, the L-5 "Sentinel" delivered personnel, intelligence and supplies to the front line. On return flights, wounded soldiers were often evacuated to rear area field hospitals for medical treatment. L-5s were primarily flown by the Army Air Forces liaison squadrons consisting of 32 planes each. One of these squadrons was attached to field army headquarters deployed overseas and an additional squadron was assigned to each Army Group headquarters. They saw action in Western Europe, Italy, the Philippines, New Guinea, and the China-Burma-India theater. In the hands of the U.S. Marine Corps artillery observation squadrons they were widely used during the Pacific Island campaigns of 1944 and 1945. The L-5 was used by generals and other high-ranking officers for short-range transportation.

An unusual use of the Sentinel was launch and recovery from a land-based overhead cable system designed by Lt. James Brodie that could be quickly set up in a large clearing that was otherwise unsuitable for a runway. The cable was strung between two tall masts and a braked carriage snagged an arresting hook attached to the top of the airplane. After successful tests of the "runway on a rope" in Oklahoma, it was demonstrated to the British in India who declined to adopt it. However, the unorthodox "Rube Goldberg" Brodie landing system was installed aboard the Naval vessel . Staff Sergeant R. A. Gregory made ten good successful launches and recoveries with a Stinson L-5. During the Battle of Okinawa, L-5s operated from an LST equipped with the "Brodie System".

The Navy and Marine version of the L-5 through L-5E were designated OY-1, and all these aircraft had 12-volt electrical systems. The 24-volt L-5G became the OY-2. Neither the L-5G nor OY-2 saw combat during World War II because production did not begin until July 1945, just weeks before the war ended, but they were used extensively during the Korean War. A further two dozen or so OY-1's were converted to OY-2's in 1948 and 1949. The British Royal Air Force (RAF) procured 40 L-5s and 60 L-5Bs in 1944 and designated them Sentinel Is and Sentinel IIs respectively. These aircraft were used exclusively in the India-Burma theater of operations by SEAC communications and medical evacuation units.

After World War II, the L-5 was used in the continental United States, Hawaii and Alaska by the Civil Air Patrol for search and rescue work. They were also employed by state law enforcement, forestry and Fish & Wildlife departments. Many other countries also received L-5s after the war. The largest quantities were sold to Italy, the Republic of the Philippines, and India. A few went to Pakistan after the partition of India in 1948, and a small number were used by the Japan Defense Force. Others were also sold to Korea, China, Thailand, Mexico, Venezuela, and Brazil.

Variants

Five versions of the Sentinel were produced for the U.S. Army Air Force (USAAF); the L-5, L-5B, L-5C, L-5E and L-5G. There was no official L-5A variant as is often reported because the designation was intended for a version of the aircraft that was never built. Nonetheless, many people in and out of the military still refer to the standard "observer" version of the L-5 as an L-5A. Like the L-5A, the L-5D was a planned version that was not adopted. A single L-5F was an L-5B equipped with an experimental low-noise "stealth" propeller and exhaust system for research purposes. The L-5B through L-5G models were modified to carry a litter patient or light cargo, or a rear seat passenger sitting in the normal position.

;O-62
:Original designation for the first contract for 275 aircraft but this was changed to L-5 before any of these planes were delivered.
;L-5
:Observation model used for artillery spotting and liaison work; 1,538 delivered, 82 transferred to the USMC as OY-1.
;L-5A
:Cancelled variant of L-5 with 24V electrical system. 688 examples falsely reported in 1944 by Jane's All the World's Aircraft to have been built.
;L-5B
:729 delivered. Ambulance versions with large hatch to permit loading of a stretcher or cargo; twin-float capability; 60 transferred to RAF as Sentinel Mk II. 42 delivered to USMC as OY-1.
;L-5C
:200 delivered. Same as L-5B but equipped with a vertical mount behind the rear seat for a K-20 aerial reconnaissance cameras. 39 delivered to USMC as OY-1.
;L-5D: Not adopted. No prototype built.
;L-5E
:500 delivered. Same as L-5C but fitted with manually drooping ailerons for better low-speed handling; 45 transferred to USMC as OY-1.
;L-5E-1
:250 Delivered. Included larger wheels and tires and heavy duty brakes for better off-field performance. 82 transferred to USMC as OY-1.
;L-5G
:Similar to L-5E-1 but with a 24 volt electrical system and SCR-622 radio package. Powered by 190-hp (142-kW) Lycoming 0-435-11 engine with improved cylinders and carburetor. 115 were built by end of the war and the contract for 785 others was cancelled. 18 delivered to USMC as OY-2.
;XL-5F
:One modified L-5B used to develop the 24-volt system used on the L-5G. Re-surfaced in 1948 powered by a geared Lycoming G0-435 piston engine and equipped with a NASA-designed 5-bladed propeller and large exhaust system mounted in ambulance bay. Used for "quiet airplane" development and tests.

;U-19A
:L-5s still in service and redesignated U-19A by the USAF in 1962.
;U-19B
:Single L-5G redesignated U-19B in 1962. Used as a glider tug at the United States Air Force Academy and equipped with a Lycoming R-680 radial engine.
;OY-1
:288 L-5 through L-5E-1 transferred to the United States Marine Corps and United States Navy.
;OY-2
:18 transfers of L-5G to USN/USMC; 30 OY-1 conversions to 24V electrical system.
;Sentinel Mk I
:40 L-5s supplied to the RAF under Lend-Lease.
;Sentinel Mk II
:60 L-5Bs supplied to the RAF under Lend-Lease.
;L-5/235
:Civilian variant developed in Italy for glider towing, powered by Lycoming O-540-B, .
; Clevenger
: Approximately 20 L-5's converted to crop dusters by Clevenger Aerial Applicators of Salinas, CA. Equipped with Continental 220 hp radial engines, larger main and tail wheels, and fitted with lower wings and interplane struts to create a biplane. Operated at up to 3,800# gross weight in the Restricted category.

Operators

;
*Royal Australian Air Force – operated one L-5 Sentinel from 1944 to 1946, loaned from the USAAF.
;
*Royal Hellenic Air ForceBridgman 1951, p. 11a.
;
*Government of Indonesia – acquired a Sentinel during Indonesian National Revolution
;
*Italian Air Force - operated 119 Stinson L-5 Sentinel from 1946 until 1961.
;
* National Security Force
*Japan Ground Self-Defense Force
;
*Republic of Korea Air Force
;
*Pakistan Air Force
;
*Philippine Army Air Corps 1945 to 1947
*Philippine Air ForceBridgman 1951, p. 16a.
;
*Polish Air Force – The fuselage of the sole L-5 used in Poland after 1945 is displayed at the Polish Aviation Museum.
;
*ROC Air Force
;
*PLAAF
;
*Royal Thai Air ForceBridgman 1951, p. 20a.
;
*Royal Air Force
** No. 27 Squadron RAF
** No. 117 Squadron RAF
** No. 194 Squadron RAF
;
*Civil Air Patrol
*United States Army Air Forces
*United States Air Force
*United States Marine Corps
*United States Navy

Surviving aircraft

Today there are about 300 known examples left worldwide and less than half are in flying condition. A group called the Sentinel Owners and Pilots Association is dedicated to the preservation and enjoyment of this aircraft type.

Australia

;Airworthy
;;OY-1
* 03995 – Robert William Kemmis in Coolangatta, Queensland, Australia. This example was built for the USAAF but was delivered directly to the US Navy instead, serving until 1949.

United States

;Airworthy
;;OY-1
* 42-15060 – Commemorative Air Force FloriBama Wing in Pensacola, Florida.
;;OY-2
* 44-18143 – Commemorative Air Force Lake Superior Squadron in Superior, Wisconsin.
;;L-5
* c/n 76-272 – Commemorative Air Force Dallas Fort Worth Wing in Lancaster, Texas.
* 42-98285 – Commemorative Air Force Dew Line Squadron in Amarillo, Texas.
* 42-98667 – Commemorative Air Force Minnesota Wing in South St. Paul, Minnesota.
* 42-98758 or 42-990444 – Commemorative Air Force Capital Wing in Brandy Station, Virginia.
* 44-17543 – privately owned in White Hall, Maryland.
* 44-17588 – Military Aviation Museum in Pungo, Virginia.
* 44-17590 – Commemorative Air Force Central California Valley Squadron in Modesto, California.
* 44-17944 – George J. Marrett of Atascadero, California. On loan to the Estrella Warbird Museum in Paso Robles, California.
;On Display
;;OY-1
* 03917 – Travis Air Force Base Heritage Center in Fairfield, California. It is painted as an L-5.
;;L-5
* 42-98184 – Museum of Aviation in Warner Robins, Georgia.
* 42-14798 – Steven F. Udvar-Hazy Center of the National Air and Space Museum in Chantilly, Virginia. This airframe is the first production L-5 built and was donated to the museum on 5 June 1960.
* 42-14918 – Flying Leatherneck Aviation Museum in San Diego, California.
* 42-15046 – March Field Air Museum in Riverside, California.
* 42-98144 or 42-98453 – National Naval Aviation Museum in Pensacola, Florida.
* 42-98225 – National Museum of the United States Air Force in Dayton, Ohio.
* 44-17925 – Vintage Flying Museum in Fort Worth, Texas.
* 44-18010 – EAA AirVenture Museum in Oshkosh, Wisconsin.
* 45-35046 – South Dakota Air and Space Museum in Box Elder, South Dakota.
;Under Restoration or in Storage
* 42-14934 – to airworthiness with the Commemorative Air Force Air Group One in El Cajon, California.

Netherlands

;Airworthy
;;L-5
* 44-17113 – Dutch Dakota Association in Haarlemmermeer, North Holland.

Specifications (L-5)

See also

References

Footnotes

Notes

Bibliography

* Bavousett, Glenn B. ''World War II Aircraft in Combat''. New York: Arco Pub. Co, 1976.
* Bridgeman, Leonard. ''Jane's All the World's Aircraft 1951–52''. London: Samson Low, Marston & Company, Ltd., 1951.
*
* Gray, James H. ''"History and Design of the Stinson L-5"''; Sentinel Owners & Pilots Association website and newsletter, 2001–2022. www.sentinelclub.org
* Love, Terry M. ''L-Birds: American Combat Liaison Aircraft of World War II''. New Brighton, Minnesota: Flying Books International, 2001. .
* Morgała, Andrzej. ''Ex-USAAF aircraft 1945: Piper L-4 Grasshopper, Douglas C-47 Skytrain/Dakota, Cessna UC-78 Bobcat, Stinson L-5 Sentinel, Taylorcraft L-2A Grasshopper''. Sandomierz: STRATUS, 2011.
*
*

External links

Sentinel Owners and Pilots Association

"America Reports On Aid To Allies etc." ''Universal Newsreel,'' 1942

{{Authority control

High-wing aircraft
Sentinel
1940s United States military utility aircraft
Glider tugs