Volvo 700 Series

The Volvo 700 series is a range of executive cars produced by the Swedish manufacturer Volvo Cars from 1982 to 1992. The 700 series was introduced in 1982 with the luxurious 760, followed two years later by the lower priced 740 which capitalized on the prestige attained by the very similar 760. The 700 series was then gradually replaced, beginning in 1990, by the 900 series. The 700, designed by Jan Wilsgaard, was originally to have been a replacement for the 200 series, but production of that model continued until the early nineties. The expensive 780, a Bertone-designed coupé version, entered production in 1986 and departed without a direct successor only four years later.

The most visible differences between the 700 and the 900 series were the more rounded corners on the body of the latter, and a somewhat better-appointed interior. The 700 series came to an end in late 1992 when the last 740s were built (although they were considered to be of model year 1993). The range had been augmented and finally supplanted by the Volvo 900 in 1993, with the last of the 900s being sold in 1998.

__TOC__

Volvo 740

Introduced in early 1984 (in the U.S. and Australia for the 1985 model year), the 740 arrived nearly two years after the luxurious 760. It was the lower-end version of the original 760, intended to be a mid-size car that offered more style, performance, and luxury than the 200 series. The '4' in the middle of the Volvo model name had once signified a four-cylinder engine, but by the time of the introduction of the 740 it simply meant less luxurious equipment as four- and six-cylinder engines were fitted across both ranges. The 740 was available as a four-door sedan (sometimes referred to as the 744) and a five-door station wagon (also known as the 745). The station wagon premiered simultaneously at the 1985 Toronto and Chicago auto shows in early February 1985. The wagon was aimed squarely at the North American markets and only went on sale in Europe several months later, in the fall of 1985.

The Volvo 740 was a popular choice as a police car in several parts of Europe, especially so with the police in Scandinavian countries.

For 1985, an intercooled version of the 2-litre turbo engine ( B200ET) was introduced for markets such as Italy, where larger engines were heavily taxed. This unit produces at 5500 rpm, ten horsepower more than the preceding non-intercooled B19ET variant, enough for a claimed top speed. Quattroruote only managed to reach Model year 1986 marked the worldwide introduction of the station wagon; other differences were limited to a new font for the "740" badging and new hubcap designs. First shown at the 1988 Geneva Motor Show with tentative specifications but only going on sale with the introduction of the 1989 model year cars, a 16-valve version of the larger B230 engine was introduced (B234). This model has nearly as much peak power as the turbo version and was Volvo's first multi-valve engine.

Facelift

In 1990, the 740 received a minor facelift with new, smaller, composite headlamps and 780-style tail lights. In 1991, both the 740 and the newly introduced 940 received an updated dashboard, similar in appearance to the ones found in the 760. The 740 remained mostly unchanged for the 1992 model year, and sales ended in 1994. Production of the 740 ceased on 2 October 1992, though the engine, transmission, chassis, and other details continued in the Volvo 940 (introduced in September 1990), which was essentially identical to the 740 with the exception of the rear of the sedans.

Aside from styling, 1990 also marked a number of mechanical improvements to the 740 series. The B200 and B230 motors received larger connecting rods. The 740 Turbo switched from the Garrett T3-series turbocharger to the Mitsubishi TD04 series, which offers quicker spool-up and better boost at low engine speeds, albeit at the expense of top-end performance. The electronic fuel injection system was upgraded from Bosch LH-Jetronic 2.2 to 2.4 (in 1988 for naturally aspirated cars, in 1990 for turbocharged cars). The newer fuel system offers onboard diagnostics, which are accessible from the engine compartment and require no special equipment. For 1992, the final model year for the 740, the mechanical engine cooling fan was replaced with an electric fan.

Versions

Trim levels were 740, 740 GL, 740 GLE, 740 SE, 740 GLT and 740 Turbo, worldwide.

Continental markets had some exceptions to this rule. The 740 Turbo 16V (most markets received the 2.3 litre eight-valve turbo engine) was sold mainly in Italy, but also in Portugal and Belgium, and used the 2-litre B204FT engine found also in the 780 for these same markets. The 740 Turbo 16V was equipped with the ECC from the 780 as standard.

Late in 1991, Volvo offered a sedan and wagon badged the 740 SE, standing for "special equipment". The 740 SE came in three colors; red, black, and white. Mechanically, the 740 SE was the same as a normal 740 Turbo, but with many features, such as a power sunroof and leather seats, as standard equipment. The SE also had a special factory color-keyed body kit, including front and rear bumpers, side skirts, and a spoiler for the sedan. The 740 SE, along with the 740 Turbo sedan, was discontinued for 1992.

Volvo 760

The 760 marked a new strategy for Volvo, as they introduced the executive six-cylinder model first with the four-cylinder 740 only following a few years later. Jan Wilsgaard, head of Volvo's Design and Styling Team, proposed over 50 new designs for the new car. Unusual for a new executive car at the time, the 760 had a live rear axle – Volvo's designers claimed that a well-designed one was at least as capable as any independent design, while offering substantial cost and weight savings. The axle itself was mounted almost entirely behind the passenger compartment, freeing up more space inside, and was unusual in that it is mounted in a sub-frame, allowing better passenger comfort than a conventional setup. Volvo called the system Constant Track Rear Suspension, drawing attention to another benefit of a live axle.

It was introduced to the U.S. in 1982 for the 1983 model year as the 760 GLE saloon, with the V6 engine coupled to an automatic transmission, having been launched in Sweden in February 1982 and in Britain from July 1982. The federalized Turbo Diesel went on sale a few months later, at the very end of 1982. In February 1985 the 760 Station Wagon ("765" in internal parlance) was introduced, going on sale in US and Canada a few months later. European markets only received the wagons beginning in the autumn, for the 1986 model year.

This new design was criticized by the media when released: Gordon Murray of ''Autocar Magazine'' said, "to me it's obscene. That goes right against the grain of what everybody else is trying to do. To me it looks like a European version of a North American car. It produces the same amount of power as a 2600 or 3500 — in this day and age it disgusts me to see something about like that. It's a definite step backwards." All that changed however when ''Autocar'' and ''Car & Driver'' got their hands on a turbo intercooled 760; they said it was one of the best handling and fastest accelerating cars they had seen in a while, going from 0–60 mph (97 km/h) in under 8 seconds.

The Turbodiesel, while presented alongside the V6 model, was not immediately available in all markets, with Volvo focusing on markets where diesels had a high market penetration. In Sweden, for instance, it only went on sale for the 1983 model year. Contrarily, in Italy the 740 and 760 diesels sold more than the Mercedes-Benz W123 diesels and the BMW 524d combined in the first half of 1984. The Turbo Diesel was somewhat handicapped in the United States market by only offering a five-speed manual transmission. McGonegal, p. 84 With the bottom dropping out of the diesel market this was not a major issue, however. The heavy diesel engine made for a pronounced front weight bias, with 57 percent of the car's weight resting on the front wheels. McGonegal, p. 81

1983 also brought air conditioning and power windows as standard equipment in Sweden, while a bigger fuel tank was gradually introduced. Turbocharged and intercooled variants were added in 1984, while the 740 (the 760's lower-specification sibling) was introduced for the 1985 model year. In 1985, an electronic traction control system was introduced. Unlike the lesser 740, the 760 received standard anti-lock brakes in many models.

For the 1988 model year, the 760 received numerous updates. From the outside, the most noticeable of the over 2000 changes were the revised front sheet metal, including an aluminium hood, recessed windscreen wipers, and new aerodynamic headlights. Inside, all 760s received a revised dashboard which was angled towards the driver, 3-position tilt steering, and a new stereo system. The top versions were now equipped with a new electronic climate control (ECC; standard on cars sold in the US). Underneath, saloons received the same multi-link independent rear suspension which was also introduced on the 780. The new 4-link rear axle also required a new fuel tank, which was in the form of a saddle, sitting atop the driveshaft. The volume of the tank shrunk by 2 liters, to . Along with the revised dash, the interior saw the addition of a revised dome light and many fabric accent pieces. The 760 Estate received the same changes, except it continued to use the live rear axle. This was due to the weight increase: the new rear suspension weighed about more than the old one, and Volvo determined that the loss of payload would not be worth the comfort improvements.

East German leader Erich Honecker often used this Volvo in his governmental car pool.

For 1990, its final year of production, Volvo 760 saloons received taillights in the style of the Volvo 780 and minor interior changes. The 760 was discontinued after the 1990 model year (with production ending on 27 June 1990), replaced by the Volvo 960, an update of the 760 chassis. The Volvo 740 outlived the 760, remaining for another two years, finally being discontinued in 1992 after the 850 was launched.

The Volvo 760 was built in Kalmar, Sweden, and Ghent, Belgium. Cars were also assembled in Halifax, Nova Scotia, Canada, and in Clayton, Victoria in Australia.

File:1984-1985 Volvo 760 Turbo sedan 01.jpg, Volvo 760 Turbo saloon pre-facelift (AU)
File:1987-1989 Volvo 760 GLE sedan (2011-11-18) 02.jpg, Volvo 760 GLE post facelift (AU)
File:1989 Volvo 765 TIC.JPG, Volvo 760 Turbo Intercooler estate (US)

Volvo 780

The Volvo 780 coupé debuted at the International Auto Show in Geneva, Switzerland in 1985, marking Volvo's return to the two-door coupé market following the departure of the 262C in 1981. The 780 became available in Europe in 1986 and in United States a year later.

Like its predecessor, the 780 was designed and built by Carrozzeria Bertone in Turin, Italy. The hood, trunk, and roof lines were all slightly lower than the standard 700 series profile, and the C-pillar was wider and had a more gradual slope down to the trunk. Headroom was improved over the 262C since Bertone only lowered the roofline by a single centimeter this time. Window frames all had black matte trim, and were accented with chrome. Chrome also highlighted the door handles, bumpers, and side mouldings. Originally, it had been planned to use a smaller, 2,458 cc turbocharged, version of the PRV V6 (as seen in the Renault 25 and Alpine), which had already been successfully tested in 740s and 760s. In the smaller engine compartment of the 780, however, the engine overheated and the PRV V6 Turbo never appeared in a Volvo.

In the first two years that the 780 was available worldwide (1986 and 1987) it received the B280F V6 engine and a solid (live) rear axle. In the Italian market, originally only the Volkswagen built D24TIC was to be offered, with , but soon the V6 also became available and a 2.0-litre turbo (B200ET) Italian tax special was also added later in 1986. From August 1987 the 780 came equipped with Volvo's independent rear suspension, which used self-leveling Nivomat shocks to keep ride height correct. An improved climate control unit (ECC) was also fitted.

The B280F at this point produced roughly , but the car itself weighed nearly . To address concerns about performance, Volvo introduced the B230FT+; a B230FT with Volvo's Turbo+ boost controller, increasing the engine output to . The following model year saw this increase to . In Italy, later 780s were available with the B204GT. This was a 16 valve turbo motor producing . A mere 165 examples of the 780 were built with this engine. In the car's final year, 1991, the 780 was rebadged simply as "Volvo Coupé". At this point, the car came only in turbo guise.

Volvo's official production total for the 780 is 8,518 cars built between 1986 and 1991. From 1986 to 1995, Volvo did offer a small, sporty coupé, the front-wheel drive Volvo 480, but a successor to the 780 would only be introduced in 1997 when the C70 became available.

Specifications

Models

The saloon model originally debuted in 1982 in Europe, and was joined by the estate for 1985.

Model availability:

Engines

These engines were offered on 700 series vehicles:

* B19E: 2.0 L inline-4 (83.04–84.07, saloon only)Lindh, ''Volvo: The Cars'', p. 214
* B19ET: 2.0 L turbo inline-4 (83.12–84.07, saloon only)
* B23E: 2.3 L inline-4, naturally aspirated, Bosch K-Jetronic fuel injection ('84)
* B23ET: 2.3 L turbo inline-4, utilizing Bosch Motronic engine management ('84)
* B23FT: 2.3 L turbocharged inline-4
* B28A: 2.8 L V6, naturally aspirated, carburated ('82–85)
* B28E: 2.8 L V6, naturally aspirated, Bosch K-Jetronic, high output ('82–86)
* B28F: 2.8 L V6, naturally aspirated, odd fire crankshaft ('82–86)
* B200E: 2.0 L inline-4, naturally aspirated, Bosch K-Jetronic
* B200F: 2.0 L inline-4, naturally aspirated, Bosch LH-Jetronic
* B200K: 2.0 L inline-4, naturally aspirated, Renix ignition, 200K had standard head unlike 230K (introduced for the '85 model year)
* B200ET: 2.0 L inline-4, turbocharged, Bosch Motronic engine management (155 hp or 160 PS, introduced for the '85 model year)
* B200FT: 2.0 L inline-4, turbocharged, Bosch LH-Jetronic
* B204E: 2.0 L 16-valve, DOHC, inline-4, naturally aspirated (introduced for the '89 model year)
* B204FT: 2.0 L 16-valve, DOHC, inline-4, turbocharged (introduced for the '89 model year)
* B204GT: 2.0 L 16-valve, DOHC, inline-4, turbocharged (introduced for the '89 model year)
* B230A: 2.3 L inline-4, naturally aspirated, carburated (1985–86)
* B230E: 2.3 L inline-4, naturally aspirated, Bosch K-Jetronic fuel injection (introduced in the '85 model year)
* B230F: 2.3 L inline-4, naturally aspirated, fuel injected and catalyzed 114 hp ('85–88 740GLE, '89–90 740GL, '90–92 740)
* B230K: 2.3 L inline-4, naturally aspirated, carburetted, Renix ignition, ''Heron'' head (introduced for the '85 model year)
* B230ET: 2.3 L inline-4, turbocharged, Bosch Motronic (introduced in the '85 model year)
* B230FT: 2.3 L inline-4, turbocharged, 160 hp ('85–92 740 Turbo **note: '90–92 models produced 162 hp**)
* B234F: 2.3 L 16-valve, DOHC, inline-4, naturally aspirated, 153 hp ('89–90 740 GLE/GLT)
* B280E: 2.8 L V6, naturally aspirated, Bosch LH-Jetronic 2.2, Nordic or European version even fire crankshaft (introduced in the '87 model year)
* B280F: 2.8 L V6, naturally aspirated, Bosch LH-Jetronic , even fire crankshaft ('87–90)
* D24: 2.4 L inline-6 diesel, , naturally aspirated (Volkswagen)
* D24T: 2.4 L inline-6, turbodiesel, , variant of the LT35 engine manufactured by Volkswagen.
* D24TIC: 2.4 L inline-6, turbodiesel, intercooled, (780: ), variant of the LT35 engine manufactured by Volkswagen.

Transmissions

Volvo offered various transmissions depending on the year, model, and engine combinations including the:
* M46 manual transmission (4-speed + Laycock de Normanville overdrive)
* M47 manual transmission (5-speed)
* AW30-40 electronically controlled automatic transmission (4-speed, lockup torque converter)
* AW70/ AW70L automatic transmission (4-speed, lockup torque converter on some models)
* AW71 automatic transmission (4-speed with non-lockup torque converter)
* AW71L automatic transmission (4-speed + lockup torque converter)
* AW72L automatic transmission (4-speed, lockup torque converter)
* ZF 4HP22 transmission automatic transmission (4-speed, lockup torque converter)

Suspension and axle

There were also different suspension combinations depending on the model chosen:
* 1030: standard rear axle
* 1031: heavy-duty version of the 1030
* 1041: rear axle with Eaton locking mechanism

Notes

References

External links

Volvo Cars Heritage

{{Volvo cars timeline

700
Coupés
Sedans
Station wagons
Executive cars
Luxury vehicles
Rear-wheel-drive vehicles
1990s cars
Cars introduced in 1982