3M9 Kub

The 2K12 ''"Kub"'' (russian: 2К12 "Куб"; en, cube) ( NATO reporting name: SA-6 "Gainful") mobile surface-to-air missile system is a Soviet low to medium-level air defence system designed to protect ground forces from air attack. "2К12" is the GRAU designation of the system.

Each 2K12 battery consists of a number of similar tracked vehicles, one of which carries the 1S91 (SURN vehicle, NATO designation "Straight Flush") 25 kW G/ H band radar (with a range of ) equipped with a continuous wave illuminator, in addition to an optical sight. The battery usually also includes four triple-missile transporter erector launchers (TELs), and four trucks, each carrying three spare missiles and a crane. The TEL is based on a GM-578 chassis, while the 1S91 radar vehicle is based on a GM-568 chassis, all developed and produced by MMZ.

Development

The development of the 2K12 was started after 18 July 1958 at the request of the CPSU Central Committee. The system was set the requirements of being able to engage aerial targets flying at speeds of at altitudes of at ranges up to , with a single shot kill probability of at least 0.7.

The systems design was the responsibility of the now Tikhomirov Scientific Research Institute of Instrument Design (NIIP). In addition to NIIP several other design bureaus were involved in the creation of the Kub missile system including Mytishchi Machine-Building Plant which designed and produced the chassis of the self-propelled components. Many of the design bureaus would later go on to co-operate in the development of the successor to the 2K12 "Kub", the 9K37 "Buk".

First trials of the missile system were started at the end of 1959 to discover a series of problems:
* low power for the missile radar seeker and badly designed nose cone
* missile air inlets design failure
* low quality of heat shield inside the afterburner chamber (titanium was replaced by steel).

In August 1961 Toropov was replaced by Lyapin as the Chief Designer of Vympel and in January 1962 Tikhomirov was replaced by Figurovskiy as the Chief Designer of NIIP. Still, the work was not intensified. Before 1963 only 11 of 83 missiles fired had the seeker head installed; only 3 launches were successful.

Kub downed its first-ever air target on February 18, 1963, during the state trials at Donguz test site, Orenburg Oblast. It was an Ilyushin Il-28 bomber.

The system entered an extended testing period between 1959 and 1966, after overcoming the technical difficulties of producing the 2K12 "Kub" the system was accepted into service on 23 January 1967 and went into production that same year.

It is sometimes claimed that the M-11 Shtorm naval system is a version of the 3M9 but this is not the case, as the M-11 Shtorm is a separate system and, unusually for Russian surface-to-air missiles, has no land-based variant.

The 2K12 "Kub" was recommended for modernisation work in 1967 with the goal of improving combat characteristics (longer range, improved ECCM, reliability and reaction time) established for the new chief designer Ardalion Rastov. A modernised variant underwent trial testing in 1972 eventually being adopted in 1973 as the "Kub-M1". The system underwent another modernisation between 1974 and 1976, again the general combat characteristics of the system were improved with the "Kub-M3" clearing testing and entering service in 1976.

After the Rastov visit to Egypt in 1971 to see Kub in operation he decided upon the development of a new system, called Buk, where each TEL should have its own fire control radar (TELAR) and is able to engage multiple targets from multiple directions at the same time.

The final major development of the Kub missile system was achieved during the development of its successor, the 9K37 "Buk" in 1974. Although the Buk is the successor to Kub it was decided that both systems could share some interoperability, the result of this decision was the "Kub-M4" system. The Kub-M4 used Kub-M3 components which could receive fire control information from the 9А310 transporter erector launcher and radar (TELAR) of the 9K37 Buk. The advantage of interoperability was an increase in the number of fire control channels and available missiles for each system as well as a faster service entry for Buk system components. The Kub-M4 was adopted into service in 1978 following completion of trials.

Some early development interpretations of the Buk missile system heavily utilized Kub components, including the 3M9 missile.

There are several plans to integrate active radar homing missiles into Kub. For instance, Polish WZU of Grudziadz demonstrated a project of a Sparrow-armed Kub at the MSPO 2008 defence exhibition in Kielce.
Poland's WZU shows Sparrow-armed Kub
at Jane's Information Group website It is reported also that Vympel initiated some work to use its RVV-AE air-to-air missile to modernise the Kvadrat SAM system.RV-77 could create a smarter Kub
at Jane's Information Group website

Also, the Czech company RETIA presented a SURN (fire control radar) upgrade featuring an optical channel and new multiple-function color displays as well as the radar upgrade and the IFF system.SAM system modernization
at RETIA, a.s.

In 2011 a Kub upgraded launcher (named "2K12 KUB CZ") with three Aspide 2000 missiles in launch containers was presented at the International Exhibition of Defence and Security Technologies (IDET) exposition in Brno. The modifications were made by Retia.The Czech company RETIA, a.s. is replacing – three deadly fingers – of the Surface to Air Missile (SAM) system 2K12 KUB
at RETIA, a.s.

Description

The 2K12 system shares many components with the 2K11 Krug (SA-4) system. In many ways they are designed to complement each other; 2K11 is effective at long ranges and high altitudes, 2K12 at medium ranges and intermediate altitudes.

The system is able to acquire and begin tracking targets using the 1S91 "Самоходная установка разведки и наведения" (SPRGU - "Self-propelled Reconnaissance and Guidance Unit" / NATO: "Straight Flush" radar) at and begin illumination and guidance at . IFF is also performed using this radar. It can only guide one or two missiles to a single target at any time. The missile is initially command guided with terminal semi-active radar homing (SARH), with target illumination provided by the "Straight Flush" radar. Detonation is via either the impact or proximity fuze. On the latest models, this vehicle is also fitted with an optical tracking system which allows engagement without the use of the radar (for active RF emissions stealth reasons, or due to heavy ECM jamming) in which case the effective altitude is limited to 14 km/46000 ft. The optical tracking method also allows engagements to altitudes below that where the radar is able to track targets. Maximum target speed is around Mach 2 for head-on engagements and Mach 1 for tail-chase engagements. Top speed of the missile is approximately Mach 2.8.

In contrast to the elaborate Patriot missile or even the simpler Hawk system fielded by US forces, most of the system rides on two tracked self-propelled vehicles, rather than towed or mounted on trucks, and either the launcher or control vehicle can be set to launch in only 15 minutes after changing location.

Missiles

The fairly large missiles have an effective range of 4–24 km (2.5–15 miles) and an effective altitude of 50–14,000 m (164–45,931 ft). The missile weighs 599 kg (1,321 lb) and the warhead weighs 56 kg (123 lb). Top missile speed is approx. Mach 2.8. The combined propulsion system 9D16K included solid fuel rocket motor which, when burned out, forms the combustion chamber for a ramjet in a pioneering design putting this missile far ahead of its contemporaries in terms of propulsion.

The missile was fitted with a semi-active radar seeker 1SB4, designed by MNII Agat, which was able to track the target by Doppler frequency since the start. Later upgrades (3M9M3 missile) could do this before the start. Chief Designer of the seeker head was Yu.N. Vekhov, since 1960 – I.G. Akopyan.

In 1977 a new version, the 3M9M1 (DoD designation SA-6B) was created with three missiles fitted onto a different chassis (the same as that of the 9K37 "Buk" (NATO reporting name "Gadfly" / DoD SA-11 ), the 2K12 effective replacement) with an integrated "Fire Dome" missile guidance radar. For comparisons between the 2K12, 9K37, see the 9K37 Buk entry.

An earlier incremental upgrade saw the 2K12 missiles replaced with the 2K12E versions and this system was known as Kvadrat ("Квадрат", meaning ''square''). This name was derived from the most common arrangement pattern of the military vehicles of the 2K12 complex, when the 1S91 radar is located at the center and 4x2P25 TELs at the vertices of a square around the radar.

Comparison

1S91 radar

SURN 1S91 vehicle included two radar station – a target acquisition and distribution radar 1S11 and a continuous wave illuminator 1S31, in addition to an IFF interrogator and an optical channel.

While 1S31 antenna was installed on the upper section of the superstructure and the 1S11 on the lower, they could turn around independently. To make the height of the vehicle lower the central cylinder was able to hide inside the prime mover.

The acquisition range of the radar was reported as for an F-4 Phantom II type of target.

Total weight of the 1S91 vehicle with a crew of 4 was 20.3 tonnes and 2P25 vehicle with 3 missiles and a crew of 3 was 19.5 t.

Additional radar

The 2K12 can also be used at a regimental level, if used as such it can be accompanied by a number of additional radar systems for extended air search at longer range and lower altitude, to supplement the 1S91 "Straight Flush". These systems include the:
* P-12 "Spoon Rest", a VHF early warning radar (also used by the S-75 Dvina), with a range.
* P-40 "Long Track", an E band early warning radar (also used by the 2K11 Krug and 9K33 Osa), with a range.
* P-15 "Flat Face A", a UHF early warning radar (also used by the S-125 Neva, with a range.
* "Thin Skin" or "Side Net" E band height finding radar (also used by the S-75, 2K11 Krug and S-200, range 240 km/148 miles)
* "Score Board" IFF radar

The "Spoon Rest" and "Thin Skin" are mounted on a truck, "Long Track" on a tracked vehicle (a modified AT-T) and "Flat Face" on a van. The "Score Board" IFF radar is mounted on a free standing tri-pod.

Without the P-40 "Long Track" mobile radar vehicle, the 2K12 is unable to track aircraft at high altitudes.

File:1S91 missile guidance system control station.JPG, 1S91 first/second operator console
File:Missile guidance system control station of a 1S91 radar.JPG, 1S91 third operator console
File:Monitor and control equipment 1S91.JPG, 1S91 teleconsole
File:1S91 Kub main operator console.jpg, 1S91 main operator console (after upgrade)
File:1S91 Kub third operator console at MAKS Airshow 2011.jpg, 1S91 third operator console (after upgrade)
File:1S91 Kub Teleoperator console at MAKS Airshow 2011.jpg, 1S91 teleconsole (after upgrade)
File:P-12 NRS-12.jpg, NRS-12 "Score Board" IFF radar (bottom left - mounted on tri-pod) and P-12 "Spoon Rest" (centre - mounted on a towable generator).

Operational history

Middle East

Yom Kippur War

In the 1973 Yom Kippur War, the Egyptian and Syrian 2K12s surprised the Israeli military, who were accustomed to having air superiority over the battlefield. The highly mobile 2K12 took a heavy toll on the slower A-4 Skyhawk and even the F-4 Phantom, forming a protective umbrella until they could be removed. The radar warning receivers on the Israeli aircraft did not alert the pilot to the fact that he was being illuminated by the radar. The 2K12 performed well according to a conversation between Israeli General Peled and Henry Kissinger, and caused the most Israeli losses of any Egyptian anti-aircraft missile, followed by the 9K32 Strela-2.

The superior low altitude performance of the weapon, and its new CW semi-active missile seeker resulted in a much higher success rate compared to the earlier S-75 Dvina and S-125 Neva systems. While exact losses are disputed, around 40 aircraft are usually cited as lost to SAMs, and the 2K12 Kub proved the most effective of the three weapons. But in subsequent conflicts, its performance declined as captured examples resulted in effective counter-measures being developed.

1982 Lebanon war

The Syrians also deployed the 2K12 Kub to Lebanon in 1981 after the Israelis shot down Syrian helicopters near Zahlé. The SAM batteries were placed in the Bekaa Valley near the Beirut- Damascus road. They remained close to the existing Syrian air defense system but could not be fully integrated into it. Early in the 1982 Lebanon war, the Israeli Air Force concentrated on suppressing the SAM threat in the Beqaa Valley, launching Operation Mole Cricket 19. The result was a complete success. Several 2K12 Kub batteries, along with S-75s and S-125 systems, were destroyed in a single day. While Syria's own air defenses remained largely intact, its forces in Lebanon were left exposed to attacks by Israeli strike aircraft for the remainder of the war. It has been reported, however, that at least one Israeli F-4 Phantom fighter-bomber was shot down in the area by an SA-6 on July 24, 1982.

South African Border War

The People's Armed Forces for the Liberation of Angola (FAPLA) procured a number of 2K12 Kub systems from the Soviet Union in 1981. According to the Central Intelligence Agency, Angola had obtained sixteen TEL launchers for the 2K12 Kub systems, which were deployed in the Moçâmedes District. The South African military noted that the missiles would make it difficult for it to provide air cover for its cross-border operations against guerrillas of the People's Liberation Army of Namibia, which were operating from Angolan sanctuaries. All of Angola's 2K12 Kub launchers were destroyed in a South African preemptive strike as part of Operation Protea.

2K12 Kub missile sites were also operated by Cuban expeditionary forces in Angola during Operation Excite/Hilti. On 26 June 1988, six 3M9M3 missiles launched from a Cuban 2K12 Kub battery were fired at a South African weather balloon being used as a radar decoy over Tchipa. South African observers used the firing data to plot the location of the 2K12 Kub launchers and destroyed them in a concentrated bombardment with G5 howitzers.

Western Sahara War

Forces of the Polisario Front acquired two full batteries of 2K12 Kub missiles from Algeria during the Western Sahara War, which they used effectively against the fighters of the Royal Moroccan Air Force, including shooting down two Mirage F1 fighters in 1981 during a major battle in Guelta Zemmur.

Poland

On 19 August 2003, a Polish Air Force Su-22M4K was accidentally shot down by friendly fire during an exercise by a Polish 2K12 Kub battery. The aircraft was flying 21 km (13 mi) from the coast over the Baltic Sea near Ustka. The pilot, General Andrzej Andrzejewski, ejected and was rescued after two hours in the water.

Libya

The system was deployed by Libya during the border dispute with Chad and proved a threat for French aircraft. On 16 February 1986, the system failed in detecting low flying French jets which were attacking the Ouadi Doum airbase. On January 7, 1987, the French Air Force were successful in destroying a 2K12 Kub radar site in the Faya Largeau area with SEPECAT Jaguars armed with Martel anti-radiation missiles.

In March, the Chadian rebels captured Ouadi Doum air base, seizing virtually all heavy equipment used for the defense of this airfield, intact. Most of this equipment was transported to France and the United States in the following days, but some 2K12 Kub systems remained in Chad.

With this catastrophe, the Libyan occupation of northern Chad – and the annexation of the Aouzou Strip – was over: by 30 March, the bases at Faya Largeau and Aouzou had to be abandoned. The LARAF now had a completely different task: its Tu-22Bs were to attack the abandoned bases and destroy as much equipment left there as possible. The first strikes were flown in April, and they continued until 8 August 1987, when two Tu-22Bs tasked to strike Aouzou were ambushed by a captured 2K12 Kub battery used by the Chadian Army. One of the bombers was shot down.

Libyan air defense, including 2K12 Kub batteries, was active during the 2011 military intervention in Libya.

Iraq

Several 2K12 Kub batteries, along with other SAM systems and military equipment, were supplied to Iraq before and during the Iran–Iraq War as part of large military packages from the Soviet Union. The batteries were active since the start of the war in September 1980, scoring kills against U.S-supplied Iranian F-4 Phantoms and Northrop F-5s.

The SA-6/Kub was also used during the 1991 Gulf War. The threat posed by these SAMs led to the US Navy outfitting the ALQ-167 Bullwinkle Jamming pod on their F-14A/A+ Tomcats and A-6E TRAM/SWIP Intruder aircraft. On the opening night of Desert Storm, on 17 January 1991, a B-52G was damaged by a missile. Different versions of this engagement are told. It could have been an S-125 or a 2K12 Kub while other versions report a MiG-29 hit the bomber with a R-27R missile. However, the U.S. Air Force disputes these claims, stating the bomber was actually hit by friendly fire, an AGM-88 High-speed, Anti-Radiation Missile (HARM) that homed on the fire-control radar of the B-52's tail gun; the jet was subsequently renamed ''In HARM's Way''. Shortly following this incident, General George Lee Butler announced that the gunner position on B-52 crews would be eliminated, and the gun turrets permanently deactivated, commencing on 1 October 1991.

On January 19, 1991, a USAF F-16 (serial 87-228) was shot down by a 2K12 Kub during the massive (though ill-fated) Package Q Strike against a heavily defended Baghdad. It was the tenth coalition aircraft lost in combat in Operation Desert Storm. The pilot, Captain Harry 'Mike' Roberts, ejected safely but was taken prisoner and freed in March 1991. The aircraft was on a mission to attack the Air Defense Headquarters Building. It had flown 4 combat missions before being lost.

The 2K12 Kub threat was largely controlled by Allied EW assets together with the older S-75s and S-125 missile systems. Most of the losses were due to IR guided SAMs.

Kubs continued to be used by the Iraqi military, along with other SAM systems, to challenge the Western imposed no-fly zones during the 1990s and early 2000s. They were not able to shoot down any Coalition aircraft though several sites were destroyed as retaliation. In one incident, on September 11, 1996, during Operation Provide Comfort II, one missile was fired against two USAF F-16 in northern Iraq but missed. On December 30, 1998, a 2K12 Kub site near Talil fired 6-8 missiles at aircraft enforcing the Southern Watch component of the NFZ. American F-16s responded by dropping six GBU-12 laser-guided bombs on the site and also launching two HARMs "as a preemptive measure" to warn Iraqi radar operators against carrying out more firings.

Bosnia and Yugoslavia

Army of Republika Srpska forces, using modified 2K12 Kub systems were successful in shooting down Scott O'Grady's F-16 in 1995"All For One"
, June 19, 1995, Kevin Fedarko and Mark Thompson, ''Time''

One Mi-17 was shot down by a Kub on May 28, 1995, killing the Bosniak Minister Irfan Ljubijankić, and 6 other crew and passengers.

During the Kosovo War in 1999, on the first night of the war (March 24/25), a Yugoslav Air Force MiG-29 flown by Maj. Predrag Milutinović was downed by a Kub battery in a friendly fire incident, while approaching Niš Airport after an unsuccessful engagement with NATO aircraft.

The Yugoslav Air Defence had 22 2K12 Kub batteries. Using shoot and scoot tactics, the self-propelled ground system demonstrated a good survivability with only three radars lost in the face of nearly four-hundred AGM-88 shots. As comparison the fixed S-75 and S-125 sites suffered losses to around 66 to 80 percent. According to the then-commander of Air force and air defense General Spasoje Smiljanić, during the 78 day campaign, 2K12 Kub had 46 shooting with 70 missiles.

Syrian War

On April 14, 2018, American, British, and French forces launched 103 air-to-surface and cruise missiles targeting sites in Syria. According to the Russian military, twenty-one Kub missiles launched in response allegedly destroyed eleven incoming missiles, However, the American Department of Defense stated no Allied missiles were shot down.

Yemen Civil War

South Yemen formerly operated these systems in the South Yemeni air defense forces. Later, United Yemen purchased a large number of these systems in the 1990s and they entered service with the Yemeni air defense forces in 1999.
On 6 June 2019, Houthi forces successfully shot down a USAF MQ-9. CENTCOM officials blamed the shoot down on a Houthi-operated 2K12 Kub system.

Operators

Current operators

* – about 40 2K12s, as of 2012
* – 16 2К12s, as of 2021
*
* – 20 2K12s, as of 2016
* – 20 2K12s, as of 2019
*
* – 25+
* – 4 batteries – 16 launchers and 4 radiolocators
* – 56 2K12s, as of 2012. All modernized and upgraded.
* – unknown number in service.
* – 12 2K12s, as of 2019
* – 180 2K12s, as of 2012
*
* – 20 2K12s, as of 2012
*


* – Kub Kvadrat-M and Kub 2K12M2 air defence systems received from Belarus.
*
* – 20 2K12s, as of 2015.
* – 32 batteries, future upgrading expected and proposed
*
* – 12 batteries
* – 195 2K12s, as of 2012
* – 20 2K12s, as of 2012
* – 2+ in service as of 2016
*
*

Former operators

* – Replaced by 9K37 Buk. Current 1 battery 2K12s deployed in Armenia, as of 2012 (retired as of 2015). Also in service as IVC 3M20M3 ''Peniye'' missile training target imitator systemPeniye training target system
at Russian Firearms: Specifications, Photos, Pictures website
at Jane's Information Group website
* – Passed on to successor states
* – 4 2K12s with C2 Tatrapan PVO Retired.
* – Retired after German reunification
*
*
* – Passed on to successor states
* – Passed on to successor states

File:PRV-11 "Side Net" radar.jpg, "Side Net" height finding radar. Photo by Nellis AFB.
File:Polish Military Hardware (2856800211).jpg, P-40 "Long Track" early warning radar. Photo by Nellis AFB.
File:1S91 in Polish service.jpg, An 1S91 (Straight Flush) radar of the Hungarian Army's 2K12 Kub missile system

References

Sources

*
*

External links

Kub system walkarounds


at Federation of American Scientists website

Needles in the Haystack – Hunting Mobile Electronic Targets
Maj Michael Pietrucha, USAF

Radar Sites near the North Gate
photos of Soviet radars at Area 51 North Gate

Photos of Polish Kub

{{Russian and Soviet missiles, SAM

Cold War surface-to-air missiles of the Soviet Union
Self-propelled anti-aircraft weapons of the Soviet Union
Self-propelled anti-aircraft weapons of Russia
2K12
2K12
Military vehicles introduced in the 1960s
Almaz-Antey products