Westland Wessex 60

The Westland Wessex is a British-built turbine-powered development of the Sikorsky H-34 (in US service known as Choctaw). It was developed and produced under licence by Westland Aircraft (later Westland Helicopters). One of the main changes from Sikorsky's H-34 was the replacement of the piston-engine powerplant with a turboshaft engine. Early models were powered by a single Napier Gazelle engine, while later builds used a pair of de Havilland Gnome engines.

The Wessex was initially produced for the Royal Navy (RN) and later for the Royal Air Force (RAF); a limited number of civilian aircraft were also produced, as well as some export sales. The Wessex operated as an anti-submarine warfare and utility helicopter; it is perhaps best recognised for its use as a search and rescue (SAR) helicopter. The type entered operational service in 1961, and had a service life in excess of 40 years before being retired in Britain.

Design and development

In 1956, an American-built S-58 was shipped to Britain for Westland to use as a pattern aircraft. Initially assembled with its Wright Cyclone, it was demonstrated to the British armed services leading to a preliminary order for the Royal Navy. For British production, it was re-engined with a single Napier Gazelle turboshaft engine, first flying in that configuration on 17 May 1957.Taylor 1965, p.169. The lighter (by 600 lb) Gazelle engine required some redistribution of weight. The first Westland-built Wessex serial ''XL727'', designated a ''Wessex HAS.1'', first flew on 20 June 1958. The first production Wessex HAS1 were delivered to Royal Navy's Fleet Air Arm (FAA) in early 1960; the Wessex was the first helicopter operated by the FAA to be purpose-designed from scratch as an anti-submarine platform."The Wessex Helicopter".
''royalnavy.mod.uk'', Retrieved: 14 January 2014.

In service, the Wessex was found to be a major improvement over the older Westland Whirlwind. The decision made by Westland to install a modern gas-turbine powerplant gave the Wessex a greater load capacity, was quieter and generated less vibration, the latter quality being highly beneficial when treating casualties during flight. The Gazelle engine allowed for rapid starting and thus faster response times. The Wessex could also operate in a wide range of weather conditions as well as at night, partly due to its use of an automatic pilot. These same qualities that made the Wessex well-suited to the anti-submarine role also lent themselves to the search and rescue (SAR) mission, which the type would become heavily used for.

An improved variant, the Wessex HAS.3, succeeded the HAS.1 in the anti-submarine role; it had a more capable radar and better avionics, greater engine power, improved navigational features and a more advanced weapon system; the original HAS.1 were re-tasked for SAR duties. A commando assault variant, the Wessex HU.5, was also developed as a battlefield transportation helicopter; it was deployed on the navy's amphibious assault ships, such as the commando carrier , and used to transport Royal Marines.McGowen 2005, p. 84. The Wessex HU.5 was powered by coupled de Havilland Gnome engines, which provided nearly double the power of the original HAS.1 model and significantly extended its range. This enabled it to operate in a wider range of conditions; during the 1970s, the HU.5 also started to be used for the SAR mission.

As an anti-submarine helicopter, the Wessex could be either equipped with a dipping sonar to detect and track submarines or be armed with either depth charges or torpedoes; a single Wessex could not search for and attack submarines as this was beyond its carrying capability. It was this limitation that soon led the Royal Navy to search for a more capable helicopter that could provide this capability. This ultimately resulted in Westland proceeding with the adaptation and production of another Sikorsky-designed helicopter in the form of the Westland Sea King.

The Wessex was also used as a general-purpose helicopter for the RAF, for troop-carrying, air ambulance and ground support roles. The Wessex was the first of the RAF's helicopters in which instrument flying, and thus night operations, were possible. Unlike the Navy's Wessex fleet, which was largely composed of early single-engine models, the RAF mandated that its Wessex helicopters should be all twin-engined; this was a major factor in the RAF's decision to reject the adoption of ex-FAA Wessex helicopters as the Navy migrated to the newer Sea King.

Operational history

United Kingdom

Overview

The Wessex was first used by the Royal Navy, which introduced the Wessex ''HAS.1'' to operational service in 1961. Having been satisfied by the favourable initial performance of the Wessex but seeking to improve its avionics and equipment, the Navy soon pressed for the development of the improved ''HAS.3'', which came into service in 1967. Operationally, younger models would be assigned to perform the key anti-submarine warfare and commando transport missions, while older and less capable models would be typically be assigned to land bases for search and rescue (SAR).

The RAF became an operator of the Wessex in 1962; those helicopters used for air-sea or mountain rescue duties helped make the Wessex a particularly well known aircraft of the service and contributed to the saving of many lives during its time in service. As one of the RAF's standing duties, multiple Wessex helicopters were permanently kept on standby to respond to an emergency located anywhere within 40 miles of the British coastline within 15 minutes during daytime, at night hours this response time was decreased to 60 minutes. SAR-tasked Wessex helicopters were also stationed abroad, such as at Cyprus. The qualities of the Wessex were described as being "ideal for mountain flying".

The Wessex often found itself being used on the battlefield as a utility transport; as well as delivering supplies and equipment, the Wessex could also transport small groups of troops. Operationally, the Wessex could lift less than the RAF's Bristol Belvedere helicopters, but was more robust and required less maintenance; thus, when the Belvedere was retired at the end of the 1960s, Wessex squadrons were often tasked with their former duties in support of the British Army on an ad-hoc basis. In large-scale helicopter assault operations, the type could be escorted by the RAF's Hawker Siddeley Harriers. The HC.4 variant of the Westland Sea King began to replace the Wessex in this capacity from the late 1970s onwards, although troop-carrying missions would continue into the late 1990s.

The Wessex's service career featured long-term deployments to both Hong Kong and Northern Ireland to support internal security operations, performing transport and surveillance missions. In Northern Ireland, the use of helicopters for supply missions proved a viable alternative to vulnerable road convoys; operations in this theatre led to the employment of various defensive equipment and countermeasures against the threat posed by small arms and man-portable air-defense systems (MANPADS).

Wessex helicopters were also used by the Queen's Flight of the RAF to transport VIPs including members of the British Royal Family; in this role, the helicopters were designated ''HCC.4'' and were essentially similar to the ''HC.2'', differences included an upgraded interior, additional navigation equipment and enhanced maintenance programmes. Both Prince Philip and Prince Charles were trained Wessex pilots; occasionally they would perform as flying crew members in addition to being passengers on board the VIP services. The Wessex was replaced in this role by a privately leased Sikorsky S-76 in 1998.

Wartime operations

In 1962, an international crisis arose as Indonesia threatened confrontation over the issue of Brunei, which was not in the newly formed Federation of Malaya. By February 1964, a large number of RAF and RN helicopters, including Westland Wessex, were operating from bases in Sarawak and Sabah to assist Army and Marine detachments fighting guerilla forces infiltrated by Indonesia over its one thousand mile frontier with Malaysia. Having removed much of the anti-submarine equipment to lighten the aircraft, during the campaign in Borneo the Wessex was typically operated as a transport helicopter, capable of ferrying up to 16 troops or a 4,000-pound payload of supplies directly to the front lines. Alongside the Westland Scout, the Wessex emerged as one of the main workhorses of the campaign, roughly half were operated directly from land bases and would regularly rotate with those stationed on RN vessels stationed off shore. From these operations the Commando Helicopter Force gets its nickname of the ''Junglies''.

Around 55 Westland Wessex HU.5s participated in the Falklands War, fighting in the South Atlantic in 1982. On 21 May 1982, 845 Squadron's Wessex HU.5s supported British landings on East Falkland. The type was heavily used throughout the conflict for the transportation and insertion of British special forces, including members of the Special Air Service (SAS) and the Special Boat Service (SBS).Crawford 2003, p. 38 A total of nine Wessex (eight HU.5s and one HAS.3) were lost during the Falklands campaign.Burden et al. p. 188. Two HU.5s of 845 Squadron crashed on the Fortuna Glacier in South Georgia during an attempt to extract members of the SAS during a snow storm, six of 848 Squadron's Wessex HU.5s were lost when the container ship '' Atlantic Conveyor'' was sunkBurden et al. 1986, p. 287. and the HAS.3 aboard HMS ''Glamorgan'' was destroyed when the ship was struck by an Exocet missile.

Civilian operations

A civilian version of the helicopter, the Wessex 60, was also manufactured and supplied to a number of civilian operators, including Bristow Helicopters, one of the biggest rotary-wing operators in the world. Bristow flew them from various UK airfields and helicopter pads to support the growing North Sea Oil industry until they were withdrawn in 1982.

Australia

In April 1961, the Royal Australian Navy (RAN) announced that they had selected the Westland Wessex to become the standard service helicopter from their ships and its intention to purchase roughly 30 for anti-submarine patrols, casualty evacuations, and fleet communications duties. The RAN formally accepted the first two of 27 Wessex helicopters in September 1963; 817 Squadron was the first to operate the type; the Wessex and its dunking sonar array quickly proved to be the most effective anti-submarine platform as yet seen in the RAN."817 Squadron History."
navy.gov.au, Retrieved: 15 February 2014.

The Wessex was a major operational shift for the Fleet Air Arm, enabling the RAN to proceed with the conversion of the aircraft carrier HMAS ''Melbourne'' as an anti-submarine platform. In typical carrier operations, a Wessex would be deployed during the launch and recovery of fixed-wing aircraft as a guard helicopter; during anti-submarine patrols, routine procedure was to have one Wessex airborne to actively screen the ship while a second would be fully armed and prepared for operations, such an arrangement was used during troop transport deployments by HMAS ''Sydney'' to Vietnam during the 1960s. Performing search and rescue sorties became another valued role of the type; in 1974, multiple Wessex helicopters participated in the relief effort in Darwin in the aftermath of Cyclone Tracy.

While the Wessex proved to be too large to reasonably operate from most of the RAN's destroyers, it was found to be well suited as a troop-transport helicopter from heavy landing ships and larger vessels. By 1980, the Wessex was no longer being used for anti-submarine operations, having been replaced by the more advanced and capable Westland Sea King in this capacity. Instead, remaining Wessex helicopters were retained to perform its secondary roles as a plane guard, search and rescue platform, and as a utility transport helicopter. The type was withdrawn from service in 1989.

Variants

;Wessex HAS.1
:RN utility, anti-submarine warfare, later air-sea rescue only, 140 built, some later converted to HAS.3.
;Wessex HC.2
:RAF Troop carrier for up to 16 troops, One prototype converted from HAS1 and 73 built.
;Wessex HAR.2
:RAF search and rescue conversions.
;Wessex HAS.3
:RN anti-submarine version with improved avionics with a radome on the rear fuselage, 3 new-build development aircraft and 43 converted from HAS.1
;Wessex HCC.4
: VVIP transport for the Queen's Flight, two built
;Wessex HU.5
:RN service troop transporter, carried 16 Royal Marines, 101 built
;Wessex HAS.31
: Royal Australian Navy anti-submarine warfare model, 27 built.
;Wessex HAS.31B
:Updated anti-submarine warfare model for the Royal Australian Navy.
;Wessex 52
:Military transport version of the HC.2 for the Iraqi Air Force, 12 built.
;Wessex 53
:Military transport version of the HC.2 for the Ghana Air Force, two built.
;Wessex 54
:Military transport version of the HC.2 for the Brunei Air Wing, two built
;Wessex 60
:Civilian version of the Wessex HC.2, 20 built.

Notable accidents

* ''G-ASWI'' – Bristow Helicopters. Crashed (North Sea) August 1981; no survivors
* Two Westland Wessex HU 5 helicopters from 845 Naval Air Squadron crashed on the Fortuna Glacier on 22 April 1982, during the Falklands War
* ''XR524'' (RAF) – Crashed August 1993 in North Wales after tail rotor failure, killing 3 out of 7 on board.

Operators

Military operators

;
* Royal Australian Navy
** 723 Squadron RAN (HC-723)
** 725 Squadron RAN
** 816 Squadron RAN (HU-816)
** 817 Squadron RAN (HS-817)
;
* Brunei Air Wing
;
* Ghana Air Force
;
* Iraqi Air Force
** 2nd Squadron (Iraq)
;
*Sultan of Oman's Air Force
;
* Empire Test Pilots' SchoolHalley 2001, p. 82
* Royal Air Force
** No. 18 Squadron RAFHalley 1980, p. 355.
** No. 22 Squadron RAF
**No. 28 Squadron RAF
** No. 32 Squadron RAFDonald, David. "Westland Wessex HCC.4: Queen's Flight helicopters retire". ''World Air Power Journal'' Volume 34, Autumn/Fall 1998. London:Aerospace Publishing. p. 29. . .
** No. 60 Squadron RAF
** No. 72 Squadron RAF
**No. 78 Squadron RAF
** No. 84 Squadron RAFAshworth 1989, p. 162.
**No. 103 Squadron RAFHalley 1980, p. 140.
**The Queen's Flight
** No. 2 Flying Training School RAF
**No. 202 Squadron RAF
** No. 240 Operational Conversion Unit RAFHalley 2001, p. 84
**Search and Rescue Training Unit
* Royal Navy
** 700H Naval Air Squadron
**700V Naval Air Squadron
** 706 Naval Air SquadronThetford 1982, p. 355.
**706B Naval Air Squadron
**707 Naval Air Squadron
** 737 Naval Air SquadronBurden et al. 1986, p. 267.
**771 Naval Air SquadronBurden et al. 1986, p. 280.
**772 Naval Air Squadron
** 781 Naval Air Squadron
**814 Naval Air Squadron
**815 Naval Air Squadron
**819 Naval Air Squadron
**820 Naval Air Squadron
** 826 Naval Air Squadron
** 829 Naval Air Squadron
**845 Naval Air SquadronBurden et al. 1986, p. 271.
** 846 Naval Air SquadronThetford 1982, p. 359.
** 847 Naval Air SquadronBurden et al. 1986, p. 279.
** 848 Naval Air SquadronBurden et al. 1986, p. 283.
;
* Uruguayan Air Force
* Uruguayan Navy

Civil operators

;
* Bristow Helicopters

Aircraft on display

;Australia
* N7-202 – HAS.31 on display at the Darwin Aviation Museum in Darwin, Northern Territory.
* N7-203 – HAS.31B on display at the Historical Aircraft Restoration Society in Parkes, New South Wales.
* N7-204 – HAS.31B on display at the Australian National Aviation Museum in Melbourne.
* N7-214 – HAS.31B on display at the Australian Aviation Heritage Centre (Qld) in Caboolture, Queensland.
* N7-216 – On display at the Australian National Maritime Museum in Sydney.
* N7-217 – HAS.31A on display at the Queensland Air Museum in Caloundra Airport, Queensland.
* N7-221 – On display at the National Vietnam Veterans Museum in Newhaven, Victoria.
* N7-222 – HAS.31B on display at the Historical Aircraft Restoration Society in Albion Park Rail, New South Wales.
* N7-224 – HAS.31B on display at the South Australian Aviation Museum in Port Adelaide, South Australia.
* N7-226 – HAS.31 on display at the Fleet Air Arm Museum in Nowra, New South Wales.

;Germany
* XR527 – HC.2 on display at Flugausstellung Hermeskeil in Hermeskeil, Rhineland-Palatinate.
* XT670 – HC.2 on display at Flugausstellung Hermeskeil in Hermeskeil, Rhineland-Palatinate.

;United Kingdom

* XM328 – HAS.3 on display at The Helicopter Museum in Weston-super-Mare, Somerset.
* XM330 – HAS.1 on display at The Helicopter Museum in Weston-super-Mare, Somerset.
* XP142 – HAS.3 in storage at the Fleet Air Arm Museum in Yeovil, Somerset.
* XR525 – HC.2 on display at the Royal Air Force Museum Cosford in Cosford, Shropshire.
* XR528 – HC.2 on static display at Morayvia in Kinloss, Moray.
* XR529 – HC.2 previously displayed as the RAF Aldergrove Gate Guardian, currently on display at Crumlin Road Gaol in Belfast, Northern Ireland.\
* XS481 - HU.5 on display at the South Yorkshire Aircraft Museum, Doncaster.
* XS482 – HU.5 on display at the RAF Manston History Museum in Ramsgate, Kent.
* XS508 – HU.5 in storage at the Fleet Air Arm Museum in Yeovil, Somerset.
* XS511 – HU.5 on display at the Tangmere Military Aviation Museum in Tangmere, West Sussex.
* XS863 – HAS.1 on display at the Imperial War Museum Duxford in Duxford, Cambridgeshire.
* XT466 – HU.5 on static display at Morayvia in Kinloss, Moray.
* XT482 – HU.5 on display at the Fleet Air Arm Museum in Yeovil, Somerset.
* XT486 – HU.5 on display at the Dumfries and Galloway Aviation Museum in Dumfries, Dumfries and Galloway.
* XT604 – HC.2 on display at the East Midlands Aeropark in Castle Donington, Leicestershire.
* XT761 – HU.5 airworthy with Historic Helicopters in Chard, Somerset.
* XT765 – HU.5 in storage at the Fleet Air Arm Museum in Yeovil, Somerset.
* XT771 – HU.5 in storage with Historic Helicopters in Chard, Somerset.
* XV720 - HC.2 used as part of the Culham Laser Gaming course near Didcot, Oxfordshire.
* XV728 – HC.2 on display at the Newark Air Museum in Winthorpe, Nottinghamshire.
* XV732 – HCC.4 on display at the Royal Air Force Museum London in London.
* XV733 – HCC.4 on display at The Helicopter Museum in Weston-super-Mare, Somerset.
* WA0561 – Wessex 60 on display at The Helicopter Museum in Weston-super-Mare, Somerset.

;Uruguay
* XR522 – HC.2 at the Museo Aeronáutico Coronel (Aviador) Jaime Meregalli in Ciudad de la Costa, Canelones.

Specifications (Wessex HC.2)

Notable appearances in film

Wessexes portrayed the visually similar CH-34 Choctaws in Stanley Kubrick's 1987 film ''Full Metal Jacket''. The helicopters used were Wessex 60s, a civilian version of the Wessex HC.2. These are powered by the coupled-twin de Havilland Gnome with a distinctive long nose and single large turbine exhaust on each side, distinguishing them from the CH-34. XT761 was featured in season 4 of ''The Crown'' depicting Tom Byrne as Prince Andrew visiting the Queen.

See also

References

Citations

Bibliography

* Allen, Patrick. ''Wessex''. Airlife, 1988. .
* Ashworth, Chris. ''Encyclopedia of Modern Royal Air Force Squadrons''. Wellingborough, UK: Patrick Stephens Limited, 1989. .
*
* Burden, Rodney A. et al. ''Falklands: The Air War''. British Aviation Research Group, 1986. .
* Crawford, Stephen. ''Twenty First Century Military Helicopters: Today's Fighting Gunships''. Zenith Imprint, 2003. .
* Dunstan, Simon. ''Vietnam Choppers: Helicopters in Battle 1950–1975''. Osprey Publishing, 2003. .
* Fowler, Will. ''Britain's Secret War: The Indonesian Confrontation 1962 – 66''. Osprey Publishing, 2006. .
* Grey, Jeffrey. ''A Military History of Australia''. Cambridge University Press, 2008. .
* Harrison, Neil
"World's Biggest VTOL Carrier"
'' Flight International'', 1 May 1969, pp. 725–727.
* Halley, James J. ''The Squadrons of the Royal Air Force''. Tonbridge, Kent, UK: Air Britain (Historians) Ltd, 1980. .
* Halley, James ''Royal Air Force aircraft XA100 to XZ999'' Tonbridge, Kent, UK: Air Britain (Historians) Ltd, 2001.

"Helicopters in the Royal Air Force."
''Royal Air Force Historical Society'', 18 October 2000.
* James, Derek N. ''Westland Aircraft since 1915''. London: Putnam, 1991. .
* McGowen, Stanley S. ''Helicopters: An Illustrated History of their Impact''. Santa Barbara, California: ABC-CLIO, 2005. .
* Motum, John. ''The Putnam Aeronautical Review''. Naval Institute Press, 1991. .
* Ovcacik, Michal and Susa, Karel. ''Westland Wessex: Rotary Wings Line'', 1st edition 1998, 4+ Publications, Prague Czech Republic, (in English) .
* Piggot, Peter. ''Royal Transport: An Inside Look at The History of British Royal Travel''. Dundurn, 2005. .
* Plamondon, Aaron. ''The Politics of Procurement: Military Acquisitions in Canada and the Sea King Helicopter''. UBC Press, 2010. .
* Ripley, Tim. ''16 Air Assault Brigade: The History of Britain's Rapid Reaction Force''. Casemate Publishers, 2008. .
* Robertson, Bruce. ''British Military Aircraft serials 1878–1987''. Leicester, England:Midland Counties Publications, 1987.
*
* Taylor, John W. R. (editor). ''Jane's All The World's Aircraft 1965–66''. London:Sampson Low, Marston, 1965.
* Thetford, Owen. ''British Naval Aircraft since 1912''. London: Putnam, 1978. .

External links

RAF Museum

helis.com Wessex section

Wessex over South Armagh by Michael Rondot

{{Authority control

1960s British helicopters
1960s British military utility aircraft
Wessex
Military helicopters
Twin-turbine helicopters
Search and rescue helicopters
Aircraft first flown in 1958