The Toyota FCHV is a current

hybrid Hybrid may refer to: Science * Hybrid (biology), an offspring resulting from cross-breeding ** Hybrid grape, grape varieties produced by cross-breeding two ''Vitis'' species ** Hybridity, the property of a hybrid plant which is a union of two dif ...

hydrogen Hydrogen is the chemical element with the symbol H and atomic number 1. Hydrogen is the lightest element. At standard conditions hydrogen is a gas of diatomic molecules having the formula . It is colorless, odorless, tasteless, non-toxic, an ...

fuel cell vehicle A fuel cell vehicle (FCV) or fuel cell electric vehicle (FCEV) is an electric vehicle that uses a fuel cell, sometimes in combination with a small battery or supercapacitor, to power its onboard electric motor. Fuel cells in vehicles generate elec ...

development programme of the Toyota Motor Corporation, which was leased to a limited number of drivers in the United States and Japan beginning in 2002. "FCHV" stands for "Fuel Cell Hybrid Vehicle". A number of

prototype A prototype is an early sample, model, or release of a product built to test a concept or process. It is a term used in a variety of contexts, including semantics, design, electronics, and Software prototyping, software programming. A prototyp ...

s have been produced, up to the latest FCHV-adv ("advanced").

History

There are currently five generations of the FCHV, beginning with preliminary prototypes FCHV-1 (1997) and FCHV-2 (1999). The FCHV-3 was presented at the "International Symposium on Fuel-Cell Vehicles" in March 2001 in

Tokyo Tokyo (; ja, 東京, , ), officially the Tokyo Metropolis ( ja, 東京都, label=none, ), is the capital and largest city of Japan. Formerly known as Edo, its metropolitan area () is the most populous in the world, with an estimated 37.468 ...

, and the FCHV-4 was the first production version, although Toyota did not plan a full-scale commercial hydrogen fuel cell vehicle launch until around 2015. As of 2008 the FCHV-adv was available for lease in Japan. The use of the vehicles by government ministries and companies is intended to provide detailed development feedback on the FCHV performance under varied driving conditions. In 2007 a FCHV was driven between

Osaka is a designated city in the Kansai region of Honshu in Japan. It is the capital of and most populous city in Osaka Prefecture, and the third most populous city in Japan, following Special wards of Tokyo and Yokohama. With a population of 2. ...

and

on a single tank of hydrogen, proving that a hydrogen vehicle could compete with conventional vehicles for range. In August 2009, Toyota USA announced an estimated FCHV-adv range of from a tank of hydrogen, based on a test trip in "real-world" conditions between Torrance and

San Diego San Diego ( , ; ) is a city on the Pacific Ocean coast of Southern California located immediately adjacent to the Mexico–United States border. With a 2020 population of 1,386,932, it is the List of United States cities by population, eigh ...

California California is a U.S. state, state in the Western United States, located along the West Coast of the United States, Pacific Coast. With nearly 39.2million residents across a total area of approximately , it is the List of states and territori ...

FCHV system

The FCHV designs are based on the first generation

Highlander Highlander may refer to: Regional cultures * Gorals (lit. ''Highlanders''), a culture in southern Poland and northern Slovakia * Hill people, who live in hills and mountains * Merina people, an ethnic group from the central plateau of Madagascar ...

SUV, although a bus version is also in development. The powertrain consists of a 90 kW fuel cell supplied from onboard compressed

hydrogen tank A hydrogen tank (other names- cartridge or canister) is used for hydrogen storage. The first type IV hydrogen tanks for compressed hydrogen at were demonstrated in 2001, the first fuel cell vehicles on the road with type IV tanks are the Toyota F ...

s, and a

nickel–metal hydride battery A nickel metal hydride battery (NiMH or Ni–MH) is a type of rechargeable battery. The chemical reaction at the positive electrode is similar to that of the Nickel–cadmium battery, nickel–cadmium cell (NiCd), with both using nickel oxid ...

in parallel. Battery and fuel cell can provide power to the 90 kW driving motors either singly or together. The mechanism is very similar to the Hybrid Synergy Drive in the Toyota Prius and Toyota Auris HSD but with the

fuel cell A fuel cell is an electrochemical cell that converts the chemical energy of a fuel (often hydrogen) and an oxidizing agent (often oxygen) into electricity through a pair of redox reactions. Fuel cells are different from most batteries in requ ...

replacing the

petrol Gasoline (; ) or petrol (; ) (see ) is a transparent, petroleum-derived flammable liquid that is used primarily as a fuel in most spark-ignited internal combustion engines (also known as petrol engines). It consists mostly of organic co ...

internal combustion engine An internal combustion engine (ICE or IC engine) is a heat engine in which the combustion of a fuel occurs with an oxidizer (usually air) in a combustion chamber that is an integral part of the working fluid flow circuit. In an internal combus ...

, thus minimising

greenhouse gas emissions Greenhouse gas emissions from human activities strengthen the greenhouse effect, contributing to climate change. Most is carbon dioxide from burning fossil fuels: coal, oil, and natural gas. The largest emitters include coal in China and lar ...

at point of use. At low speeds the FCHV can run on battery alone, with a range of about . For high performance, such as when accelerating from rest, the fuel cell and battery supply power in tandem. The battery can also charge by regenerative braking, improving overall efficiency.

Hydrogen storage

The 700

Bar Bar or BAR may refer to: Food and drink * Bar (establishment), selling alcoholic beverages * Candy bar * Chocolate bar Science and technology * Bar (river morphology), a deposit of sediment * Bar (tropical cyclone), a layer of cloud * Bar (u ...

(10000

PSI Psi, PSI or Ψ may refer to: Alphabetic letters * Psi (Greek) (Ψ, ψ), the 23rd letter of the Greek alphabet * Psi (Cyrillic) (Ѱ, ѱ), letter of the early Cyrillic alphabet, adopted from Greek Arts and entertainment * "Psi" as an abbreviation ...

)

s holds 156 liters - enough fuel for a range of on the Japanese 10-15 test cycle and on the Japanese JC08 test cycle. Test vehicles on the Japanese 10-15 test cycle average with a top speed of . Vehicles on the JC08 test cycle average and a top speed of .

Models

FCHV-1

FCHV-2

FCHV-3

FCHV-4

FCHV-adv

FCHV-BUS

The Toyota FCHV-BUS is a

fuel cell bus A fuel cell bus is a bus that uses a hydrogen fuel cell as its power source for electrically driven wheels, sometimes augmented in a hybrid fashion with batteries or a supercapacitor. The only emission from the bus is water. Several cities arou ...

based on the

Hino Blue Ribbon City The Hino Blue Ribbon (kana:日野・ブルーリボン) is a heavy-duty single-decker bus produced by Hino Motors through the J-Bus joint-venture. The range is primarily available as city bus and tourist coach. It is built by J-Bus as either a ...

(KL-HU2PMEE) low-floor bus. *90 kW PEFC Fuel cell stack: twice *Motor: AC synchronous 80 kW twice *Hydrogen tank: Compressed hydrogen gas 35 MPa / 150 liter, five (version 2002) or seven (version 2005) *Passenger capacity: 63 (included 22 seats) FCHV-BUS demonstrated at Toei Bus (August 2003 - December 2004) and Expo 2005. After Expo 2005, some were lent to bus fleet operators, and also demonstrated in fuel cell events. *

Chita Noriai , also called Chita Bus, is a bus company in the Meitetsu Group, based in Handa, Aichi Prefecture, Japan. Bus Lines Airport bus *From Chūbu Centrair International Airport **For Kariya and Chiryū **For Okazaki **For Anjō **For Tokonam ...

(March 2006 - December 2009) as route bus in Chubu International Airport * Chubu International Airport (since July 2006) as ramp bus *

Meitetsu Bus is a bus company in the Meitetsu Group. Bus Lines Highway Buses *Chuo Highway Bus **Meitetsu BC - Shinjuku **Meitetsu BC - Iida **Meitetsu BC - Ina, Komagane, Minowa **Meitetsu BC - Matsumoto **Meitetsu BC - Nagano **Meitetsu BC - Niig ...

(since October 2010) as route bus in

Toyota City, Aichi , formerly known as Koromo, is a Cities of Japan, city in Aichi Prefecture, Japan. , the city had an estimated population of 426,162 and a population density of 464 people per km2. The total area was . It is located about 35 minutes from Nagoya by ...

*Airport Transport Service (since December 2010) as airport shuttle bus for

Tokyo International Airport , officially , and sometimes called as Tokyo Haneda Airport or Haneda International Airport , is one of two international airports serving the Greater Tokyo Area, the other one being Narita International Airport (NRT). It serves as the primary ...

FC Bus

The FC Bus uses the Toyota Fuel Cell System (TFCS) in a bus, based on experience with Hino on the

Hino Blue Ribbon The Hino Blue Ribbon (kana:日野・ブルーリボン) is a heavy-duty single-decker bus produced by Hino Motors through the J-Bus joint-venture. The range is primarily available as city bus and tourist coach. It is built by J-Bus as either a ...

bus. In 2015, the bus was lent to

for free, as a demonstration that fuel cell buses were practical. It was used on the Toyota City Community Bus ''Oiden Bus Toyota East Circle Line'' (Section：

Toyotashi Station 270px, Platforms is a junction railway station in the city of Toyota, Aichi, Japan, operated by Meitetsu. Lines Toyotashi Station is served by the Meitetsu Mikawa Line and is 15.7 kilometers from the terminus of the line at Chiryū Station. It ...

↔

Mikawa-Toyota Station 260px, Platforms in May 2015 is a railway station in the city of Toyota, Aichi Prefecture, Japan, operated by the third sector Aichi Loop Railway Company. Lines Mikawa-Toyota Station is served by the Aichi Loop Line, and is located 15.9 kilom ...

). In September on 2015, the bus started running ''Toyota Oiden Bus Fujioka・Toyota Line'' (Section：

↔ Fujioka Elementary School). Toyota planned to start sales in 2017 and to have 100 units in Tokyo in time for the 2020 Olympics. The bus was delivered to Toei Bus on lease contract.

SORA

The Toyota SORA bus will be made from 2018. The name "SORA" stands for Sky, Ocean, River, Air, which is the water cycle. It includes a Toyota Fuel Cell System (TFCS) and a collision warning system. It has a capacity of up to 79 people. The seats can also stow automatically when not in use. It also uses LED lights to communicate with other buses and travel in convoys to conserve energy. They can also be used as an emergency power source, having up to .

Project Portal trucks

Toyota started testing two Mirai fuel cells (114 kW each) in a converted

Kenworth T680 The Kenworth T600 is a model line of conventional-cab trucks that were produced by the American truck manufacturer Kenworth from 1984 to 2007. Distinguished by its aerodynamic sloped hood, the T600 was a Truck classification#Class 8, Class 8 truc ...

electric Class 8 semi-trailer truck in the

Port of Los Angeles The Port of Los Angeles is a seaport managed by the Los Angeles Harbor Department, a unit of the City of Los Angeles. It occupies of land and water with of waterfront and adjoins the separate Port of Long Beach. Promoted as "America's Port", t ...

in April 2017 as part of 'Project Portal', doing

drayage Drayage is the transport of goods over a short distance in the shipping and logistics industries. Drayage is often part of a longer overall move, such as from a ship to a warehouse. Some research defines it specifically as "a truck pickup from ...

for Toyota. The truck has two motors for a combined and of torque, a 200 kW 12 kWh battery, and a fixed gear ratio of 15.5:1. It has a range of determined by the size of the hydrogen tanks. It accelerates (empty) from in 7 seconds. The motors are mainly powered by the fuel cells rather than from the small battery. Toyota added a

terminal tractor A terminal tractor, known in the United States as a shunt truck, spotter truck, spotting tractor, yard truck, yard shifter, yard dog, yard goat, yard horse, yard jockey, hostler, or mule, is a kind of semi-tractor intended to move semi-trailers ...

to the project in 2019. The project was updated with a truck in 2020.

Cultural impact

Prophets of Science Fiction

The FCHV is featured in the

Jules Verne Jules Gabriel Verne (;''Longman Pronunciation Dictionary''. ; 8 February 1828 – 24 March 1905) was a French novelist, poet, and playwright. His collaboration with the publisher Pierre-Jules Hetzel led to the creation of the ''Voyages extraor ...

episode of the Science Channel program

Prophets of Science Fiction ''Prophets of Science Fiction'' is an American documentary television series produced and hosted by Ridley Scott for the Science Channel. The program premiered on . The series covers the life and work of leading science fiction authors of the las ...

. Some measure of credit is given to Jules Verne in the episode, for helping to inspire the idea.

References

External links

Putting the Green in Our Machine. Toyota USA.Fuel Cell Vehicle. Toyota Global
{{DEFAULTSORT:Toyota Fchv FCHV Hydrogen cars Fuel cell vehicles Fuel cell buses