Factory and Workshop Act 1901

The Factory Acts were a series of acts passed by the Parliament of the United Kingdom to regulate the conditions of industrial employment.

The early Acts concentrated on regulating the hours of work and moral welfare of young children employed in cotton mills but were effectively unenforced until the Act of 1833 established a professional Factory Inspectorate. The regulation of working hours was then extended to women by an Act of 1844. The Factories Act 1847 (known as the Ten Hour Act), together with Acts in 1850 and 1853 remedying defects in the 1847 Act, met a long-standing (and by 1847 well-organised) demand by the millworkers for a ten-hour day. The Factory Acts also sought to ameliorate the conditions under which mill-children worked with requirements on ventilation, sanitation, and guarding of machinery.

Introduction of the ten-hour day proved to have none of the dire consequences predicted by its opponents, and its apparent success effectively ended theoretical objections to the principle of factory legislation; from the 1860s onwards more industries were brought within the Factory Act.

Health and Morals of Apprentices Act 1802

The Health and Morals of Apprentices Act 1802 (42 Geo III c.73) was introduced by Sir Robert Peel; it addressed concerns felt by the medical men of Manchester about the health and welfare of children employed in cotton mills, and first expressed by them in 1784 in a report on an outbreak of 'putrid fever' at a mill at Radcliffe owned by Peel. Although the Act included some hygiene requirements for all textile mills, it was largely concerned with the employment of apprentices; it left the employment of 'free' (non-indentured) children unregulated.

It allowed (but did not require) local magistrates to enforce compliance with its requirements, and therefore went largely unenforced. As the first attempt to improve the lot of factory children, it is often seen as paving the way for future Factory Acts. At best, it only partially paved the way; its restriction to apprentices (where there was a long tradition of legislation) meant that it was left to later Factory Acts to establish the principle of intervention by Parliament on humanitarian grounds on worker welfare issues against the "laissez-faire" political and economic orthodoxy of the age which held that to be ill-advised.

Under the Act, regulations and rules came into force on 2 December 1802 and applied to all textile mills and factories employing three or more apprentices or twenty employees. The buildings must have sufficient windows and openings for ventilation, and should be cleaned at least twice yearly with quicklime and water; this included ceilings and walls.

Each apprentice was to be given two sets of clothing, suitable linen, stockings, hats, and shoes, and a new set each year thereafter. Apprentices could not work during the night (between 9 pm and 6 am), and their working hours could not exceed 12 hours a day, excluding the time taken for breaks. A grace period was provided to allow factories time to adjust, but all night-time working by apprentices was to be discontinued by June 1804.

All apprentices were to be educated in reading, writing and arithmetic for the first four years of their apprenticeship. The Act specified that this should be done every working day within usual working hours but did not state how much time should be set aside for it. Educational classes should be held in a part of the mill or factory designed for the purpose. Every Sunday, for one hour, apprentices were to be taught the Christian religion; every other Sunday, divine service should be held in the factory, and every month the apprentices should visit a church. They should be prepared for confirmation in the Church of England between the ages of 14 and 18 and must be examined by a clergyman at least once a year. Male and female apprentices were to sleep separately and not more than two per bed.

Local magistrates had to appoint two inspectors known as 'visitors' to ensure that factories and mills were complying with the Act; one was to be a clergyman and the other a Justice of the Peace, neither to have any connection with the mill or factory. The visitors had the power to impose fines for non-compliance and the authority to visit at any time of the day to inspect the premises.

The Act was to be displayed in two places in the factory. Owners who refused to comply with any part of the Act could be fined between £2 and £5.

Cotton Mills and Factories Act 1819

The Cotton Mills and Factories Act 1819 ( 59 Geo. III c66) stated that no children under 9 were to be employed and that children aged 9–16 years were limited to 12 hours' work per day.Early factory legislation
Parliament.uk. Accessed 2 September 2011. It applied to the cotton industry only, but covered all children, whether apprentices or not. It was seen through Parliament by Sir Robert Peel; it had its origins in a draft prepared by Robert Owen in 1815 but the Act that emerged in 1819 was much watered-down from Owen's draft. It was also effectively unenforceable; enforcement was left to local magistrates, but they could only inspect a mill if two witnesses had given sworn statements that the mill was breaking the Act.

An amending Act (''60 Geo. III., c. 5'') was passed in December 1819. When any accident disabled a factory (as had just happened at New Lanark), night working in the rest of the works by those who had previously worked in the affected factory was permitted until the accident was made good.

Cotton Mills Regulation Act 1825

In 1825 John Cam Hobhouse introduced a Bill to allow magistrates to act on their own initiative, and to compel witnesses to attend hearings; noting that so far there had been only two prosecutions under the 1819 Act. Opposing the Bill a millowner MP agreed that the 1819 Bill was widely evaded, but went on to remark that this put millowners at the mercy of millhands "The provisions of Sir Robert Peel's act had been evaded in many respects: and it was now in the power of the workmen to ruin many individuals, by enforcing the penalties for children working beyond the hours limited by that act" and that this showed to him that the best course of action was to repeal the 1819 Act. On the other hand, another millowner MP supported Hobhouse's Bill saying that he

"agreed that, the bill was loudly called for, and, as the proprietor of a large manufactory, admitted that there was much that required remedy. He doubted whether shortening the hours of work would be injurious even to the interests of the manufacturers; as the children would be able, while they were employed, to pursue their occupation with greater vigour and activity. At the same time, there was nothing to warrant a comparison with the condition of the negroes in the West Indies.

Hobhouse's Bill also sought to limit hours worked to eleven a day; the Act as passed (the Cotton Mills Regulation Act :''6 Geo. IV., c. 63'') improved the arrangements for enforcement, but kept a twelve-hour day Monday-Friday with a shorter day of nine hours on Saturday. The 1819 Act had specified that a meal break of an hour should be taken between 11 a.m. and 2 p.m.; a subsequent Act (''60 Geo. III., c. 5'') allowing water-powered mills to exceed the specified hours in order to make up for lost time widened the limits to 11 a.m. to 4 p.m.; Hobhouse's Act of 1825 set the limits to 11 a.m. to 3 p.m. A parent's assertion of a child's age was sufficient, and relieved employers of any liability should the child in fact be younger. JPs who were millowners or the fathers or sons of millowners could not hear complaints under the Act.

Act to Amend the Laws relating to the employment of Children in Cotton Mills & Manufactories 1829

In 1829, Parliament passed an 'Act to Amend the Laws relating to the employment of Children in Cotton Mills & Manufactories' which relaxed formal requirements for the service of legal documents on millowners (documents no longer had to specify all partners in the concern owning or running the mill; it would be adequate to identify the mill by the name by which it was generally known). The bill passed the Commons but was subject to a minor textual amendment by the Lords (adding the words 'to include') and then received the Royal Assent without the Commons first being made aware of (or agreeing to) the Lords' amendment. To rectify this inadvertent breach of privilege, a further Act (making no other change to the Act already passed) was promptly passed on the last day of the parliamentary session.

Labour in Cotton Mills Act 1831 (Hobhouse's Act)

''An Act to repeal the Laws relating to Apprentices and other young Persons employed in Cotton Factories and in Cotton Mills, and to make further Provisions in lieu thereof ( 1 & 2 Will. IV c39)''
:(Acts repealed were ''59 Geo. III, c. 66; 60 Geo. III, c. 5; 6 Geo. IV, c. 63; 10 Geo. IV, c. 51; 10 Geo. IV, c. 63'')
In 1831 Hobhouse introduced a further bill with – he claimed to the Commons – the support of the leading manufacturers who felt that "unless the House should step forward and interfere so as to put an end to the night-work in the small factories where it was practised, it would be impossible for the large and respectable factories which conformed to the existing law to compete with them."

The Act repealed the previous Acts, and consolidated their provisions in a single Act, which also introduced further restrictions. Night working was forbidden for anyone under 21 and if a mill had been working at night the onus of proof was on the millowner (to show nobody under-age had been employed). The limitation of working hours to twelve now applied up to age eighteen. Complaints could only be pursued if made within three weeks of the offence; on the other hand justices of the peace who were the brothers of millowners were now also debarred from hearing Factory Act cases. Hobhouse's claim of general support was optimistic; the Bill originally covered all textile mills; the Act as passed again applied only to cotton mills.

Labour of Children, etc., in Factories Act 1833 (Althorp's Act)

The first 'Ten Hour Bill' – Sadler's Bill (1832), Ashley's Bill (1833)

Dissatisfied with the outcome of Hobhouse's efforts, in 1832 Michael Thomas Sadler introduced a Bill extending the protection existing Factory Acts gave to children working in the cotton industry to those in other textile industries, and reducing to ten per day the working hours of children in the industries legislated for. A network of 'Short Time Committees' had grown up in the textile districts of Yorkshire and Lancashire, working for a 'ten-hour day Act' for children, with many millhands in the Ten Hour Movement hoping that this would in practice also limit the adult working day. Witnesses to one of the Committees taking evidence on Peel's Bill had noted that there were few millworkers over forty, and that they themselves expected to have to stop mill work at that age because of 'the pace of the mill' unless working hours were reduced. see in particular the evidence of a 36-year-old spinner Robert Hyde pp 25–30

Hobhouse advised Richard Oastler, an early and leading advocate of factory legislation for the woolen industry, that Hobhouse had got as much as he could, given the opposition of Scottish flax-spinners and 'the state of public business': if Sadler put forward a Bill matching the aims of the Short Time Committees "he will not be allowed to proceed a single stage with any enactment, and ... he will only throw an air of ridicule and extravagance over the whole of this kind of legislation". Oastler responded that a failure with a Ten Hour Bill would "not dishearten its friends. It will only spur them on to greater exertions, ''and would undoubtedly lead to certain success'' "the correspondence can also be found as in the British Newspaper Archive

Sadler's Bill (1832)

Sadler's Bill when introduced indeed corresponded closely to the aims of the Short Time Committees. Hobhouse's ban on nightwork up to 21 was retained; no child under nine was to be employed; and the working day for under-eighteens was to be no more than ten hours (eight on Saturday). These restrictions were to apply across all textile industries. The Second Reading debate on Sadler's bill did not take place until 16 March 1832, the Reform Bill having taken precedence over all other legislation.

Meanwhile, petitions both for and against the Bill had been presented to the Commons; both Sir Robert Peel (not the originator of the 1802 bill, but his son, the future Prime Minister) and Sir George Strickland had warned that the Bill as it stood was too ambitious: more MPs had spoken for further factory legislation than against, but many supporters wanted the subject to be considered by a Select Committee. Sadler had resisted this: "if the present Bill was referred to one, it would not become a law this Session, and the necessity of legislating was so apparent, that he was unwilling to submit to the delay of a Committee, when he considered they could obtain no new evidence on the subject".

In his long Second Reading speech, Sadler argued repeatedly that a Committee was unnecessary, but concluded by accepting that he had not convinced the House or the Government of this, and that the Bill would be referred to a Select Committee. (Lord Althorp, responding for the Government, noted that Sadler's speech made a strong case for considering legislation, but thought it did little to directly support the details of the Bill; the Government supported the Bill as leading to a Select Committee, but would not in advance pledge support for whatever legislation the Committee might recommend).

This effectively removed any chance of a Factories Regulation Act being passed before Parliament was dissolved. Sadler was made chairman of the Committee, which allowed him to make his case by hearing evidence from witnesses of Sadler's selection, on the understanding that opponents of the Bill (or of some feature of it) would then have their innings. Sadler attempted (31 July 1832) to progress his Bill without waiting for the committee's report; when this abnormal procedure was objected to by other MPs, he withdrew the Bill. Sadler, as chairman of the committee, reported the minutes of evidence on 8 August 1832, when they were ordered to be printed. Parliament was prorogued shortly afterwards: Sadler gave notice of his intention to reintroduce a Ten-Hour Bill in the next session

Ashley's Bill (1833)

Sadler, however, was not an MP in the next session: in the first election for the newly enfranchised two member constituency of Leeds he was beaten into third place by Thomas Babington Macaulay a Whig politician of national standing and John Marshall, the son of one of Leeds's leading millowners. Casting around for a new parliamentary advocate for factory reform, the short-time movement eventually secured the services of Lord Ashley, eldest son of the 6th Earl of Shaftesbury. By the time the new parliament met, public opinion (especially outside the textile districts) had been powerfully affected by 'the report of Mr Sadler's Committee'.

Extracts from this began to appear in newspapers in January 1833 and painted a picture of the life of a mill-child as one of systematic over-work and systematic brutality. The conclusion many papers drew was that Sadler's Bill should be revived and passed. However, when Ashley introduced a Bill essentially reproducing Sadler's, MPs criticised both the report (since the only witnesses heard had been Sadler's, the report was unbalanced; since witnesses had not testified on oath, doubts were expressed about the accuracy/veracity of the more lurid accounts of factory life) and Sadler's conduct. 'An air of ridicule and extravagance' had been thrown not upon factory legislation, but upon the use of Select Committees for fact-finding on factory conditions.

A Factory Commission was set up to investigate and report. Sadler and the Short Time Committees objected to any further fact-finding and attempted to obstruct the work of the Commissioners. Ashley's Bill proceeded to a Second Reading in early July 1833 (when the likely main recommendations of the Commission were known, but its report was not yet available to MPs); Ashley wanted the Bill to then be considered by a Committee of the whole House and defeated Lord Althorp's amendment to refer the Bill to a Select Committee. However at Committee stage the first point considered where the Bill differed from the Commission's was the age up to which hours of work should be limited Ashley lost (heavily) the vote on this, and left it to Althorp to pilot through a Factory Act based upon the Commission's recommendations.

1833 Factory Commission

This toured the textile districts and made extensive investigations. It wasted little time in doing so, and even less in considering its report; as with other Whig commissions of the period it was suspected to have had a good idea of its recommendations before it started work. During the course of the Factory Commission's inquiries, relationships between it and the Ten Hour Movement became thoroughly adversarial, the Ten Hour Movement attempting to organise a boycott of the commission's investigations: this was in sharp contrast with the commissioners' practice of dining with the leading manufacturers of the districts they visited.

The commission's report(Report of the Commissioners on Conditions in Factories, Parliamentary Papers, 1833, volume XX), subsequent extracts are as given in extracts from did not support the more lurid details of Sadler's report – mills were not hotbeds of sexual immorality, and beating of children was much less common than Sadler had asserted (and was dying out). Major millowners such as the Strutts did not tolerate it (and indeed were distinguished by their assiduous benevolence to their employees). Working conditions for mill-children were preferable to those in other industries: after a visit to the coal mine at Worsley one of the commission staff had written

Nonetheless, the commission reportedthat mill children did work unduly long hours, leading to
* ''Permanent deterioration of the physical constitution:''
* ''The production of disease often wholly irremediable:'' and
* ''The partial or entire exclusion (by reason of excessive fatigue) from the means of obtaining adequate education and acquiring useful habits, or of profiting by those means when afforded''
and that these ill-effects were so marked and significant that government intervention was justified but where Sadler's Bill was for a ten-hour day for all workers under eighteen, the commission recommended an eight-hour day for those under thirteen, hoping for a two-shift system for them which would allow mills to run 16 hours a day.

Althorp's Act (1833)

The Factory Act 1833 (3 & 4 Will. IV) c103 was an attempt to establish a regular working day in textile manufacture. The act had the following provisions:
*Children (ages 9–12) are limited to 48 hours per week.
*Children under 9 were not allowed to be employed in factories, except in silk mills.
*Children under 18 must not work at night (i.e. after 8.30 p.m. and before 5.30 a.m.)
*Children (ages 9–13) must not work more than 8 hours with an hour lunch break. (Employers could (and it was envisaged they would) operate a 'relay system' with two shifts of children between them covering the permitting working day; adult millworkers therefore being 'enabled' to work a 15-hour day)
*Children (ages 9–13) could only be employed if they had a schoolmaster's certificate that the previous week they had two hours of education per day (This was to be paid for by a deduction of a penny in the shilling from the children's wages. A factory inspector could disallow payment of any of this money to an 'incompetent' schoolmaster, but could not cancel a certificate issued by him.)R J Saunders "Report on the Establishment of Schools in the Factory District" in
*Children (ages 14–18) must not work more than 12 hours a day with an hour lunch break.
*Provided for routine inspections of factories and set up a Factory Inspectorate (subordinate to the Home Office) to carry out such inspections, with the right to demand entry and the authority to act as a magistrate. (Under previous Acts supervision had been by local 'visitors' (a Justice of the Peace (JP), and a clergyman) and effectively discretionary). The inspectors were empowered to make and enforce rules and regulations on the detailed application of the Act, independent of the Home Secretary
*Millowners and their close relatives were no longer debarred (if JPs) from hearing cases brought under previous Acts, but were unlikely to be effectively supervised by their colleagues on the local bench or be zealous in supervising other millowners
The Act failed to specify whether lunar or calendar months were intended where the word 'monthly' was used, and one clause limited hours of work per week where a daily limit had been intended. A short amending Act was therefore passed in February 1834

'Ineffectual attempts at legislation' (1835–1841)

The 1833 Act had few admirers in the textile districts when it came into force. The short-time movement objected to its substitution for Ashley's Bill, and hoped to secure a Ten-Hour Bill. Millowners resented and political economists deplored legislators' interference in response to public opinion, and hoped that the Act could soon be repealed (completely or in part). In 1835, the first report of the Factory Inspectors noted that the education clauses were totally impracticable, and relay working (with a double set of children, both sets working eight hours; the solution which allowed Althorp's Bill to outbid Ashley's in the apparent benefit to children) was difficult if not impracticable, there not being enough children.They also reported that they had been unable to discover any deformity produced by factory labour, nor any injury to health or shortening of the life of factory children caused by working a twelve-hour day. The inspectors appointed were also largely ineffective, simply because there were not enough of them to oversee all 4000 factories on the island. The idea of government-appointed inspectors would gain traction within the following decades, but for now, they were mostly figureheads.

Poulett Thomson's Bill (1836)

Three of the four inspectors had recommended in their first report that all children 12 or older should be allowed to work twelve hours a day. This was followed by an agitation in the West Riding for relaxation or repeal of the 1833 Act; the short-time movement alleged that workers were being 'leant on' by their employers to sign petitions for repeal, and countered by holding meetings and raising petitions for a ten-hour act. Charles Hindley prepared a draft bill limiting the hours that could be worked by any mill employing people under twenty-one, with no child under ten to be employed, and no education clauses. Hindley's bill was published at the end of the 1834-5 parliamentary session, but was not taken forward in the next session, being pre-empted by a government bill introduced by Charles Poulett Thomson, the President of the Board of Trade, allowing children twelve or over to work twelve hours a day.

The second reading of Poulett Thomson's Bill was opposed by Ashley, who denounced the bill as a feeler towards total repeal of protection for factory children. The Bill passed its second reading by a majority of only two (178–176) – a moral defeat for a government measure. Furthermore, although Poulett Thomson had opened the debate by saying that "at the present moment he was unwilling to re-open the whole factory question", Peel had said he would vote for the second reading, not because he supported the bill, but because its committee stage would allow the introduction of additional amendments to factory legislation. Poulett Thomson (eventually) abandoned the bill.

In 1837 Poulett Thomson announced his intention to bring in a factory bill; consequently Ashley, who had intended to introduce a ten-hour bill, dropped this, promising instead a ten-hour amendment to the government bill. No progress had been made with the government bill when the death of King William, and the consequent dissolution of parliament, brought the session to an end.

Fox Maule's Bill (1838)

In the 1838 session another government factory bill was introduced by Fox Maule Under-Secretary of State for the Home Department. Children in silk mills were not to work more than ten hours a day (but this was not backed up by any certification of age). Otherwise, the bill made no changes to age limits or hours of work, but repealed the education clauses of the 1833 Act, replacing them with literacy tests. After a transitional period, children who could not read the New Testament were not to be employed more than nine hours a day; children who could not read an easy reader to be published by the Home Secretary could not be employed.

His political opponents mocked the thought of Lord John Russell turning his undoubted talents to the production of a reading primer, and it was soon announced that once the Bill went into committee it would be amended to restore the 1833 education clauses. The second reading of the bill was scheduled for 22 June, but in early June Russell announced that the bill had been abandoned for the session.

Ashley denounces government complacency

On 22 June, when the government intended to progress a bill on Irish tithes, Ashley forestalled them, moving the second reading of the factory bill. He complained of the evasive conduct of ministers and government apathy and complacency on factory reform. Peel (who normally, even in opposition, deprecated obstruction of government business by backbenchers{{efn, In this case and presumably on Peel's instructions, obstruction seems to have been avoided: once the debate on Ashley's motion was complete the reading of the Irish tithes bill was unopposed) supported Ashley: he held very different views on the issue from Ashley, but the issue was important, contentious, and should not be evaded : "so long as ineffectual attempts at legislation remained on the table of the house, the excitement of the manufacturing districts would continue to be kept up"{{cite news, title=Factories, work=Evening Standard, date=23 June 1838, location=London, page=4: not to be found in the on-line Hansard,; that jumps from volume 42 to volume 44 {{efn, 1838 had seen the first flowering of Chartism in the manufacturing districts, which would lead to monster meetings at Kersal Moor (September 1838) and Peep Green (Hartshead Moor)(October 1838): the speeches at those meetings suggest however that the New Poor Law was the major immediate issue, rather than factory legislation. Ashley's motion was lost narrowly 111 to 119.

Ashley later attacked the government and its complacency and connivance at the shortcomings in the current Factory Act identified by the government's own Factory Inspectors:{{cite journal, title=Children in Factories, journal=Hansard House of Commons Debates, date=20 July 1838, volume=44, pages=cc383-443, url=http://hansard.millbanksystems.com/commons/1838/jul/20/children-tn-factories, access-date=18 August 2015
* Althorp's Act had claimed superiority over Ashley's Bill of 1833 because of its shorter working hours for children and its provision for education. Those provisions had been violated from the outset, and continued to be violated, and the government connived at those violations: "notwithstanding the urgent representations and remonstrances of their own inspectors, the Government had done nothing whatever to assist them in the discharge of their duties"
* Millowners sat on the bench and adjudicated in their own cases (because Althorp's Act had repealed the provisions in Hobhouse's Act forbidding this): they countersigned surgeon's certificates for children employed in their own factory .{{efn, age certificates for children could be issued by surgeons other that those approved by a factory inspector, provided the certificate was counter-signed by a magistrate One factory inspector had reported a case of a millowner sitting as magistrate on a case brought against his own sons, as tenants of a mill he owned.
* Magistrates had the power to mitigate the penalties specified in the Act. The inspectors reported that magistrates habitually did so, and to an extent which defeated the law; it was more profitable to break the law and pay the occasional fine than to comply with the Act.

"After these representations .. by his own inspectors, how could the noble Lord opposite reconcile it with his conscience as an individual, and with his public duty as a Minister of the Crown, during the whole course of his administration, never to have brought forward any measure for the removal of so tremendous an evil?"

* The education clauses were not observed in one mill in fifty; where they were, the factory inspectors reported, "the schooling given is a mere mockery of instruction"; vice and ignorance, and their natural consequences, misery and suffering, were rife among the population of the manufacturing districts. "Would the noble Lord opposite venture to say that the education of the manufacturing classes was a matter of indifference to the country at large?"

"He wanted them to decide whether they would amend, or repeal, or enforce the Act now in existence; but if they would do none of these things, if they continued idly indifferent, and obstinately shut their eyes to this great and growing evil, if they were careless of the growth of an immense population, plunged in ignorance and vice, which neither feared God, nor regarded man, then he warned them that they must be prepared for the very worst result that could befall a nation."

Fox Maule tries again (1839–41)

In the 1839 session, Fox Maule revived the 1838 Bill with alterations. The literacy tests were gone, and the education clauses restored. The only other significant changes in the scope of the legislation were that working extra hours to recover lost time was now only permitted for water-powered mills, and magistrates could not countersign surgeon's certificates if they were mill-owners or occupiers (or father, son, or brother of a mill-owner or occupier). Details of enforcement were altered; there was no longer any provision for inspectors to be magistrates ''ex officio'', sub-inspectors were to have nearly the same enforcement powers as inspectors; unlike inspectors they could not examine witnesses on oath, but they now had the same right of entry into factory premises as inspectors.

Declaring a schoolmaster incompetent was now to invalidate certificates of education issued by him, and a clause in the bill aimed to make it easier to establish and run a school for factory children; children at schools formed under this clause were not to be educated in a creed objected to by their parents.

The bill, introduced in February, did not enter its committee stage until the start of July{{cite journal, title=Factories, journal=Hansard House of Commons Debates, date=1 July 1839, volume=48, pages=cc1063-94, url=http://hansard.millbanksystems.com/commons/1839/jul/01/factories#S3V0048P0_18390701_HOC_18, access-date=18 August 2015
In committee, a ten-hour amendment was defeated 62–94, but Ashley moved and carried 55-49 an amendment removing the special treatment of silk mills. The government then declined to progress the amended bill.

No attempt was made to introduce a factory bill in 1840; Ashley obtained a Select Committee on the working of the existing Factory Act, which took evidence, most notably from members of the Factory Inspectorate, throughout the session with a view to a new bill being introduced in 1841. Ashley was then instrumental in obtaining a Royal Commission on the employment of children in mines and manufactures, which eventually reported in 1842 (mines) and 1843 (manufactures): two of the four Commissioners had served on the 1833 Factory Commission; the other two were serving factory inspectors.

In March 1841 Fox Maule introduced a Factory Bill and a separate Silk Factory Bill. The Factory Bill provided that children were now not to work more than seven hours a day; if working before noon they couldn't work after one p.m.{{cite news, title=Factories Bill, work=Yorkshire Gazette, date=1 May 1841, page=7 The education clauses of the 1839 Bill were retained. 'Dangerous machinery' was now to be brought within factory legislation. Both the Factory and Silk Factory bills were given unopposed second readings on the understanding that all issues would be discussed at committee stage, both were withdrawn before going into committee, the Whigs having been defeated on a motion of no confidence, and a General Election imminent.

Graham's Factory Education Bill (1843)

The Whigs were defeated in the 1841 general election, and Sir Robert Peel formed a Conservative government. Ashley let it be known that he had declined office under Peel because Peel would not commit himself not to oppose a ten-hour bill; Ashley therefore wished to retain freedom of action on factory issues. In February 1842, Peel indicated definite opposition to a ten-hour bill, and Sir James Graham , Peel's Home Secretary, declared his intention to proceed with a bill prepared by Fox Maule, but with some alterations. In response to the findings of his Royal Commission, Ashley saw through Parliament a Mines And Collieries Act banning the employment of women and children underground;{{cite journal, title=Employment of Women and Children in Mines and Collieries, journal=Hansard House of Commons Debates, date=7 June 1842, volume=63, pages=cc1320-64, url=http://hansard.millbanksystems.com/commons/1842/jun/07/employment-of-women-and-children-in, access-date=19 August 2015 the measure was welcomed by both front benches, with Graham assuring Ashley "that her Majesty's Government would render him every assistance in carrying on the measure".
In July, it was announced that the Government did not intend any modification to the Factory Act in that session.

The education issue and Graham's bill

The Royal Commission had investigated not only the working hours and conditions of the children, but also their moral state. It had found much of concern in their habits and language, but the greatest concern was that "the means of secular and religious instruction.. are so grievously defective, that, in all the districts, great numbers of Children and Young Persons are growing up without any religious, moral, or intellectual training; nothing being done to form them to habits of order, sobriety, honesty, and forethought, or even to restrain them from vice and crime."2nd Report of the Commission on the Employment of Children (Trades and Manufactures), (1843) Parliamentary Papers volume XIII, pp 195–204 as quoted in {{cite book, editor1-last=Royston Pike, editor1-first=E, title=Human Documents of the Industrial Revolution, url=https://archive.org/details/humandocumentsof0000pike, url-access=registration, date=1966, publisher=George Allen & Unwin Ltd, location=London, page
204–208
isbn=9780049420601 {{efn, A member of the Commission separately suggested, in his capacity as Factory Inspector, that the Plug Plot Riots and other Chartist disturbances in Ashton-under-Lyne could have been averted had more attention been paid in the past to the education of the humbler classes of the district by their superiors). It is unclear how far this political aspect drove the education initiative. For the record, the Chartist ''Northern Star'' supported Graham's education clauses; education and intellectual culture were the means "by which the working man comes to know something of the framework of society, and to understand what his rights are, as a first step towards the assertion of them"{{cite news, title=The Government Factory Bill, work=Northern Star and Leeds General Advertiser, date=25 March 1843, page=20 In 1843, Ashley initiated a debate on "the best means of diffusing the benefits and blessings of a moral and religious education among the working classes..."{{cite journal, title=Condition and Education of the Poor, journal=Hansard House of Commons Debates, date=28 February 1843, volume=67, pages=cc47-114, url=http://hansard.millbanksystems.com/commons/1843/feb/28/condition-and-education-of-the-poor, access-date=22 August 2015

Responding, Graham stressed that the issue was not a party one (and was borne out on this by the other speakers in the debate); although the problem was a national one, the government would for the moment bring forward measures only for the two areas of education in which the state already had some involvement; the education of workhouse children and the education of factory children. The measures he announced related to England and Wales; Scotland had an established system of parochial schools run by its established church, with little controversy, since in Scotland there was no dissent on doctrine, only on questions of discipline.

In the 'education clauses' of his Factory Education Bill of 1843, he proposed to make government loans to a new class of government factory schools effectively under the control of the Church of England and the local magistrates. The default religious education in these schools would be Anglican, but parents would be allowed to opt their children out of anything specifically Anglican; if the opt-out was exercised, religious education would be as in the best type of Dissenter-run schools.

Once a trust school was open in a factory district, factory children in that district would have to provide a certificate that they were being educated at it or at some other school certified as 'efficient'. The 'labour clauses' forming the other half of the bill were essentially a revival of Fox Maule's draft; children could work only in the morning or in the afternoon, but not both. There were two significant differences; the working day for children was reduced to six and a half hours, and the minimum age for factory work would be reduced to eight. Other clauses increased penalties and assisted enforcement.

Reaction, retreats, and abandonment

A Second Reading debate was held to flesh out major issues before going into committee.{{cite journal, title=Factories – Education, journal=Hansard House of Commons Debates, date=24 March 1843, volume=67, pages=cc1411-77, url=http://hansard.millbanksystems.com/commons/1843/mar/24/factories-education, access-date=23 August 2015 At Lord John Russell's urging, the discussion was temperate, but there was considerable opposition to the proposed management of the new schools, which effectively excluded ratepayers (who would repay the loan and meet any shortfall in running costs) and made no provision for a Dissenter presence (to see fair play). The provisions for appointment of schoolmasters were also criticised; as they stood they effectively excluded Dissenters.

Out of Parliament, the debate was less temperate; objections that the Bill had the effect of strengthening the Church became objections that it was a deliberate attack on Dissent, that its main purpose was to attack Dissent, and that the Royal Commission had deliberately and grossly defamed the population of the manufacturing districts to give a spurious pretext for an assault on Dissent. Protest meetings were held on that basis throughout the country, and their resolutions condemning the bill and calling for its withdrawal were supported by a campaign of organised petitions: that session Parliament received 13,369 petitions against the bill as drafted with a total of 2,069,058 signatures.{{cite news, title=Petitions Against the Factory Bill, work=Manchester Courier and Lancashire General Advertiser, date=19 August 1843, page=5 (For comparison, in the same session there were 4574 petitions for total repeal of the Corn Laws, with a total of 1,111,141 signatures.)

Lord John Russell drafted resolutions calling for modification of the bill along the lines suggested in Parliament; the resolutions were denounced as inadequate by the extra-parliamentary opposition. Graham amended the educational clauses, but this only triggered a fresh round of indignation meetings and a fresh round of petitions (11,839 petitions and 1,920,574 signatures). Graham then withdrew the education clauses but this did not end the objections,{{cite journal, title=State of Public Business, journal=Hansard House of Commons Debates, date=17 July 1843, volume=70, pages=cc1215-23, url=http://hansard.millbanksystems.com/commons/1843/jul/17/state-of-public-business, access-date=30 August 2015 since it did not entirely restore the ''status quo ante'' on education.

Indeed the education requirements of the 1833 Act now came under attack, the ''Leeds Mercury'' declaring education was something individuals could do for themselves "under the guidance of natural instinct and self-interest, infinitely better than Government could do for them".{{cite news, title=Sir James Graham's Third Edition. Labour clauses – Compulsory Education, work=Leeds Mercury, date=1 July 1843, page=4 Hence "''All Government interference to'' COMPEL ''Education is wrong''" and had unacceptable implications: "If Government has a right to compel Education, it has right to ''compel'' RELIGION !"
Although as late as 17 July Graham said he intended to get the bill though in the current session, three days later the bill was one of those Peel announced would be dropped for that session.

Factories Act 1844 ('Graham's Factory Act')

In 1844 Graham again introduced a Bill to bring in a new Factory Act and repeal the 1833 Factory Act. The Bill gave educational issues a wide berth, but otherwise largely repeated the 'labour clauses' of Graham's 1843 Bill, with the important difference that the existing protection of young persons (a twelve-hour day and a ban on night working) was now extended to women of all ages. In Committee, Lord Ashley moved an amendment to the bill's clause 2, which defined the terms used in subsequent (substantive) clauses; his amendment changed the definition of 'night' to 6 p.m. to 6 a.m. – after allowing 90 minutes for mealbreaks only ten-and-a-half hours could be worked; this passed by nine votes. On clause 8, limiting the hours of work for women and young persions, the motion setting a twelve-hour day was defeated (by three votes: 183–186) but Lord Ashley's motion setting the limit at ten hours was also defeated (by seven votes:181–188).{{cite journal, title=Hours of Labour in Factories, journal=Hansard House of Commons Debates, date=22 March 1844, volume=73, issue=cc1371-464, url=http://hansard.millbanksystems.com/commons/1844/mar/22/hours-of-labour-in-factories, access-date=1 September 2015

Voting on this Bill was not on party lines, the issue revealing both parties to be split into various factions. On clause 8, both 'ten' and 'twelve' hours were rejected (with exactly the same members voting) because five members voted against both 'ten' and 'twelve'.
Faced with this impasse, and having considered and rejected the option of compromising on some intermediate time such as eleven hours,{{efn, of the five MPs who voted 'against both 'ten' and 'twelve', three seem to have given no explanation, of the other two William Aldam spoke in support of an eleven-hour day in the 22 March debate, William Ewart spoke in favour of an eleven-hour compromise in the 25 March debate Graham withdrew the Bill, preferring to replace it by a new one which amended, rather than repealed, the 1833 Act.{{cite journal, title=Hours of Labour in Factories, journal=Hansard House of Commons Debates, date=25 March 1844, volume=73, pages=cc1482-525, url=http://hansard.millbanksystems.com/commons/1844/mar/25/hours-of-labour-in-factories, access-date=1 September 2015

A Radical MP warned the government during the debate on clause 8 that Ashley's first victory could never be undone by any subsequent vote: morally the Ten-Hour question had been settled;{{rp, c1402 Government might delay, but could not now prevent, a Ten-hour Act. However, the new bill left the 1833 definition of 'night' unaltered (and so gave no opportunity for redefinition) and Lord Ashley's amendment to limit the working day for women and young persons to ten hours was defeated heavily (295 against, 198 for), it having been made clear that the Ministers would resign if they lost the vote.

As a result, the Factory Act of 1844 (citation 7 & 8 Vict c. 15) again set a twelve-hour day,{{cite book, last1=Hutchins, first1=B L, last2=Harrison, first2=A, title=A History of Factory Legislation, date=1903, publisher=P King and Sons, location=Westminster, url=https://archive.org/details/historyoffactory00hutc, access-date=16 July 2014 its main provisions being:{{sfnp, Hutchins, Harrison, 1911, p=
*Children 9–13 years could work for 9 hours a day with a lunch break.
*Ages must be verified by surgeons.
*Women and young people now worked the same number of hours. They could work for no more than 12 hours a day during the week, including one and a half hours for meals, and 9 hours on Sundays. They must all take their meals at the same time and could not do so in the workroom
*Time-keeping to be by a public clock approved by an inspector
*Some classes of machinery: ''every fly-wheel directly connected with the steam engine or water-wheel or other mechanical power, whether in the engine-house or not, and every part of a steam engine and water-wheel, and every hoist or teagle,{{efn, dialect word for 'hoist' (OED) near to which children or young persons are liable to pass or be employed, and all parts of the mill-gearing'' (this included power shafts) ''in a factory'' were to be "securely fenced."
*Children and women were not to clean moving machinery.
*Accidental death must be reported to a surgeon and investigated; the result of the investigation to be reported to a Factory Inspector.
*Factory owners must wash factories with lime every fourteen months.
*Thorough records must be kept regarding the provisions of the Act and shown to the inspector on demand.
*An abstract of the amended Act must be hung up in the factory ''so as to be easily read'', and show (amongst other things) names and addresses of the inspector and sub-inspector of the district, the certifying surgeon, the times for beginning and ending work, the amount of time and time of day for meals.
*Factory Inspectors no longer had the powers of JPs but (as before 1833) millowners, their fathers, brothers and sons were all debarred (if magistrates) from hearing Factory Act cases.

Factories Act 1847

{{main, Factories Act 1847
After the collapse of the Peel administration which had resisted any reduction in the working day to less than 12 hours, a Whig administration under Lord John Russell came to power. The new Cabinet contained supporters and opponents of a ten-hour day and Lord John himself favoured an eleven-hour day. The Government therefore had no collective view on the matter; in the absence of Government opposition, the Ten Hour Bill was passed, becoming the Factories Act 1847 (citation 10 & 11 Vict c. 29). This law (also known as the Ten Hour Act) limited the work week in textile mills (and other textile industries except lace and silk production) for women and children under 18 years of age. Each work week contained 63 hours effective 1 July 1847 and was reduced to 58 hours effective 1 May 1848. In effect, this law limited the workhours only for women and children to 10 hours which earlier was 12 hours.

This law was successfully passed due to the contributions of the Ten Hours Movement. This campaign was established during the 1830s and was responsible for voicing demands towards limiting the work week in textile mills. The core of the movement was the 'Short Time Committees' set up (by millworkers and sympathisers) in the textile districts, but the main speakers for the cause were Richard Oastler (who led the campaign outside Parliament) and Lord Ashley, 7th Earl of Shaftesbury (who led the campaign inside Parliament). John Fielden, although no orator, was indefatigable in his support of the cause, giving generously of his time and money and – as the senior partner in one of the great cotton firms – vouching for the reality of the evils of a long working day and the practicality of shortening it.

Factories Act 1850 (the 'Compromise Act')

The Acts of 1844 and 1847 had reduced the hours per day which any woman or young person could work but not the hours of the day within which they could do that work (from 5:30 a.m. to 8:30 p.m.). Under the 1833 Act millowners (or some of them) had used a 'relay system' so that the mill could operate all the permitted hours without any protected person exceeding their permitted workday. The 1833 Act had hoped that two sets of children would be employed and each work a full half-day (the 'true relay' system, which left the other halfday free for education). Instead, some mills operated a 'false relay' system in which the protected persons worked split shifts. The false relay system was considered objectionable both because of the effect on the protected persons {{efn, both because thrown out of mill for a couple of hours in all weathers, and because releasing teenagers from factory discipline and leaving them to their own devices for a couple of hours in the proximity of members of the opposite sex (and possibly of dram-shops) was inconsistent with Victorian morals and because an inspector (or other millowners) could relatively easily monitor the hours a mill ran; it was much more difficult if not impossible to check the hours worked by an individual (as an inspector observed "the lights in the window will discover the one but not the other"){{sfnp, Hutchins, Harrison, 1911, p= Section 26 of the 1844 Act required that the hours of work of all protected persons " shall be reckoned from the time when any child or young person shall first begin to work in the morning in such factory." but nothing in it or in the 1847 Act clearly prohibited split shifts (although this had been Parliament's intention).{{efn, The legal issues are laid out concisely and in layman's language in a newspaper report of the 1849 prosecution of the employers of Isabella Robinson 15-year-old cotton spinner at a mill in Colne "last Tuesday she began to work at 6 am; she worked until 6:15 , then she gave over working and someone else worked in her place; she returned to work at 8:30 and worked until 12:30, when she went to dinner and was away an hour; she came back at 1:30, and worked till 7:15" The factory inspector for Scotland considered split shifts to be legal; the inspector for Bradford thought them illegal and his local magistrates agreed with him: in Manchester the inspector thought them illegal but the magistrates did not. In 1850 the Court of Exchequer held that the section was to be too weakly worded to make relay systems illegal.{{efn, prompting ''Punch'' to suggest it would be more appropriate to refer to the ''Unsatis''-Factory Act Lord Ashley sought to remedy this by a short declaratory Act restoring the status quo but felt it impossible to draft one which did not introduce fresh matter (which would remove the argument that there was no call for further debate). The Home Secretary Sir George Grey was originally noticeably ambivalent about Government support for Ashley's Bill: when Ashley reported his difficulties to the House of Commons, Grey announced an intention to move amendments in favour of a scheme (ostensibly suggested by a third party) which established a 'normal day' for women and young persons by setting the times within which they could work so tightly that they were also the start and stop times if they were to work the maximum permitted hours per day. Grey's scheme increased the hours that could be worked per week, but Ashley (uncertain of the outcome of any attempt to re-enact a true Ten Hours Bill) decided to support itletter Lord Ashley , dated 7 May , to "The Short Time Committees of Lancashire and Yorkshire"{{cite news, title=Lord Ashley and the Factory Act, work=London Standard, date=9 May 1850 and Grey's scheme was the basis for the 1850 Act (citation 13 & 14 Vict c. 54). The Short Time Committees had previously been adamant for an effective Ten-hour Bill; Ashley wrote to them, noting that he acted in Parliament as their friend, not their delegate, explaining his reasons for accepting Grey's "compromise", and advising them to do so also. They duly did, significantly influenced by the thought that they could not afford to lose their friend in Parliament. The key provisions of the 1850 Act were :{{sfnp, Hutchins, Harrison, 1911, p=
*Women and young persons could only work from 6 a.m. to 6 p.m. or – in winter, and subject to approval by a factory inspector- {{rp, 43 7 a.m. to 7 p.m.: since they were to be allowed 90 minutes total breaks during the day, the maximum hours worked per day increased to 10.5
*All work would end on Saturday at 2 p.m.
*The work week was extended from 58 hours to 60 hours.
Various public meetings in the textile districts subsequently passed motions regretting that the 58-hour week had not been more stoutly defended, with various stalwarts of the Ten-Hour Movement ( various Cobbetts and Fieldens (John Fielden now being dead) and Richard Oastler) offering their support and concurring with criticism of Ashley's actions, but nothing came of this: the meetings were poorly attended (that at Manchester was attended by about 900) and the Ten-Hour Movement had now effectively run its course.

Children (8–13) were not covered by this Act: it had been the deliberate intention of the 1833 Act that a mill might use two sets of children on a relay system and the obvious method of doing so did not require split shifts. A further Act of 1853 set similar limits on the hours within which children might work.

Factories Act 1856

In April 1855 a National Association of Factory Occupiers was formed "to watch over factory legislation with a view to prevent any increase of the present unfair and injudicious enactments". The 1844 Act had required that "mill gearing" – which included power shafts – should be securely fenced. Magistrates had taken inconsistent views as to whether this applied where the "mill gearing" was not readily accessible; in particular where power shafting ran horizontally well above head height. In 1856, the Court of Queen's Bench ruled that it did. In April 1856, the National Association of Factory Occupiers succeeded in obtaining an Act reversing this decision: mill gearing needed secure fencing only of those parts with which women, young persons, and children were liable to come in contact. (The inspectors feared that the potential hazards in areas they did not normally access might be obvious to experienced men, but not be easily appreciated by women and children who were due the legislative protection the 1856 Act had removed, especially given the potential severe consequences of their inexperience. An MP speaking against the Bill was able to give multiple instances of accidents to protected persons resulting in death or loss of limbs – all caused by unguarded shafting with which they were supposedly not liable to come into contact – despite restricting himself to accidents in mills owned by Members of Parliament (so that he could be corrected by them if had misstated any facts). (Dickens thereafter referred to the NAFO as the ''National Association for the Protection of the Right to Mangle Operatives''.{{cite book, last1=Martineau, first1=Harriet, title=The factory controversy; a warning against meddling legislation, date=1855, publisher=National Association of Factory Operatives, location=Manchester, url=https://archive.org/details/factorycontrover00martuoft, access-date=30 August 2015{{rp, 37 Harriet Martineau criticised Dickens for this, arguing that mangling was the result of workers not being careful and: "If men and women are to be absolved from the care of their own lives and limbs, and the responsibility put upon anybody else by the law of the land, the law of the land is lapsing into barbarism"{{rp, 47)) For other parts of the mill gearing any dispute between the occupier and the inspector could be resolved by arbitration.{{sfnp, Hutchins, Harrison, 1911, p= The arbitration was to be by a person skilled in making the machinery to be guarded; the inspectors however declined to submit safety concerns to arbitration by those "who look only to the construction and working of the machinery, which is their business, and not to the prevention of accidents, which is not their business" {{sfnp, Hutchins, Harrison, 1911, p=

Factories Act Extension Act 1867

In virtually every debate on the various Factories Bills, opponents had thought it a nonsense to pass legislation for textile mills when the life of a mill child was much preferable to that of many other children: other industries were more tiring, more dangerous, more unhealthy, required longer working hours, involved more unpleasant working conditions, or (this being Victorian Britain) were more conducive to lax morals. This logic began to be applied in reverse once it became clear that the Ten Hours Act had had no obvious detrimental effect on the prosperity of the textile industry or on that of millworkers. Acts were passed making similar provisions for other textile trades: bleaching and dyeworks (1860 – outdoor bleaching was excluded), lace work (1861), calendering (1863), finishing (1864).{{sfnp, Hutchins, Harrison, 1911, p= A further Act in 1870 repealed these acts and brought the ancillary textile processes (including outdoor bleaching) within the scope of the main Factory Act.
In 1864 the Factories Extension Act was passed: this extended the Factories Act to cover a number of occupations (mostly non-textile): potteries (both heat and exposure to lead glazes were issues), lucifer match making ('phossie jaw') percussion cap and cartridge making, paper staining and fustian cutting.{{sfnp, Hutchins, Harrison, 1911, p= In 1867 the Factories Act was extended to all establishments employing 50 or more workers by another Factories Act Extension Act. An Hours of Labour Regulation Act applied to 'workshops' (establishments employing less than 50 workers); it subjected these to requirements similar to those for 'factories' (but less onerous on a number of points e.g.: the hours within which the permitted hours might be worked were less restrictive, there was no requirement for certification of age) but was to be administered by local authorities, rather than the Factory Inspectorate.{{sfnp, Hutchins, Harrison, 1911, p= There was no requirement on local authorities for enforcement (or penalties for non-enforcement) of legislation for workshops. The effectiveness of the regulation of workshops therefore varied from area to area; where it was effective, a blanket ban on Sunday working in workshops was a problem for observant Jews. The Factory and Workshop Act 1870 removed the previous special treatments for factories in the printing, dyeing and bleaching industries; while a short Act of 1871 transferred responsibility for regulation of workshops to the Factory Inspectorate, but without an adequate increase in the Inspectorates's resources.; a separate Act allowed Sunday working by Jews.

Factories (Health of Women, &c.) Act (1874)

(''37 & 38 Vict. c. 44'')

The newly-legalised trade unions had as one of their aims a reduction in working hours, both by direct concession by employers and by securing legislation. The 1873 Trades Union Congress (TUC) could congratulate itself on "a general concession of the 'nine-hour day' in all the leading engineering establishments of the kingdom" but regretted that a Private Member's Bill introduced by A. J. Mundella seeking to reduce the hours worked by women and children in textile industries had not succeeded, although the Government had responded by setting up a commission on the workings of the Factory Acts.{{cite news, title=Trades Union Congress at Leeds, work=Sheffield Daily Telegraph, date=14 January 1873, page=3 (The TUC had had to support the measure through a committee also containing non-unionists; Lord Shaftesbury (as Ashley had become) had declined to support any measure brought forward on a purely trade union basis.)

Mundella again introduced a nine-hour bill in 1873; he withdrew this when the government did not allow enough time for debate; he reintroduced it in 1874, but withdrew it when the government brought forward its own bill, which became the Factories (Health of Women, &c.) Act. This gave women and young persons in textile factories (silk mills now lost their previous special treatment) a working day of ten hours on weekdays (twelve hours broken into sessions of no more than four and a half hours by two meal breaks of at least an hour); on Saturday six hours could be spent on manufacturing processes, and another half-hour on other duties (such as cleaning the workplace and machinery). The provisions for children now applied to 13-year-olds, and (over a two-year period) the minimum age for children was to increase to ten.

Shaftesbury's valedictory review

Shaftesbury spoke in the Lords Second Reading debate; thinking it might well be his last speech in Parliament on factory reform, he reviewed the changes over the forty-one years it had taken to secure a ten-hour-day, as this bill at last did. In 1833, only two manufacturers had been active supporters of his bill; all but a handful of manufacturers supported the 1874 bill. Economic arguments against reducing working hours had been disproved by decades of experience. Despite the restrictions on hours of work, employment in textile mills had increased (1835; 354,684, of whom 56,455 under 13: in 1871, 880,920 of whom 80,498 under 13), but accidents were half what they had been and 'factory cripples' were no longer seen. In 1835, he asserted, seven-tenths of factory children were illiterate; in 1874 seven-tenths had "a tolerable, if not a sufficient, education". Furthermore, police returns showed "a decrease of 23 percent in the immorality of factory women". The various protective acts now covered over two and a half million people.{{cite journal, title=Second Reading, journal=Hansard House of Lords Debates, date=9 July 1874, volume=220, pages=cc1326-40

During the short-time agitation he had been promised "Give us our rights, and you will never again see violence, insurrection, and disloyalty in these counties." And so it had proved: the Cotton Famine had thrown thousands out of work, with misery, starvation, and death staring them in the face; but, "with one or two trifling exceptions, and those only momentary", order and peace had reigned.

By legislation you have removed manifold and oppressive obstacles that stood in the way of the working man's comfort, progress, and honour. By legislation you have ordained justice, and exhibited sympathy with the best interests of the labourers, the surest and happiest mode of all government. By legislation you have given to the working classes the full power to exercise, for themselves and for the public welfare, all the physical and moral energies that God has bestowed on them; and by legislation you have given them means to assert and maintain their rights; and it will be their own fault, not yours, my Lords, if they do not, with these abundant and mighty blessings, become a wise and an understanding people.

Factory and Workshop Act 1878 (the 'Consolidation Act')

In the debates on Mundella's bills and the 1874 Act, it had been noted that years of piece-meal legislation had left factory law in an unsatisfactory and confusing state;{{efn, According to the then Chief Inspector of Factories the more recent Acts "were necessarily incomplete and experimental ... by the time the last of these several Acts had received the Royal assent there existed a perfect chaos of regulations – all good in themselves when enacted – all having a direct purpose, which most of the trades have outlived, and which required constant care and consideration to prevent an application of them which would have imperiled that impartiality and that uniformity of administration which are absolutely essential to secure harmonious and cheerful co-operation". The lace manufacturers of Nottingham told the 1875 Royal Commission that workers in the industry fell under one (or none) of three different acts; all branches customarily worked a 54-hour week but most workers – where the Act of 1874 did not apply – preferred to breakfast before starting work: a work pattern incompatible with the Act. the government had spoken of the need to consolidate and extend factory law by a single Act replacing all previous legislation, but had not felt itself able to allocate the necessary legislative time. In March 1875, a Royal Commission (headed by Sir James Fergusson) was set up to look at the consolidation and extension of factory law. It took evidence in the principal industrial towns, and published its report in March 1876. It recommended consolidation of legislation by a single new Act. The new Act should include workplaces in the open air, and carrying, washing and cleaning; however mines and agriculture should be excluded. Work by protected persons should be within a twelve-hour window (between 6 am and 7 pm: exceptionally for some industries the window could be 8 am to 8 pm). Within that window: in factories two hours should be allowed for meals and no work session should exceed four and a half hours; in workshops work sessions should not exceed five hours and meal breaks should total at least one and a half hours.{{cite news, title=The Factory Acts : Report of the Royal Commission, work=Evening Standard, date=17 March 1876, location=London, page=3 Sunday working should be permitted where both worker and employer were Jewish. All children should attend school from five until fourteen; they should not be allowed to attend half-time, nor be employed under the new Act, until ten. From ten to fourteen employment would be conditional upon satisfactory school attendance and educational achievement.

The government announced that the report had been produced too late for legislation in the current parliamentary session, but legislation would be introduced in the following one. A bill was given a First Reading in April 1877, but made no further progress;{{efn, Irish members were making their presence felt by obstructing progress with legislation across the board: the Canal Boats Act 1877 was, however, passed. This addressed a recommendation of the Factory and Workshop Commission, which had taken evidence on the living conditions of barge children, but the Act led to the registration and regulation of canal boats as residences, rather than as workplaces. at the end of July it was postponed to the following year. In 1878, the Bill was given a higher priority: it had its first reading as soon as Parliament convened in January; the Second Reading debate was held on 11 February and it entered Committee stage on 21 February; the Third Reading in the Commons was given at the end of March.

Provisions of the Act

The Factory and Workshop Act 1878 (41 & 42 Vict. c. 16) replaced all the previous Acts (it listed sixteen acts repealed in their entirety) by a single Act of some hundred and seven clauses. The Chief Inspector of Factories described it as much less restrictive than the legislation it replaced: "The hard and fast line rawn by the previous Actsis now an undulating and elastic one, drawn to satisfy the absolute necessities and customs of different trades in different parts of the kingdom."

The protected persons fell into three categories:{{cite book, last1=Redgrave, first1=Jasper A, last2=Redgrave, first2=Alexander, title=The factory & workshop acts, 1878 to 1891: with introduction, copious notes, and an elaborate index, date=1893, publisher=Shaw, location=London, edition=5, url=https://archive.org/details/b21731238
* 'Children' (aged 10–14, but a child of 13 who had met required levels of academic attainment and had a good school attendance record could be employed as a 'young person')
* 'Young persons' (aged 14–18, of either sex: as noted above 13-year-olds satisfying educational requirements could be employed as young persons)
* 'Women' (females aged over 18; it had been urged that women did not require protection, and their inclusion in factory legislation deterred their employment. The countering arguments (that married women required protection from husbands, and unless unmarried women were subject to the same protection, Parliament would be legislating to promote immorality; and that the restrictions were in the interests of public health, since they ensured some maternal attention for the children of working women) had generally prevailed.)

The premises being regulated were now separated into five categories:
Factories fell into two types;
* 'textile factories' – those within the scope of the 1874 Act
* 'non-textile factories' – workplaces carrying out a number of specified processes ((textile) print works, bleaching and dyeing works, earthenware works (excluding brickworks), lucifer match works, percussion cap works, cartridge works, paper staining works, fustian cutting works, blast furnaces, copper mills, iron mills, foundries, metal and india-rubber works, paper mills, glass works, tobacco factories, letterpress printing works, bookbinding works) and additionally any workplace in which mechanical power was used (replacing the former distinction between factory and workshop on the basis on the number of employees)

Workshops were places in which the manufacture, repair or finishing of articles were carried out as a trade without the use of mechanical power and to which the employer controlled access (it was irrelevant whether these operations were carried out in the open air, and shipyards, quarries and pit banks were specifically scheduled as workshops, unless factories because mechanical power was used). Laundries (originally in the Bill) were excluded from the final Act; in Ireland much laundry work was carried out in convents and Irish members objected to inspection of convents by an (allegedly) exclusively Protestant inspectorate. {{efn, The Home Secretary assured the Commons that religion was not a consideration when appointing to the inspectorate; upon inquiry he found that the inspector for Manchester was a Catholic. Three types of workshop were distinguished:
* Workshops
* Workshops not employing protected persons other than women
* Domestic workshops (workshops carried out in a private house, room etc by members of the family living there)

The Act excluded domestic workshops carrying out straw-plait making, pillow lace making or glove-making and empowered the Home Secretary to extend this exemption. The Act also excluded domestic workshops involving non-strenuous work carried out intermittently and not providing the principal source of income of the family.

Requirements and enforcement arrangements were most stringent for textile factories, least stringent for domestic workshops (and the inspectorate had no powers to secure entry into dwellings). The Act gave the Home Secretary some latitude to vary the requirements for specific industries (but not individual workplaces) to accommodate existing practices where these were not detrimental to the underlying purpose of the Act.

The Act followed the recommendations of the Commission by setting a limit of {{frac, 56, 1, 2 hours on the hours worked per week by women and young persons in textile factories, 60 hours in non-textile factories and workshops (except domestic workshops, where there was no restriction on the working hours of women), but allowing greater flexibility on how those hours were worked for non-textile factories and workshops. The ban on Sunday working (and on late working on Saturday) was modified to apply instead to the Jewish Sabbath where both employer and employees were Jewish. Except in domestic workshops, protected persons were to have two full holidays and eight half-holidays The full holidays would normally be Christmas Day and Good Friday, but other holidays could be substituted for Good Friday (in Scotland and for all-Jewish workplaces, substitution for Christmas Day was allowed; Ireland kept Saint Patrick's Day as a holiday). Half holidays could be combined to give additional full-day holidays; it had to be clarified later that the Act's definition of a half-holiday as "at least half" of a full day's employment "on some day other than Saturday" was to give the minimum duration of a half-holiday, not to prohibit one being taken on a Saturday.

Children were not to be employed under the age of ten, and should attend school half-time until fourteen (or until thirteen if they had a good record of school attendance and satisfactory scholastic achievement). (In Scotland, for factory children only, this overrode attempts by local school boards to set standards of scholastic attainment to be met before a child could cease full-time schooling; the Scottish education acts ceded precedence to the factory acts. In England and Wales it was unclear whether factory acts or education acts had precedence until the Elementary Education Act of 1880 settled the matter in favour of school board bye-laws, but without any standardisation of criteria between different boards. Specification of a minimum educational attainment before a factory child could work half-time then became enforceable in England, but remained unenforceable in Scotland until passage of the Education (Scotland) Act 1883.{{rp, 222–224) 'Half-time' could be achieved by splitting each day between school and work, or (unless the child worked in a domestic workshop) by working and attending school on alternate days. If the former, the child should work morning and afternoons on alternate weeks; if the latter the schooldays in one week should be workdays the next (and ''vice versa''). No child should work a half-day on successive Saturdays. Surgeons no longer certified the apparent age of a child (or young person), age now being substantiated by a birth certificate or school register entry, but (for employment in factories) they were required to certify the fitness for the work of children and young persons under the age of sixteen.

Protected persons should not be allowed to clean moving machinery, the requirement to guard machinery now extended to the protection of men as well as protected persons, and the Home Secretary might direct that some or all of the fine imposed for a breach of this requirement be paid to any person injured (or the relatives of any person killed) as a result. (Guarding was now only unnecessary if the position of machinery meant it was equally safe if unguarded, but hoists still only needed to be guarded if a person might pass close to them.) There were restrictions on the employment of some classes of protected persons on processes injurious to health. Young persons and children could not work in the manufacture of white lead, or silvering mirrors using mercury; children and female young persons could not be employed in glass works; girls under sixteen could not be employed in the manufacture of bricks, (non-ornamental) tiles, or salt; children could not be employed in the dry grinding of metals or the dipping of lucifer matches. Inspectors were given powers to require the mitigation of dusty atmospheres by mechanical ventilation or other mechanical means.

Subsequent minor Acts

The Factory and Workshop Act 1883 (46 & 47 Vict. c.53) gave additional powers for the regulation of white-lead manufacture and bakehouses (but sanitary requirements for retail bakehouses were to be enforced by local authorities); in the same session a private member's bill intended to prohibit the employment of female children in the manufacture of nails was defeated at Second Reading. The Factory and Workshops Act 1878 Amendment (Scotland) Act 1888 affected the choice of full-day holidays in Scottish burghs; formerly they had been the sacramental fast days specified by the local church  – they could now be specified by the burgh magistrates.
The Cotton Cloth Factories Act of 1889 set limits on temperature (and humidity at a given temperature) where cotton cloth was being woven.{{efn, The problem this addressed was the risk to health to workers in damp clothing leaving a hot mill for the ambient temperature of a mill town. A more comprehensive amendment of the Factory Act had been drafted, but parliamentary time could not be found.

Inadequate resources for strict enforcement

The TUC had few complaints about the Act, but complained that the inspectorate enforcing it was too small and lacking in 'practical men'. The latter complaint was partially addressed by changing the recruitment process and appointing a number of former trade union officials to the inspectorate. The total number of inspectors increased from 38 in 1868 to 56 in 1885, but (the general secretary of the TUC complained) these had to cover the more than 110,000 workplaces registered (in 1881) and attempt to detect unregistered workplaces falling within the scope of the Act: 16 out of 39 districts in England had no registered workshops and only half the registered workshops had been inspected in 1881. When, after several unsuccessful attempts to extend some of the protections of the Act to shopworkers, Sir John Lubbock succeeded in securing passage of a Shop Hours Regulation Act at the end of the 1886 session, the Act made no provision for (and the Home Secretary Hugh Childers refused to accept any amendment allowing) enforcement by inspection.{{efn, Gladstone's administration had been defeated on Irish issues; a dissolution was to follow once essential non-controversial Bills had been passed. Therefore, no controversial amendments to the Bill could be accepted; its remaining opponents also objected to its treatment as non-controversial. The Evening Standard thought that this meant the Act would be a dead letter, given experiences with the Factory Acts:

The Factory Acts are enforced by an elaborate machinery of inspection. Anyone who has taken the trouble to inquire into the matter knows perfectly well that without this stringent inspection they would be absolutely worthless. Even as it is they are contravened openly every day, because the best inspection must, from the nature of the case, be somewhat spasmodic and uncertain. When an Inspector discovers that the law has been broken he summons the offending party; but, as a rule, if he does not make the discovery himself, no one informs him of it. The chief provisions of the last Factory Act are hung up, legibly printed on white cardboard, "plain for all men to see", in every room of every factory. No one can be ignorant of them; yet when they are disregarded, as they are constantly, it is the rarest thing for any of the women affected by the illegality to give information.

Factory Act 1891

Under the heading Conditions of Employment were two considerable additions to previous legislation:
the first is the prohibition on employers to employ women within four weeks after confinement (childbirth); the second the raising the minimum age at which a child can be set to work from ten to eleven

Factory and Workshop Act 1895

{{main, Factory and Workshop Act 1895 The main article gives an overview of the state of Factory Act legislation in Edwardian Britain under the Factory and Workshop Acts 1878 to 1895 (the collective title of the Factory and Workshop Act 1878, the Factory and Workshop Act 1883, the Cotton Cloth Factories Act 1889, the Factory and Workshop Act 1891 and the Factory and Workshop Act 1895.)

Factory and Workshop Act 1901

Minimum working age is raised to 12. The act also introduced legislation regarding the education of children, meal times, and fire escapes.
Children could also take up a full-time job at the age of 13 years old.

Review in 1910

By 1910, Sidney Webb reviewing the cumulative effect of century of factory legislation felt able to write:
{{quote, The system of regulation which began with the protection of the tiny class of pauper apprentices in textile mills now includes within its scope every manual worker in every manufacturing industry. From the hours of labour and sanitation, the law has extended to the age of commencing work, protection against accidents, mealtimes and holidays, the methods of remuneration, and in the United Kingdom as well as in the most progressive of English-speaking communities, to the rate of wages itself. The range of Factory Legislation has, in fact, in one country or another, become co-extensive with the conditions of industrial employment. No class of manual-working wage-earners, no item in the wage-contract, no age, no sex, no trade or occupation, is now beyond its scope. This part, at any rate, of Robert Owen's social philosophy has commended itself to the practical judgment of the civilised world. It has even, though only towards the latter part of the nineteenth century, converted the economists themselves – converted them now to a "legal minimum wage" – and the advantage of Factory Legislation is now as soundly "orthodox" among the present generation of English, German, and American professors as "laisser-faire" was to their predecessors. ... Of all the nineteenth century inventions in social organisation, Factory Legislation is the most widely diffused.{{sfnp, Hutchins, Harrison, 1911, p={{rp, Preface

He also commented on the gradual (accidentally almost Fabian) way this transformation had been achieved

{{quote, The merely empirical suggestions of Dr. Thomas Percival and the Manchester Justices of 1784 and 1795, and the experimental legislation of the elder Sir Robert Peel in 1802, were expanded by Robert Owen in 1815 into a general principle of industrial government, which came to be applied in tentative instalments by successive generations of Home Office administrators. ... This century of experiment in Factory Legislation affords a typical example of English practical empiricism. We began with no abstract theory of social justice or the rights of man. We seem always to have been incapable even of taking a general view of the subject we were legislating upon. Each successive statute aimed at remedying a single ascertained evil. It was in vain that objectors urged that other evils, no more defensible existed in other trades, or among other classes, or with persons of ages other than those to which the particular Bill applied. Neither logic nor consistency, neither the over-nice consideration of even-handed justice nor the Quixotic appeal of a general humanitarianism, was permitted to stand in the way of a practical remedy for a proved wrong. That this purely empirical method of dealing with industrial evils made progress slow is scarcely an objection to it. With the nineteenth century House of Commons no other method would have secured any progress at all.{{sfnp, Hutchins, Harrison, 1911, p={{rp, Preface

Factories Act 1937

The 1937 Act (1 Edw. 8 & 1 Geo. 6 c.67) consolidated and amended the Factory and Workshop Acts from 1901 to 1929. It was introduced to the House of Commons by the Home Secretary, Sir John Simon, on 29 January 1937 and given Royal Assent on 30 July.

Factories Act 1959

This Act was to amend the previous Acts of 1937 and 1948, as well as adding more health, safety and welfare provisions for factory workers. It also revoked regulation 59 of the 1939 Defence (General) Regulations. The Act is dated 29 July 1959.{{cite web , title=Factories Act 1959 , url=https://www.legislation.gov.uk/ukpga/Eliz2/7-8/67/enacted , website=www.legislation.gov.uk , access-date=22 December 2018

Factories Act 1961

{{Main, Factories Act 1961
This Act consolidated the 1937 and 1959 Acts. {{As of, 2008, the 1961 Act is substantially still in force, though workplace health and safety is principally governed by the Health and Safety at Work etc. Act 1974 and regulations made under it.

See also

*History of labour law in the United Kingdom
*UK labour law
*Mines Act of 1842
*Labour law
*Factory inspector

Notes

{{notelist

References

{{reflist

Further reading

*{{cite book , last1=Hutchins , first1=B. L. , last2=Harrison , first2=A. , title=A History of Factory Legislation , year=1911 , publisher=P. S. King & Son , url=https://archive.org/details/historyoffactory014402mbp

Encyclopedia of British History
* {{cite book, title=Law and Society in England 1750–1950, author = W.R. Cornish and G. de N. Clark (Available onlin
here
.
* Finer, Samuel Edward. ''The life and times of Sir Edwin Chadwick'' (1952
excerpt
pp 50–68.
* Pollard, Sidney. "Factory Discipline in the Industrial Revolution." ''Economic History Review,'' 16#2 1963, pp. 254–271
online

External links

The 1833 Factory Act on the UK Parliament websiteAspects of the Industrial Revolution in Britain : Working Conditions and Government Regulation
– a selection of primary documents


{{UK legislation

Acts of the Parliament of the United Kingdom
Child labour
United Kingdom labour law
United Kingdom Acts of Parliament 1802
United Kingdom Acts of Parliament 1819
United Kingdom Acts of Parliament 1833
United Kingdom Acts of Parliament 1844
United Kingdom Acts of Parliament 1847
United Kingdom Acts of Parliament 1850
United Kingdom Acts of Parliament 1867
United Kingdom Acts of Parliament 1878
United Kingdom Acts of Parliament 1891
Health and safety in the United Kingdom
Children's rights in the United Kingdom
Women's rights in the United Kingdom
Cotton production
Articles containing video clips