Volvo Engine Architecture

The Volvo Engine Architecture (VEA) is a family of straight-three and straight-four automobile petrol and diesel engines produced by Volvo Cars in Skövde, Sweden, since 2013, Zhangjiakou, China, since 2016 and Tanjung Malim, Malaysia, since 2022 by Proton. Volvo markets all engines under the ''Drive–E'' designation, while Geely groups the three-cylinder variants with its other engines under the ''G-power'' name. These engines are some of the few ever put into production as twincharged engines, in the company of the Lancia Delta S4 and concept Jaguar CX-75.

History

Development of the new engine family began in 2006, with the decision to only produce four-cylinder engines being finalised in 2007. The intention was to produce smaller, more economical and environmentally friendly engines that would be fitted to every Volvo model. In 2008 Volvo began to upgrade its Skövde engine plant and invested roughly 2 billion SEK into development and tooling for the VEA.

In the autumn of 2013, the first cars with the new engines were delivered to customers, starting with the S60 II and V60 models. At the same time, Volvo began to phase out the five-cylinder petrol and diesel engines, the six-cylinder petrol engines as well as any four-cylinder engines from other manufacturers. Until the end of 2015, nearly all other engines had been phased out, with only a few non VEA engines remaining in production for select models. Volvo nearly completed the phaseout in 2016 with only two variants of the five-cylinder diesel remaining in production for the 60-series models.

In December 2014, Volvo introduced the first hybrid variant of a VEA engine with the launch of the XC90 T8. It uses an electric rear axle drive (ERAD) for both electric propulsion and AWD capabilities. Hybrid engines are equipped with a crankshaft integrated starter generator (CISG) that is used to start the engine, capture otherwise lost energy when slowing down and reduce lag at low rpm by acting as an additional supercharger. Volvo refers to this type of hybrid implementation as ''Twin Engine''.

With the introduction of Volvo's new flagship sedan in 2016, the S90, the ''PowerPulse'' anti-lag system for the top of the range diesel engines was unveiled. It uses a small tank of compressed air that can instantaneously be released into the turbocharger to help with spool up, thereby reducing turbo lag.

Volvo began testing of three-cylinder variants in mid 2014, it had been planned to introduce these engines in 2015. With their smaller capacity and less power they were meant to be used as base engines. In 2015 no three-cylinder engines were released, instead four-cylinder variants with 1.5 L capacity were introduced as base engines on some models. In the second half of 2017, the first production VEA three-cylinder engine was released with the debut of the LEVC TX, where it is used as a range extender. The first Volvo three-cylinder VEA was slated for introduction in 2018 for the XC40 under the ''T3'' engine designation, however it saw only limited release.

Due to stricter emissions laws, additional and improved emissions control equipment was introduced, beginning in the second half of 2017 for the 2018 model year. Diesel engines gained a SCR-catalyst to decrease NOx emissions, petrol engines received a particle filter. These changes are referred to as VEA GEN2. This improved the emissions rating to Euro 6c and for some engines to Euro 6d-TEMP. The improvements were rolled out in stages and some engines, particularly the hybrid variants, remained in Euro 6 configuration until the second quarter of 2018. By model year 2019 all engines had been updated to achieve Euro 6d-TEMP certification, with some engines getting discontinued. All diesel engines are now equipped with Ad-Blue and all petrol engines with a particle filter.

Volvo has been developing a major update for all its engines since 2017. It is code-named VEA GEN3 (with VEP GEN3 and VED GEN3 respectively) and part of Volvo's effort to hybridize all of its engines. The MHEV variants will have a 48V network separate from the high-voltage battery system.

New ''B'' badging for hybrid vehicles. Deviating from the previously introduced T (1994 with the T-5, without the dash in 1996 for X70) and D (2002 with the D5 engine, expanded in ~2009 with D4 and D3 subdivision) naming/badging scheme. The system uses kinetic energy recovery via a belt driven integrated starter generator (BISG) which is stored in a 48V 0.25 kWh lion battery. Under heavy load or rapid acceleration the BISG is used as a power adder. P0 hybridization.

Nomenclature

The engine codes consist of a series of letters and digits. The actual, broadly used engine code is 7 or 8 characters long. Hybrid models can have a second engine code that is 7 characters long, mild hybrids engine codes are 6 characters long. Different, more general engine codes are used for some certification and approval documents and are 6 to 8 characters long. An additional 2 characters are used to identify each specific engine variant with an ''MP'' or ''HP'' suffix to differentiate performance.

Standard engine codes:
* 1st: Fuel type (B/D) B = Bensin (Petrol), D = Diesel
* 2nd: Number of cylinders (3/4)
* 3rd & 4th: Approximate displacement in deciliters, may be rounded up or down (19 ~= 2.0 L)
* 5th: Valves per cylinder (4)
* 6th: Induction method (T) T = turbocharged
* 7th & 8th: Engine variant (4/5/6/9/11/14/20/23/27/35/44)

Petrol (GEP3/VEP4)

1.5

All three-cylinder 1.5 L (1,477 cc) petrol engines have a bore of and a stroke of with a compression ratio of 10.5:1. All engines are turbocharged and intercooled with direct injection. All 3 cylinder engines are equipped with belt driven water pump and integrated mass balancer shaft, 4 cylinder engines are equipped with an electric water pump.

B3154T

The ''B3154T'' is usually only referred to as range extender. It delivers at 4000 rpm and . When running it only recharges the high voltage battery, thus functioning as a range extender giving approx. 300 miles of additional range. Single turbocharger.

CISG.

Emissions level Euro 6.

Applications:
* 2017–present LEVC TX badged as ''LEVC TX'', ''LEVC TX e-City'' or with no additional badging

B3154T

The ''B3154T'' (11 or 14 for standard transmission and 15 for automatic) delivers at 5000 rpm and of torque in the range of 1850–3850 rpm with standard transmission or of torque in the range of 1850–3850 rpm with automatic. Engine variant for cars equipped with a manual or automatic gearbox. Single turbocharger.

This engine is only available with a six-gear gearbox made by Volvo Cars or the Toyota AW8G30 gearbox.

It was replaced by the newer engine ''B3154T7'' which retains the same ID code of 11 but not 14; automatic was changed to ''B3154T2'' which retains the same ID code of 15.

Emissions level Euro 6d-TEMP.

Applications:
* 2019 Volvo XC40 badged as ''XC40 T3''

B3154T2

The ''B3154T2'' (15) delivers at 5500 rpm and of torque in the range of 1500–3000 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

This engine is only available with the AW8G30 gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo XC40 badged as ''XC40 T3''

B3154T3

The ''B3154T3'' delivers at 5000 rpm and of torque in the range of 1550–3000 rpm.

Emissions level euro 6dtemp.

Applications:
* 2019–present Volvo XC40 badged as ''XC40 T2''

B3154T5

The ''B3154T5'' (BB) delivers at 5800 rpm and of torque in the range of 1500–3000 rpm. The front electric motor (EFAD) delivers and of torque. Single turbocharger.

Battery capacity is 9.7 kWh.

This engine is only available with the 7DCTH gearbox.

Emissions level Euro 6d.

Applications:
* 2020–present Volvo XC40 badged as ''XC40 T5 Twin Engine''

B3154T7

The ''B3154T7'' (11) delivers at 5500 rpm and of torque in the range of 1850–3000 rpm. Engine variant for cars equipped with a manual gearbox. Single turbocharger.

This engine is only available with the M76 R6.2 gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo XC40 badged as ''XC40 T3''

B3154T9

The ''B3154T9'' delivers at 5000 rpm and of torque in the range of 1600–3000 rpm. Single turbocharger.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo XC40 badged as ''XC40 T2''

JLH-3G15TD / JLH-3G15T

The ''JLH-3G15TD'' delivers at 5500 rpm and of torque in the range of 1500–4000 rpm. Single turbocharger.

The ''JLH-3G15T'' delivers at 5500 rpm and of torque in the range of 1500 and 4000 rpm. Single turbocharger.

This engine is only available with a 7-speed DCT.

No emissions standard information.

Applications: JLH-3G15TD
* 2016–present Geely Boyue
* 2018–present Geely Binyue
* 2018–present Geely Borui GE
* 2018–present Lynk & Co 01 / 领克01 badged as ''01 PHEV''
* 2018–present Lynk & Co 02 / 领克02 badged as ''02'' or ''02 1.5TD''
* 2018–present Lynk & Co 03 / 领克03 badged as ''03'' or ''03 1.5TD''
* 2020–present Geely Icon
* 2020–present Proton X50
* 2020–present Proton X70
* 2023–present Proton X90
Applications: JLH-3G15T

* 2020–present Proton X50
* 2023–present Proton S70
* 2024–present Geely Xingyue L / Renault Grand Koleos

JLH-3G15TDC

The ''JLH-3G15TDC'' delivers at 5000 rpm and of torque in the range of 1450–4000 rpm. Single turbocharger.

Emissions level China V.

Applications:
* 2018–present Lynk & Co 02 / 领克02 badged as ''02'' or ''02 1.5TD''

B4154T2

The ''B4154T2'' (32) delivers at 5000 rpm and of torque in the range of 1800–4000 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

This engine is only available with an automatic gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2019 Volvo V40 II badged as ''V40 T3''
* 2019 Volvo V40CC badged as ''V40CC T3''

B4154T3

The ''B4154T3'' (33) delivers at 5000 rpm and of torque in the range of 1800–3500 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

Emissions level Euro 6d-TEMP.

Applications:
* 2019 Volvo V40 II badged as ''V40 T2''

B4154T4

The ''B4154T4'' (29) delivers at 5000 rpm and of torque in the range of 1700–4000 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

This engine is only available with the AW TF-71SC gearbox.

Emissions level Euro 6b.

Applications:
* 2016–2018 Volvo V40 II badged as ''V40 T3''
* 2015–2018 Volvo V40CC badged as ''V40CC T3''
* 2016–2018 Volvo S60 II badged as ''S60 T3''
* 2016–2018 Volvo S60L badged as ''S60L T3''
* 2016–2018 Volvo V60 badged as ''V60 T3''

B4154T5

The ''B4154T5'' (28) delivers at 5000 rpm and of torque in the range of 1600–3500 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

This engine is only available with the AW TF-71SC gearbox.

Emissions level Euro 6b, upgraded to Euro 6d-TEMP with model year 2018.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 T2''
* 2016–2018 Volvo S60 II badged as ''S60 T2''
* 2016–2018 Volvo V60 badged as ''V60 T2''

B4154T6

The ''B4154T6'' delivers at 5000 rpm and of torque in the range of 1600–3500 rpm. Single turbocharger.

This engine is only available with the AW TF-71SC gearbox.

Emissions level Euro 6b.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 T3''
* 2016–2018 Volvo S60 II badged as ''S60 T3''
* 2016–2018 Volvo V60 badged as ''V60 T3''

2.0

All 2.0 L (1,969 cc) petrol engines have a bore of and a stroke of with a compression ratio of 10.3:1. All engines are turbocharged and intercooled with direct injection. More powerful versions are equipped with a roots type supercharger in addition to being turbocharged and intercooled.
All engines come with an electric water pump and balancer shafts.

B4204T5

The ''B4204T5'' delivers at 5800 rpm and of torque in the range of 1500–3000 rpm. The front electric motor (EFAD) delivers at 4000 rpm and of torque at 3500 rpm. Single turbocharger.

Battery capacity is 10.7 kWh.

This engine is only available with the 7DCT gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo XC40 badged as ''XC40 Twin Engine'' or ''XC40 T5 Twin Engine''

JLH-4G20TD

The ''JLH-4G20TD'' delivers at 4700 rpm and of torque in the range of 1400–4000 rpm. Single turbocharger.

Emissions level China VI.

Applications:
* 2018–2023 Lynk & Co 02 / 领克02 badged as ''02'' or ''02 2.0T'' or ''02 AWD''

JLH-4G20TDB

The ''JLH-4G20TDB'' delivers and of torque.

Emissions level China VIB.

Applications:
* 2020–present Geely Xingyue / Geely Xing Yue / 吉利星越 badged as ''驭星者AWD'' or ''星越 350T''

JLH-4G20TDC

The ''JLH-4G20TDC'' delivers and of torque in the range of 1800–4800 rpm.

JLH-4G20TDH

The ''JLH-4G20TDH'' delivers and of torque in the range of 2000–4000 rpm.

B4204T9

The ''B4204T9'' (49) delivers at 5700 rpm and of torque in the range of 2100–4500 rpm.
For 2016 minor changes increased power output to at 5700 rpm. Turbocharger and supercharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6, beginning with model year 2018 emissions level Euro 6b.

Applications:
* 2015–2018 Volvo S60 II badged as ''S60 T6'' or ''S60 T6 AWD''
* 2015–2018 Volvo V60 badged as ''V60 T6'' or ''V60 T6 AWD''
* 2014–2017 Volvo XC60 badged as ''XC60 T6'' or ''XC60 T6 AWD''

B4204T10

The ''B4204T10'' (27) delivers at 5700 rpm and of torque in the range of 2100–4500 rpm. Turbocharger and supercharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6b.

Applications:
* 2014–2018 Volvo S60 II badged as ''S60 T6''
* 2014–2017 Volvo XC60 badged as ''XC60 T6''

B4204T11

The ''B4204T11'' (40) delivers at 5500 rpm and of torque in the range of 1500–4800 rpm. The compression ratio was changed to 10.8:1. Single turbocharger. The crankshaft has a stroke of 93.2mm.

This engine is only available with the AW TG-81SC gearbox.

A specially designed ULEV2 emissions variant of this engine exists.

Emissions level Euro 6.

Applications:
* 2015–2019 Volvo V40 II badged as ''V40 T5''
* 2015–2019 Volvo V40CC badged as ''V40CC T5'' or ''V40CC T5 AWD''
* 2015–2018 Volvo S60 II badged as ''S60 T5''
* 2015–2018 Volvo S60L badged as ''S60L T5'' or ''S60L T5 AWD''
* 2015–2018 Volvo S60CC badged as ''S60CC T5 AWD''
* 2015–2018 Volvo V60 badged as ''V60 T5''
* 2015–2018 Volvo V60CC badged as ''V60CC T5'' or ''V60CC T5 AWD''
* 2015–2017 Volvo XC60 badged as ''XC60 T5'' or ''XC60 T5 AWD''
* 2014–2016 Volvo S80 II badged as ''S80 T5''
* 2014–2016 Volvo V70 III badged as ''V70 T5'' or ''V70 Bi-Fuel''
* 2014–2016 Volvo XC70 II badged as ''XC70 T5''

B4204T12

The ''B4204T12'' (26) delivers at 5600 rpm and of torque in the range of 1500–4500 rpm. Single turbocharger.

This engine is a PZEV emissions variant and features additional emissions reducing equipment.

Applications:
* 2015-2016 Volvo S80 II badged as ''S80 T5''
* 2015–2018 Volvo S60 II badged as ''S60 T5''
* 2015–2017 Volvo XC60 badged as ''XC60 T5''

B4204T14

The ''B4204T14'' (13) delivers at 5500 rpm and of torque in the range of 1800–4800 rpm. The compression ratio was changed to 10.8:1. Single turbocharger.

The engine is equipped with a particle filter. Emissions level Euro 6d-TEMP.

Applications:
* 2018–present Volvo XC40 badged as ''XC40 T5 AWD''

B4204T15

The ''B4204T15'' delivers at 5500 rpm and of torque in the range of 1500–4000 rpm. The compression ration was changed to 10.8:1. Single turbocharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6.

Applications:
* 2014–2016 Volvo V40 II badged as ''V40 T5''
* 2015–2016 Volvo V40CC badged as ''V40CC T5''
* 2016–2017 Volvo S60 II badged as ''S60 T5''
* 2016–2017 Volvo V60 badged as ''V60 T5''
* 2014–2016 Volvo S80 II badged as ''S80 T5''

B4204T17

The ''B4204T17'' (36) delivers at 5000 rpm and of torque in the range of 1200–3500 rpm. The compression ratio was changed to 11.3:1. Single turbocharger.

This engine is only available with the M76 R6.2 gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2018–2019 Volvo V40 II badged as ''V40 T2''

B4204T18

The ''B4204T18'' (16) delivers at 5500 rpm and of torque in the range of 1500–4800 rpm. Single turbocharger.

Nominal rated power is at 5500 rpm.

Gearbox only TG-80SC AWD

Emissions level Euro 6d-TEMP.

Applications:
* 2018–present Volvo XC40 badged as ''XC40 T5 AWD''
* 2021–present Lynk & Co 09 Mild hybrid ''2.0T+8AT 48V mechanical four-wheel drive''
* 2021–present Lynk & Co 09 Hybrid ''2.0T HEV light hybrid electric four-wheel drive''

B4204T19

The ''B4204T19'' (41) delivers at 4700 rpm and of torque in the range of 1350–4000 rpm. The compression ratio was changed to 11.3:1. Single turbocharger.

This engine is available with the M66H, M76, AW TF81-SC and AW TF-71SC gearbox.

Emissions level Euro 6, beginning with model year 2018 emissions level Euro 6b.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 T4''
* 2016–2019 Volvo V40CC badged as ''V40CC T4''
* 2016–2018 Volvo S60 II badged as ''S60 T4''
* 2016–2018 Volvo S60L badged as ''S60L T4''
* 2016–2018 Volvo V60 badged as ''V60 T4''
* 2015–2016 Volvo V70 III badged as ''V70 T4''

B4204T20

The ''B4204T20'' (8) delivers at 5500 rpm and of torque in the range of 1500–4500 rpm. Single turbocharger.

Emissions level Euro 6, for the XC60 II emissions level Euro 6b.

Applications:
* 2017–present Volvo XC60 II badged as ''XC60 T5 AWD''
* 2016–present Volvo S90 II badged as ''S90 T5''
* 2017–present Volvo V90CC badged as ''V90CC T5 AWD''
* 2016–present Volvo XC90 II badged as ''XC90 T5 AWD''
*2019–present Volvo S60 III badged as ''S60 T5 AWD''

B4204T21

The ''B4204T21'' (57) delivers at 5000 rpm and of torque in the range of 1500–4000 rpm. Single turbocharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6.

Applications:
* 2015–2019 Volvo V40CC badged as ''V40CC T4 AWD''

B4204T23

The ''B4204T23'' (10) delivers at 5500 rpm and of torque in the range of 1500–4800 rpm. Single turbocharger.

In Europe emissions level Euro 6, for the XC60 II emissions level Euro 6b.

In China emissions level China VI.

Applications:
* 2019–present Volvo S60 III badged as ''S60 T5 AWD''
* 2019–present Volvo V60CC badged as ''V60CC T5'' or ''V60CC T5 AWD''
* 2017–present Volvo XC60 II badged as ''XC60 T5 AWD''
* 2016–present Volvo S90 II badged as ''S90 T5''
* 2016–present Volvo S90L badged as ''S90长轴距 T5''
* 2017–present Volvo V90 II badged as ''V90 T5'' or ''V90 Bi-Fuel''
* 2017–present Volvo V90CC badged as ''V90CC T5 AWD''
* 2015–present Volvo XC90 II badged as ''XC90 T5 AWD''

* 2019–present Lynk & Co 03 / 领克03 badged as ''03+''

B4204T26

The ''B4204T26'' (25) delivers at 5500 rpm and of torque in the range of 1800–4800 rpm. The compression ratio was changed to 10.8:1. Single turbocharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6, during model year 2018 upgraded to emissions level Euro 6d-TEMP.

Applications:
* 2019–present Volvo S60 III badged as ''S60 T5'' or ''S60 T5 AWD''
* 2019–present Volvo V60 II badged as ''V60 T5'' or ''V60 T5 AWD''
* 2018–present Volvo XC60 II badged as ''XC60 T5'' or ''XC60 T5 AWD''
* 2018–present Volvo S90 II badged as ''S90 T5''
* 2018–present Volvo V90 II badged as ''V90 T5''
* 2018–present Volvo V90CC badged as ''V90CC T5 AWD''
* 2018–present Volvo XC90 II badged as ''XC90 T5 AWD''

B4204T27

The ''B4204T27'' (A2) delivers at 5700 rpm and of torque in the range of 2200–5400 rpm. Turbocharger and supercharger.

Emissions level Euro 6, upgraded to Euro 6b for model year 2017, beginning with model year 2018 emissions level Euro 6d-TEMP.

Applications:
* 2019–2021 Volvo S60 III badged as ''S60 T6 AWD''
* 2019–2021 Volvo V60 II badged as ''V60 T6 AWD''
* 2017–2020 Volvo XC60 II badged as ''XC60 T6 AWD''
* 2017–2021 Volvo S90 II badged as ''S90 T6 AWD''
* 2017–2021 Volvo V90 II badged as ''V90 T6 AWD''
* 2017–2021 Volvo V90CC badged as ''V90CC T6 AWD''
* 2016–2022 Volvo XC90 II badged as ''XC90 T6 AWD''

B4204T28

The ''B4204T28'' (BC), later ''B4204T28'' (B1FPHEV) (BR), delivers at 5700 rpm and of torque in the range of 2200–5400 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

Battery capacity was 9.2 kWh for model years 2016 and 2017. It was increased to 10.4 kWh beginning with model year 2018.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6b, from model year 2018 emissions level Euro 6d-TEMP.

Applications:
* 2018–present Volvo XC60 II badged as ''XC60 T8'', ''XC60 T8 AWD'', ''XC60 Twin Engine'' or ''XC60 T8 TWIN ENGINE AWD''
* 2018–present Volvo S90 II badged as ''S90 T8'', ''S90 T8 AWD'', ''S90 Twin Engine'' or ''S90 T8 TWIN ENGINE AWD''
* 2019–present Volvo V90 II badged as ''V90 T8'', ''V90 T8 AWD'', ''V90 Twin Engine'' or ''V90 T8 TWIN ENGINE AWD''
* 2016–present Volvo XC90 II badged as ''XC90 T8'', ''XC90 T8 AWD'', ''XC90 Twin Engine'' or ''XC90 T8 TWIN ENGINE AWD''

B4204T29

The ''B4204T29'' (A3) delivers at 5700 rpm and of torque in the range of 2200–5400 rpm. Turbocharger and supercharger.

In the S60 III and V60 II, and for all other models from and including model year 2020, it delivers at 5700 rpm and of torque in the range of 2200–5100 rpm. Turbocharger and supercharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6, from model year 2019 on emissions level Euro 6d-TEMP.

Applications:
* 2019–present Volvo V60 II badged as ''V60 T6 AWD''
* 2018–2020 Volvo XC60 II badged as ''XC60 T6 AWD''
* 2018–present Volvo S90 II badged as ''S90 T6 AWD''
* 2018–present Volvo V90 II badged as ''V90 T6 AWD''
* 2018–present Volvo V90CC badged as ''V90CC T6 AWD''
* 2018–present Volvo XC90 II badged as ''XC90 T6 AWD''

B4204T30

The ''B4204T30'' delivers at 4700 rpm and of torque in the range of 1400–4000 rpm. Single turbocharger.

This engine is available with a 7-speed DCT.

Emissions level China VI.

Applications:
* 2017–present Lynk & Co 01 / 领克01 badged as ''01 AWD''
* 2018–2023 Lynk & Co 02 / 领克02 badged as ''02'', ''02 2.0T'' or ''02 AWD''.

B4204T31

The ''B4204T31'' (AK) delivers at 5000 rpm and of torque in the range of 1600–4000 rpm. The compression ratio was changed to 11.8:1. Single turbocharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6, beginning with model year 2018 emissions level Euro 6d-TEMP.

Applications:
* 2018–present Volvo S90 II badged as ''S90 T4''
* 2018–present Volvo V90 II badged as ''V90 T4''

B4204T32

The ''B4204T32'' delivers at 5700 rpm and of torque in the range of 1500–4500 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

Battery capacity is 11.2 kWh.

This engine is only available with the AW TG-81SC gearbox.

Emissions level China V.

Applications:
* 2016–2019 Volvo S60L badged as ''S60L T6 Twin Engine''

B4204T33

The ''B4204T33'' (35) delivers at 5000 rpm and of torque in the range of 1300–4000 rpm. Single turbocharger.

This engine is only available with the M76 manual transmission.

Emissions level Euro 6d-TEMP.

Applications:
* 2019 Volvo V40 II badged as ''V40 T3''

B4204T34

The ''B4204T34'' (BM) delivers at 5700 rpm and of torque in the range of 2200–5400 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

In the newly released S60 III and V60 II, and for all other models from and including model year 2020, it delivers at 6000 rpm and of torque in the range of 2200–4800 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

Battery capacity was 10.4 kWh for model years 2018 and 2019. It was increased to 11.6 kWh for model year 2020.

This engine is only available with the AW TG-81SD gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2019–present Volvo S60 III badged as ''S60 T8 Twin Engine''
* 2019–present Volvo V60 II badged as ''V60 T8 Twin Engine'', ''V60 T8 Twin Engine AWD'' or ''V60 T8 Twin Engine eAWD''
* 2018–present Volvo XC60 II badged as ''XC60 T8'', ''XC60 T8 TWIN ENGINE eAWD'' or ''XC60 T8 AWD RECHARGE''
* 2018–present Volvo S90 II badged as ''S90L T8'', ''S90 Excellence'' or ''S90L Excellence''
* 2018–present Volvo XC90 II badged as ''XC90 T8'' or ''XC90 T8 TWIN ENGINE''

B4204T35

The ''B4204T35'' (B1APHEV) (BA) delivers at 5700 rpm and of torque in the range of 2200–5400 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

This engine is only available with the ''AW TG-81SC'' gearbox.

In Europe emissions level Euro 6, upgraded to emissions level Euro 6b, from model year 2018 on Euro 6d-TEMP.

In China emissions level China V, upgraded to China VI.

Applications:
* 2020–present Volvo V60 II badged as ''V60 T8, T8 AWD, T8 Twin Engine AWD, T8 Polestar Engineered ''
* 2018–present Volvo XC60 II badged as ''XC60 T8'', ''XC60 T8 AWD'', ''XC60 Twin Engine'' or ''XC60 T8 TWIN ENGINE AWD''
* 2018–present Volvo S90 II badged as ''S90 T8'', ''S90 T8 AWD'', ''S90 Twin Engine'' or ''S90 T8 TWIN ENGINE AWD'' or ''S90 RECHARGE T8''
* 2018–present Volvo V90 II badged as ''V90 T8'', ''V90 T8 AWD'', ''V90 Twin Engine'' or ''V90 T8 TWIN ENGINE AWD''
* 2016–present Volvo XC90 II badged as ''XC90 T8'', ''XC90 T8 AWD'', ''XC90 Twin Engine'' or ''XC90 T8 TWIN ENGINE AWD''
* 2021–present Lynk & Co 09 PHEV ''2.0T+8AT PHEV electric four-wheel drive''

B4204T36

The ''B4204T36'' (3) delivers at 5500 rpm and of torque in the range of 1800–4500 rpm. Single turbocharger.

Emissions level Euro 6d-TEMP.

Applications:
* 2018–present Volvo XC40 badged as ''XC40 T5 AWD''

B4204T37

The ''B4204T37'' (37) delivers at 5000 rpm and of torque in the range of 1300–4000 rpm. The compression ratio was changed to 11.3:1. Engine variant for cars equipped with a manual gearbox. Single turbocharger.

This engine is only available with the M66H gearbox.

Emissions level Euro 6.

Applications:
* 2016–2018 Volvo V40 II badged as ''V40 T3''
* 2016–2018 Volvo V40CC badged as ''V40CC T3''
* 2016–2018 Volvo S60 II badged as ''S60 T3''
* 2016–2018 Volvo V60 badged as ''V60 T3''

B4204T38

The ''B4204T38'' (21) delivers at 5000 rpm and of torque in the range of 1500–4800 rpm. The compression ratio was changed to 11.3:1. Engine variant for cars equipped with a manual gearbox. Single turbocharger.

This engine was only available with the M66H gearbox until model year 2017, afterwards it was only available with the M76 gearbox.

Emissions level Euro 6.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 T2''

B4204T41

The ''B4204T41'' delivers at 5500 rpm and of torque in the range of 1500–4800 rpm. The compression ratio was changed to 8.6:1. Single turbocharger.

Emissions level Euro 6.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 T5''
* 2017–2019 Volvo V40CC badged as ''V40CC T5'' or ''V40CC T5 AWD''
* 2016–2018 Volvo S60 II badged as ''S60 T5''
* 2016–2018 Volvo V60 badged as ''V60 T5''
* 2016–2017 Volvo XC60 badged as ''XC60 T5''

B4204T43

The ''B4204T43'' (A0) delivers at 6000 rpm and of torque in the range of 3100–5100 rpm. The compression ratio was changed to 8.6:1. Turbocharger and supercharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6.

Applications:
* 2017–2018 Volvo S60 II badged as ''S60 Polestar''
* 2017–2018 Volvo V60 badged as ''V60 Polestar''

B4204L43

The B4204L43 delivers at 6000 rpm and of torque in the range of 3000–5000 rpm. Turbocharger and supercharger.

This engine is only available with the AW TG-81SC gearbox.

Applications:

* 2024-present Lynk & Co 03 / 领克03 badged as ''03+Racing, 03+TCR Cyan''

B4204T44

The ''B4204T44'' (AL) delivers at 5000 rpm and of torque in the range of 1400–4000 rpm. The compression ratio was changed to 10.8:1. Single turbocharger.

This engine is only available with the gearbox.

Emissions level Euro 6.

Applications:
* 2020–present Volvo V60 II badged as ''V60 T4
* 2018–present Volvo XC60 II badged as ''XC60 T4''
* 2018–present Volvo S90L badged as ''S90长轴距 T4''
* 2018–present Volvo V90 II badged as ''V90 T4''

B4204T45

The ''B4204T45'' (??) delivers at 5500 rpm and of torque in the range of 1700–5000 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

This engine is only available with an automatic gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo S60 III badged as ''S60 T6'', ''S60 T6 AWD'' or ''S60 T6 Twin Engine''
* 2019–present Volvo V60 II badged as ''V60 T8'', ''V60 T8 AWD'' or ''V60 T8 Twin Engine''

B4204T46

The ''B4204T46'' (BF) delivers at 5500 rpm and of torque in the range of 1700–5000 rpm. The rear electric motor (ERAD) delivers and of torque. Turbocharger and supercharger.

Battery capacity was 10.4 kWh for model year 2019. It was increased to 11.6 kWh for model year 2020.

This engine is only available with the AW TG-81SD gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–present Volvo S60 II badged as ''S60 T6 AWD''
* 2019–present Volvo V60 II badged as ''V60 T6 Twin Engine'', ''V60 T6 Twin Engine AWD'' or ''V60 T6 Twin Engine eAWD''
* 2021–present Volvo XC60 II badged as ''XC60 Recharge T6'' or ''V60 T6 AWD Recharge''

B4204T47

The ''B4204T47'' (AC) delivers at 4700 rpm and of torque in the range of 1400–4000 rpm. The compression ratio was changed to 11.3:1. Single turbocharger.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2019–present Volvo XC40 badged as ''XC40 T4'' or ''XC40 T4 AWD''

B4204T48

The ''B4204T48'' (BT) delivers at 5800–6100 rpm and of torque at 4500 rpm. The rear electric motor (ERAD) delivers 87 PS (64 kW; 86 hp) and 240 N⋅m (180 lb⋅ft) of torque. Turbocharger and supercharger.

Battery capacity is 11.6 kWh.

This engine is only available with the AW TG-81SD gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–2022 Volvo S60 III badged as ''S60 Polestar Engineered'' or ''S60 T8 Twin Engine Polestar Engineered''
* 2020–2022 Volvo V60 II badged as ''V60 Polestar Engineered'' or ''V60 T8 Twin Engine Polestar Engineered''
* 2020–2022 Volvo XC60 II badged as ''XC60 Polestar Engineered'' or ''XC60 T8 Twin Engine Polestar Engineered''
* 2019 Polestar 1 badged as ''Polestar 1''

B4204T49

•Power Output: 246 kW (335 hp) at 6000 rpm

•Torque: 430 Nm at 4500 rpm

•Applications:
*2020–present Volvo XC60 T8 Twin Engine Polestar
*2020–present Volvo S60 T8 Twin Engine Polestar Engineered

B4204T52

•Power Output: 186 kW (253 hp) at 5500 rpm

•Torque: 350 Nm between 2600–5000 rpm

•Applications:
* 2020–present Volvo XC60 T6 AWD Twin Engine
* 2020–present Volvo V60 T6 Twin Engine

B4204T53

•Power Output: 233 kW (317 hp) at 6000 rpm

•Torque: 400 Nm between 3000–5400 rpm

•Applications:
* 2020–present Volvo XC60 T8 AWD Twin Engine
* 2020–present Volvo S60 T8 Twin Engine

B4204T56

•Power Output: 228 kW (310 hp) at 6000 rpm

•Maximum Rated Power: 253 kW (344 hp) at 6000 rpm

•Torque: 400 Nm between 3000–4800 rpm

•Applications:
* 2020–present Volvo XC60 T8 AWD Twin Engine
* 2021–present Volvo S90 T8 AWD Twin Engine

B4204T57

•Power Output: 233 kW (317 hp) at 6000 rpm

•Torque: 400 Nm between 3000–5400 rpm

•Applications:
* 2020–present Volvo XC60 T8 AWD Twin Engine
* 2020–present Volvo S60 T8 Twin Engine
* 2020–present Volvo V60 T8 Twin Engine

B4204TSH

•Power Output: 233.5 kW (313 hp) at 6000 rpm

•Torque: 400 Nm between 3000–5400 rpm

•Applications:
* 2022–present Volvo XC90 T8 Recharge
* 2022–present Volvo XC60 T8 Recharge
* 2022–present Volvo S90 T8 Recharge
* 2022–present Volvo S60 T8 Recharge
* 2022–present Volvo V60 T8 Recharge

Diesel (VED4) (2013-2024)

2.0

All 2.0 L (1,969 cc) diesel engines have a bore of and a stroke of with a compression ratio of 15.8:1. All engines are turbocharged and intercooled, certain variants are twin turbocharged. Some variants additionally are equipped with Variable Nozzle Turbine (VNT) turbochargers. In order to achieve injection pressures of up to 2500 bar all engines are equipped with a belt driven fuel pump. High power variants are equipped with balancer shafts and all variants have a mechanical water pump. Volvo has ceased production of all diesel engines, with the last diesel-equipped vehicle built in March 2024.

D420T2 / D4204T2

The ''D420T2 / D4204T2'' (K2) delivers at 4000 rpm and of torque in the range of 1750–2250 rpm. The BISG delivers at 3000 rpm and of torque in the range of 0–2300 rpm. Twin turbochargers.

This engine is only available with the AWF8G55 gearbox.

Emissions level Euro 6d-TEMP.

Applications:
* 2020–2024 Volvo XC60 II badged as ''XC60 B5 AWD''
* 2020–2024 Volvo XC90 II badged as ''XC90 B5 AWD''

D420T8 / D4204T8

The ''D420T8 / D4204T8'' (K5) delivers at 4000 rpm and of torque in the range of 1750–2750 rpm. The BISG delivers at 3000 rpm and of torque in the range of 0–2300 rpm. Twin turbochargers.

This engine is only available with the AWF8G55 gearbox.

Emissions level Euro 6d-Temp.

Applications:
* 2020–2024 Volvo XC60 II badged as ''XC60 B4 AWD''

D4204T4

The ''D4204T4'' (AR) originally delivered at 4250 rpm, and of torque in the range of 1500–2500 rpm. Upgraded to at 4250 rpm, and of torque in the range of 1500–2500 rpm. Twin turbochargers.

Emissions level Euro 6, later upgraded to emissions level Euro 6d-TEMP.

Applications:
* 2017–2018 Volvo S60CC badged as ''S60CC D3 AWD''
* 2016–2018 Volvo V60CC badged as ''V60CC D3''
* 2016–2018 Volvo XC60 badged as ''XC60 D3''
* 2019–2024 Volvo V60 II badged as ''V60 D3 AWD''
* 2019–2024 Volvo V60CC II badged as ''V60CC D3 AWD''
* 2018–2024 Volvo XC60 II badged as ''XC60 D3''
* 2017–2024 Volvo V90 II badged as ''V90 D3 AWD''
* 2020–2024 Volvo XC60 II badged as ''XC60 D4''

D4204T5

The ''D4204T5'' (73) delivers at 4250 rpm and of torque in the range of 1750–2500 rpm. Twin turbochargers.

This engine is available with the M66, AW TF-71SC and AW TG-81SC gearbox.

Emissions level Euro 6.

Applications:
* 2014–2015 Volvo S60 II badged as ''S60 D4''
* 2014–2015 Volvo V60 badged as ''V60 D4''
* 2014–2016 Volvo S80 II badged as ''S80 D4''
* 2014–2016 Volvo V70 III badged as ''V70 D4''
* 2014–2016 Volvo XC60 badged as ''XC60 D4''
* 2014–2016 Volvo XC70 II badged as ''XC70 D4''

D4204T6

The ''D4204T6'' (A7) delivers at 4250 rpm and of torque in the range of 1500–2500 rpm. Single turbocharger.

Emissions level Euro 6.

Applications:
* 2016–2018 Volvo XC90 II badged as ''XC90 D4 AWD''

D4204T8

The ''D4204T8'' (74) delivers at 3750 rpm and of torque in the range of 1500–2250 rpm. The compression ratio was changed to 16.0:1. Single turbocharger.

This engine was available with the M66 gearbox until model year 2017, afterwards it was available with the M76 gearbox. All model years are available with the AW TF-71SC gearbox.

Emissions level Euro 6, upgraded to Euro 6d-TEMP.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 D2''
* 2016–2019 Volvo V40CC badged as ''V40CC D2''
* 2016–2018 Volvo S60 II badged as ''S60 D2''
* 2016–2018 Volvo V60 badged as ''V60 D2''

D4204T9

The ''D4204T9'' (79) delivers at 3750 rpm and of torque in the range of 1750–3000 rpm. The compression ratio was changed to 16.0:1. Single turbocharger with VNT.

This engine was available with the M66F gearbox until model year 2017, afterwards it was available with the M76 gearbox. All model years are available with the AW TF-71SC gearbox.

Emissions level Euro 6, upgraded to Euro 6d-TEMP.

Applications:
* 2016–2019 Volvo V40 II badged as ''V40 D3''
* 2016–2019 Volvo V40CC badged as ''V40CC D3''
* 2018–2024 Volvo XC40 badged as ''XC40 D3'' or ''XC40 D3 AWD''
* 2016–2018 Volvo S60 II badged as ''S60 D3''
* 2016–2019 Volvo V60 badged as ''V60 D3''
* 2016 Volvo V70 III badged as ''V70 D3''
* 2017–2019 Volvo S90 II badged as ''S90 D3''
* 2017–2019 Volvo V90 II badged as ''V90 D3''

D4204T11

The ''D4204T11'' (A4) delivers at 4250 rpm and of torque in the range of 1750–2500 rpm. Twin turbochargers.

This engine is only available with the AW TG-81SC gearbox.

Emissions level Euro 6b.

Applications:
* 2016–2018 Volvo S60 II badged as ''S60 D5''
* 2016–2018 Volvo V60 badged as ''V60 D5''
* 2016 Volvo XC90 II badged as ''XC90 D5 AWD''

D4204T12

The ''D4204T12'' (A6) delivers at 4000 rpm and of torque in the range of 1750–2500 rpm. Twin turbochargers.

The engine is equipped with a SCR system that has a 14.5 L AdBlue tank.

Emissions level Euro 6d-TEMP.

Applications:
* 2018–2024 Volvo XC40 badged as ''XC40 D4 AWD''

D4204T13

The ''D4204T13'' (70) delivers at 3750 rpm and of torque in the range of 1500–2250 rpm. Single turbocharger.

Emissions level Euro 6d-TEMP.

Applications:
* 2019 Volvo V40 II badged as ''V40 D2''
* 2019 Volvo V40CC badged as ''V40CC D2''

D4204T14

The ''D4204T14'' (A8) delivers at 4250 rpm and of torque in the range of 1750–2500 rpm. Twin turbochargers.

This engine is available with the M66F and AW TG-81SC gearbox.

Emissions level Euro 6 for CC models, non CC models Euro 6b for model years 2016 to 2018 and for the XC60 II, V60 II emissions level Euro 6d-TEMP.

Applications:
* 2015–2019 Volvo V40 II badged as ''V40 D4''
* 2015–2019 Volvo V40CC badged as ''V40CC D4''
* 2016–2018 Volvo S60 II badged as ''S60 D4''
* 2016–2018 Volvo S60CC badged as ''S60CC D4''
* 2016–2018 Volvo V60 badged as ''V60 D4''
* 2016–2018 Volvo V60CC badged as ''V60CC D4''
* 2019–2024 Volvo V60 II badged as ''V60 D4'' or ''V60 D4 AWD''
* 2019–2024 Volvo V60CC II badged as ''V60CC D4 AWD''
* 2014–2017 Volvo XC60 badged as ''XC60 D4''
* 2017–2024 Volvo XC60 II badged as ''XC60 D4'' or ''XC60 D4 AWD''
* 2016–2024 Volvo S90 II badged as ''S90 D4'' or ''S90 D4 AWD''
* 2016–2024 Volvo V90 II badged as ''V90 D4'' or ''V90 D4 AWD''
* 2016–2024 Volvo V90CC badged as ''V90CC D4 AWD''
* 2015–2024 Volvo XC90 II badged as ''XC90 D4''

D4204T16

The ''D4204T16'' (72) delivers at 3750 rpm and of torque in the range of 1750–3000 rpm. The compression ratio was changed to 16.0:1. Single turbocharger.

This engine is available with the M76 R7.0, M66F and AW TG-81SC gearbox.

The engine is equipped with a SCR system that has a 11.5 L AdBlue tank for SPA models or 14.5 L AdBlue tank for CMA models.

Emissions level Euro 6d-TEMP.

Applications:
* 2018–2019 Volvo V40CC badged as ''V40CC D3''
* 2018–2024 Volvo XC40 badged as ''XC40 D3'' or ''XC40 D3 AWD
* 2019–2024 Volvo V60 II badged as ''V60 D3''
* 2019–2024 Volvo S90 II badged as ''S90 D3''

D4204T20

The ''D4204T20'' (78) delivers at 3750 rpm and of torque in the range of 1500–2250 rpm. Engine variant for cars equipped with an automatic gearbox. Single turbocharger.

Emissions level Euro 6b.

Applications:
* 2016–2018 Volvo S60 II badged as ''S60 D2''
* 2016–2018 Volvo V60 badged as ''V60 D2''
* 2015–2016 Volvo V70 III badged as ''V70 D2''

D4204T23

The ''D4204T23'' (65) delivers at 4000 rpm and of torque in the range of 1750–2250 rpm. Twin turbochargers, one with VNT. Equipped with PowerPulse.

This engine is only available with the AW TG-81SC gearbox.

Starting with model year 2018 the engine is equipped with a SCR system that has a 11.5 L AdBlue tank except model year 2018 built between week 43 2017 - 01 2018).

Emissions level Euro 6, for model year 2018 upgraded to emissions level Euro 6d-TEMP.

Applications:
* 2018–2024 Volvo XC60 II badged as ''XC60 D5 AWD''
* 2017–2024 Volvo S90 II badged as ''S90 D5 AWD''
* 2017–2024 Volvo V90 II badged as ''V90 D5 AWD''
* 2017–2024 Volvo V90CC badged as ''V90CC D5 AWD''
* 2017–2024 Volvo XC90 II badged as ''XC90 D5 AWD''

Notes

References

{{Volvo cars

Volvo engines