Ufer Ground System
   HOME

TheInfoList



OR:

The Ufer ground is an electrical earth grounding method developed during World War II. It uses a concrete-encased electrode to improve grounding in dry areas. The technique is used in construction of concrete foundations.


History

During World War II, the U.S. Army required a grounding system for bomb storage vaults near
Tucson Tucson (; ; ) is a city in Pima County, Arizona, United States, and its county seat. It is the second-most populous city in Arizona, behind Phoenix, Arizona, Phoenix, with a population of 542,630 in the 2020 United States census. The Tucson ...
and
Flagstaff, Arizona Flagstaff ( ), known locally as Flag, is the county seat of Coconino County, Arizona, in the southwestern United States. As of the 2020 United States census, the city's population was 76,831. Flagstaff is the principal city of the Coconino Cou ...
. Conventional grounding systems did not work well in this location since the desert terrain had no
water table The water table is the upper surface of the phreatic zone or zone of saturation. The zone of saturation is where the pores and fractures of the ground are saturated with groundwater, which may be fresh, saline, or brackish, depending on the loc ...
and very little rainfall. The extremely dry soil conditions would have required hundreds of feet of rods to be driven into the earth to create a low impedance ground to protect the buildings from lightning strikes. In 1942, Herbert G. Ufer was a consultant working for the U.S. Army. Ufer was given the task of finding a lower cost and more practical alternative to traditional copper rod grounds for these dry locations. Ufer discovered that concrete had better conductivity than most types of soil. Ufer then developed a grounding scheme based on encasing the grounding conductors in concrete. This method proved to be very effective, and was implemented throughout the Arizona test site. After the war, Ufer continued to test his grounding method, and his results were published in a paper presented at the
IEEE The Institute of Electrical and Electronics Engineers (IEEE) is an American 501(c)(3) organization, 501(c)(3) public charity professional organization for electrical engineering, electronics engineering, and other related disciplines. The IEEE ...
Western Appliance Technical Conference in 1963. The use of concrete enclosed grounding conductors was added to the U.S.
National Electrical Code The National Electrical Code (NEC), or NFPA 70, is a regionally adoptable standard for the safe installation of electrical wiring and equipment in the United States. It is part of the National Fire Code series published by the National Fire Prote ...
(NEC) in 1968. It was not required to be used if a water pipe or other grounding electrode was present. In 1978, the NEC allowed 1/2 inch rebar to be used as a grounding electrode EC 250.52(A)(3) The NEC refers to this type of ground as a "Concrete Encased Electrode" (CEE) instead of using the name Ufer ground. Over the years, the term "Ufer ground" has become synonymous with the use of any type of concrete enclosed grounding conductor, whether it conforms to Ufer's original grounding scheme or not.


Construction

Concrete Concrete is a composite material composed of aggregate bound together with a fluid cement that cures to a solid over time. It is the second-most-used substance (after water), the most–widely used building material, and the most-manufactur ...
is naturally
basic Basic or BASIC may refer to: Science and technology * BASIC, a computer programming language * Basic (chemistry), having the properties of a base * Basic access authentication, in HTTP Entertainment * Basic (film), ''Basic'' (film), a 2003 film ...
(has high pH). Ufer observed this to mean that it had a ready supply of
ion An ion () is an atom or molecule with a net electrical charge. The charge of an electron is considered to be negative by convention and this charge is equal and opposite to the charge of a proton, which is considered to be positive by convent ...
s and so provides a better electrical ground than almost any type of soil. Ufer also found that the soil around the concrete became "doped", and its subsequent rise in pH caused the overall impedance of the soil itself to be reduced. The concrete enclosure also increases the surface area of the connection between the grounding conductor and the surrounding soil, which also helps to reduce the overall impedance of the connection. Ufer's original grounding scheme used copper encased in concrete. However, the high pH of concrete often causes the copper to chip and flake. For this reason, steel is often used instead of copper. When homes are built on concrete slabs, it is common practice to bring one end of the
rebar Rebar (short for reinforcement bar or reinforcing bar), known when massed as reinforcing steel or steel reinforcement, is a tension device added to concrete to form ''reinforced concrete'' and reinforced masonry structures to strengthen and aid ...
up out of the concrete at a convenient location to make an easy connection point for the grounding electrode. Ufer grounds, when present, are preferred over the use of grounding rods. In some areas (like
Des Moines, Iowa Des Moines is the List of capitals in the United States, capital and List of cities in Iowa, most populous city in the U.S. state of Iowa. It is the county seat of Polk County, Iowa, Polk County with parts extending into Warren County, Iowa, Wa ...
) Ufer grounds are required for all residential and commercial buildings. The conductivity of the soil usually determines if Ufer grounds are required in any particular area. An Ufer ground of specified minimum dimensions is recognized by the U.S. National Electrical Code as a grounding electrode. The grounding conductors must have sufficient cover by the concrete to prevent damage when dissipating high-current lightning strikes. A disadvantage of Ufer grounds is that the moisture in the concrete can flash into steam during a lightning strike or similar high energy fault condition. This can crack the surrounding concrete and damage the building foundation."Electrical Overstress/Electrostatic Discharge Symposium Volume 22" By ESD Association, Institute of Electrical and Electronics Engineers


References


External links

* {{cite web , url=http://www.psihq.com/iread/ufergrnd.htm , title=The Ufer Ground , date=1995 , archive-url=https://web.archive.org/web/20220304133528/http://www.psihq.com/iread/ufergrnd.htm , access-date=September 13, 2022, archive-date=2022-03-04
A new look at the Ufer ground system
Electrical safety Electrical wiring Foundations (buildings and structures)