Tire fire

Tire fires are events that involve the combustion of large quantities of tires, usually waste tires, typically in locations where they are stored, dumped, or processed. They exist in two forms: as fast-burning events, leading to almost immediate loss of control, and as slow-burning pyrolysis which can continue for over a decade. They are noted for being difficult to extinguish. Such fires produce much smoke, which carries toxic chemicals from the breakdown of synthetic rubber compounds while burning.

Tire fires are normally the result of arson or improper manipulation with open fire. Tires are not prone to self-ignition, as a tire must be heated to at least for a period of several minutes prior to ignition.

Extinguishing tire fires is difficult. The fire releases a dark, thick smoke that contains cyanide, carbon monoxide, sulfur dioxide, and products of butadiene and styrene. Burning tires are heated, and, as they have a low thermal conductivity, they are difficult to cool down. Moreover, they frequently burn inside even if they are extinguished from outside, and easily reignite when hot. One possible remedy is to cover the fire with sand, reducing the supply of oxygen and the exhaust of smoke. After extinguishing and cooling down (which may last several days), toxic chemicals can be neutralized.

In Northern Europe, new and used tires are stored in large warehouses also known as tire hotels. Fire is a growing concern, and as tire fires are difficult to extinguish, regular sprinkler systems are not sufficient. Inert gas extinguishing systems in combination with an effective detection system would be the preferred choice for protecting these warehouses. Tests for establishing the minimum design concentration (MDC) are currently being performed in Denmark.

Notable tire fires

Some notable tire fires include:

*1983 – Arsonists ignited seven million tires that burned for nine months in Winchester, Virginia, polluting nearby areas with lead and arsenic. The location was cleaned up as a Superfund project from 1983 to 2002.
*1984 – A pile estimated at four million tires, known locally as Mount Firestone, ignited in Everett, Washington, and burned for months as the fire department was unable to extinguish it.
*1989 – In Heyope (near Knighton, Powys, Wales), a fire involving approximately 10 million tires began which still smouldered 15 years later.
*1990 – In Hagersville, Ontario, a fire started in a pile of 12 to 14 million tires; it burned for 17 days and forced 4,000 people to evacuate.
*1994 – In East Chicago, Indiana, a fire consumed 70,000 tons of tires and shredded rubber. It started on July 16, 1994 and burned until August 22, 1994.
*1995 – The Hornburg tire fire in Sinclairville, New York burned over a million tires in a blaze lasting more than a week.
*1996 – An arson in March at an illegal tire yard underneath a section of I-95 in Philadelphia caused $6 million in damage and completely closed a section of the highway for weeks and partial closures for six months.
*1998 – A grass fire ignited the 7 million tires at the unlicensed S.F. Royster Tire Disposal Facility in Tracy, California. It was extinguished, after 26 months, with water and foam in December 2000.
*1999 – On August 21, arsonists ignited the former Kirby Tire Recycling facility, containing an estimated 25 million tires located on near Sycamore, Ohio. The fire burned for 30 hours, involved over 250 firefighters, the Ohio National Guard and the U.S. Environmental Protection Agency (EPA) and caused significant environmental damage. The fire was controlled and finally extinguished in part by covering it with dirt. In the intervening years the EPA has performed a massive clean up effort on the site.
*1999 – Lightning struck a tire dump in Westley, California, which burned for 30 days. Pyrolitic oil flowed into a nearby stream and also ignited.
*2002 – The EnTire Tire Recycling facility in Nebraska City, Nebraska burned for over eleven days. An explosion occurred during the firefighting effort, injuring thirteen firefighters. Multiple evacuations of up to a 30-block area were ordered during the event. Over 40 agencies assisted during the event at an estimated cost of $1.4 million.
*2005 – A fire started at Watertown Tire Recyclers in Watertown, Wisconsin on July 19 and burned for six days. 108 fire departments and more than 25 agencies assisted in handling the disaster.
*2008 – a malfunction in the chopper/shredder line of the Golden by-products tire recycling plant in Ballico, California ignited rubber debris around the conveyor system which then ignited two multi-ton piles of shredded/chopped rubber. It only burned for about 12 hours but took over 1 million gallons of water to extinguish. The piles were allowed to form a crust which in turn smothered the fires in them. The plant was later cited for exceeding permitted capacity.
*2012 – On January 27, 2012, a massive tire fire sparked at a tire recycling plant in Lockport, New York, causing dangerous amounts of soot and smoke to burn over the city for over 22 hours, causing serious damage to many homes.
*2012 – In Sulaibiya, Kuwait, a five million tire fire erupted on April 16, 2012. The fire was thought to be started deliberately by scrap metal hawkers looking to recover scrap metal.
*2012 – In Iowa City, Iowa, at approximately 6:45 p.m. on May 26, 2012, a fire started in the ground tire bedding material at the Iowa City Landfill, involving at least 7.5 acres of landfill. It was finally extinguished on June 12, 2012, after a "stir, burn and cover" operation.
*2012 – Tire fire protests erupted all over Lebanon. Protesters used burning tires to cut off main roads in Lebanon.
*2013 – Static electricity ignited a fire at J&R Tire Recycling in Hoopeston, Illinois. Over 100 firefighters from two states fought the fire, in which over 50,000 tires burned, for three days.
*2013 – Tire fire ignited in Nassau, Bahamas. The poorly managed municipal dump has had multiple fires and finally resulted in a tire fire on August 13.
*2014 – Tire fire ignited in Savannah, Georgia on February 8, 2014.
* 2015 – On August 18, in northwest Oklahoma, a tire fire in a large pile of tires next to the premises of A&T Tire and Wheel set the exterior of the business ablaze, but crews prevented flames from getting inside.
* 2015 – On August 18, a fire in Oregon disrupted the Warm Springs Tribal Reservation. Erroneously referred to by locals and news media as a "tire fire", the blaze caused by the sparks formed from a recreational vehicle driving on a bare rim engulfed more than 60,000 acres of land at the reservation.
* 2016 – On May 13, in Seseña, Spain, a fire started in a tire dump containing around 5 million tires.
* 2016 – On August 10, a tire fire sparked at Liberty Tire Recycling in Lockport, New York. Over 8 million pounds of crumb rubber ignited, destroying four buildings and evacuating over 400 families from nearby homes.
* 2017 – On January 17, a tire fire started at Federal Corporation Zhongli Factory in Taoyuan, Taiwan. More than half the factory (50,000 square meters) was on fire and over 140 families were evacuated from nearby homes. The area was heavily contaminated with carbon black.
* 2017 – On March 5 at 10:58 pm, firefighters responded to a fire at the EnTire Recycling facility in Phelps City, Missouri. Heavy smoke caused intermittent closure of Highway 136 and officials to advise nearby residents to avoid breathing the smoke, which could be seen over 10 miles away. This fire continued to smolder through August 2017.
* 2017 – On April 9, a controlled tire fire was started in West Odessa, Texas.
* 2020 – On July 22 at 4:30 pm, firefighters in Weld County, Colorado responded to a fire at a tire recycling facility. Early reports suggested a fire began on equipment which quickly spread to piles of tires. Local officials requested aid from a supertanker aircraft due to the size of the fire and unseasonably dry conditions.
*2020 – On October 18, a massive fire in the Sulaibiya tire graveyard, the site of a similar fire in 2012, burned approximately 1 million tires in 25,000 square meters.
*2020 - On November 16, 90 firefighters and 15 appliances attended a major fire involving 600,000 tires stored at a former go-karting facility in Bradford, England. The fire was declared out a week later. Three people were arrested in connection to the fire, however they were later released without charge.
*2021 — On November 9, approximately 100 firefighters responded to a tire fire at a recycling facility in southwest Philadelphia. Unusual winds brought the fire's smoke across Philadelphia's Center City and into New Jersey.

In popular culture

In popular culture the phrase is used to mean a horrifying mess that seems to last forever.

The TV show The Simpsons is set in a fictional town called Springfield, which features a permanent tire fire.

See also

*Tire recycling

References

External links

U.S. Environmental Protection Agency: Tire Fires

{{Tires, state=collapsed

Fire
Types of fire