The Ludington Pumped Storage Plant is a hydroelectric plant and

reservoir A reservoir (; from French ''réservoir'' ) is an enlarged lake behind a dam. Such a dam may be either artificial, built to store fresh water or it may be a natural formation. Reservoirs can be created in a number of ways, including contro ...

Ludington, Michigan Ludington ( ) is the largest city and county seat of Mason County in the U.S. state of Michigan. As of the 2010 census, the city population was 8,076. Ludington is a harbor town located on Lake Michigan at the mouth of the Pere Marquette River ...

. It was built between 1969 and 1973 at a cost of $315 million and is owned jointly by

Consumers Energy Consumers Energy is an investor owned utility that provides natural gas and electricity to 6.7 million of Michigan's 10 million residents. It serves customers in all 68 of the state's Lower Peninsula counties. It is the primary subsidiary of C ...

and DTE Energy and operated by Consumers Energy. At the time of its construction, it was the largest pumped storage hydroelectric facility in the world.

Characteristics

It consists of a reservoir deep, long, and wide which holds or 82859

acre-feet The acre-foot is a non- SI unit of volume equal to about commonly used in the United States in reference to large-scale water resources, such as reservoirs, aqueducts, canals, sewer flow capacity, irrigation water, and river flows. An acre-f ...

of water. The reservoir is located on the banks of Lake Michigan. Because impervious bedrock is more than below the reservoir, the builders had to line the reservoir with a layer of asphalt and clay to prevent water seeping into the ground. The power plant consists of six reversible turbines that can each generate 312 megawatts of electricity for a total output of 1,872 megawatts. Water is delivered from the upper reservoir to the turbines by six

penstock A penstock is a sluice or gate or intake structure that controls water flow, or an enclosed pipe that delivers water to hydro turbines and sewerage systems. The term is inherited from the earlier technology of mill ponds and watermills. H ...

s each long that taper from in diameter. At night, during low demand for electricity, the turbines run in reverse to pump water uphill from Lake Michigan into the reservoir. The plant takes advantage of the natural steep sand dune landform of eastern Lake Michigan. During periods of peak demand water is released to generate power. Electrical generation can begin within two minutes with peak electric output of 1872 MW achieved in under 30 minutes. Maximum water flow is over per minute. This process was designed to level the load of nearby nuclear power plants on the grid. It also replaces the need to build natural gas peak power plants used only during high demand. The Ludington Pumped Storage plant is connected to six 345-kV Transmission lines, all owned and maintained by METC, a subsidiary of ITC Holdings. The project was given the 1973 award for "Outstanding Civil Engineering Achievement" by the

American Society of Civil Engineers American(s) may refer to: * American, something of, from, or related to the United States of America, commonly known as the "United States" or "America" ** Americans, citizens and nationals of the United States of America ** American ancestry, pe ...

Upgrade

Consumers Energy discussed plans in 2008 to extend the life of the facility and upgrade the pumps to increase efficiency by up to 9%. Consumers Energy also planned to tap the

wind power Wind power or wind energy is mostly the use of wind turbines to generate electricity. Wind power is a popular, sustainable, renewable energy source that has a much smaller impact on the environment than burning fossil fuels. Historically ...

resources along the eastern Lake Michigan shore with

wind farm A wind farm or wind park, also called a wind power station or wind power plant, is a group of wind turbines in the same location used to produce electricity. Wind farms vary in size from a small number of turbines to several hundred wind turb ...

s. Because wind is an

intermittent power source Variable renewable energy (VRE) or intermittent renewable energy sources (IRES) are renewable energy sources that are not dispatchable due to their fluctuating nature, such as wind power and solar power, as opposed to controllable renewable ener ...

and may inconveniently deliver large amounts of power during periods of low electric demand, pumped storage facilities are desirable to have on the same grid with large-scale wind farms. The available pumped storage capacity, along with the wind characteristics, partly determine the maximum contribution wind power can make to the overall electricity use in a region. Consumers Energy and Detroit Edison announced an $800 million upgrade on February 7, 2011. The six-year project would begin in 2013 and extend the plant's life by at least forty years and upgrade the generating capacity from 1,872 megawatts to 2,172 megawatts. Plans for the upgrade include replacing all six of the plant's turbines, which would increase the plant's total generating capacity by 15 percent, and efficiency by 5 percent. Upon completion, the plant will produce enough power for a community of 1.65 million (a quarter million increase). As of August 2020, five of the six turbines had been successfully replaced; the project was expected to be completed in May or June 2021. However claims of defective parts and timeline overruns led Consumers Power and Detroit Edison to sue the project contractor, Toshiba America in April 2022.Consumers, DTE sue contractor over ‘defective work,’ project delays in $500M Ludington pumped storage plant upgrade
mibiz, Andy Blaskowitz, April 22, 2022

References

External links

Ludington Pumped Storage Plant (Official Site)
{{authority control Dams in Michigan Energy infrastructure completed in 1973 Hydroelectric power plants in Michigan Buildings and structures in Mason County, Michigan Pumped-storage hydroelectric power stations in the United States DTE Energy CMS Energy Reservoirs in Michigan Bodies of water of Mason County, Michigan 1973 establishments in Michigan

Characteristics

Upgrade

See also

References

External links