FMA IA 58 Pucará

The FMA IA 58 Pucará ( qu, Fortress) is an Argentine ground-attack and counter-insurgency (COIN) aircraft manufactured by the Fábrica Militar de Aviones. It is a low-wing twin-turboprop all-metal monoplane with retractable landing gear, capable of operating from unprepared strips when operationally required. The type saw action during the Falklands War and the Sri Lankan Civil War.

Development

In August 1966 the Argentine state aircraft factory, Dirección Nacional de Fabricación e Investigación Aeronáutica (DINFIA), began development of the AX-2, a Counter-insurgency (COIN) aircraft to meet a requirement of the Argentine Air Force. The project was promoted by engineer Ricardo Olmedo and became under the guidance of engineer Aníbal Dreidemie, who also designed the IA-52 Guaraní II and the IA-63 Pampa. The chosen layout was a low-wing monoplane powered by two turboprop engines mounted in wing-mounted nacelles and fitted with a T-tail. In order to test the proposed layout, DINFIA first built a full-scale unpowered glider test vehicle, which flew for the first time on 26 December 1967.''Air International'' October 1977, p. 166.Donald ''World Air Power Journal'' Volume 6, p. 137.

Testing of the glider showed no major handling problems, and in September 1968, construction began on a powered prototype, given the designation FMA IA 58 Delfín, but later renamed Pucará, to be powered by a pair of Garrett TPE331I/U-303 engines. (DINFIA had been renamed the '' Fábrica Militar de Aviones'' (FMA) earlier that year). The first prototype made its maiden flight on 20 August 1969, with a second prototype, with power switching to Turbomeca Astazou XVIGs, following on 6 September 1970.Donald ''World Air Power Journal'' Volume 6, pp. 137–138. The first prototype was later re-engined with the Astazou, this engine being chosen for the production version, and a third production prototype followed in 1973.''Air International'' October 1977, pp. 166–167. The first production model flew on 8 November 1974, with deliveries beginning in early 1976.Taylor 1982, p. 4.

At least three projects were related to the IA-58 development. The first was an extended Pucará airframe with pressurized cabin for six passengers, equipped with Astafan turbofan engines for light transport and photography duties. The second was an observation and reconnaissance aircraft having the same configuration as the Fairchild-Republic A-10. The third was denominated IA-60 and was an advanced trainer and light attack platform powered by two Astafans conserving the basic airframe and canopy of the Pucará with T-tail incorporating high wings. Some tests were made on wind tunnels but no further development was made in order to proceed with the IA-63 Pampa program.

Design

The IA 58 Pucará is of conventional, all-metal (mainly duralumin) construction. The unswept cantilever wings have 7 degrees of dihedral on the outer panels and are fitted with slotted trailing-edge flaps. The IA-58 has a slender fuselage, with a tandem cockpit arrangement; the crew of two is seated under the upward opening clamshell canopy on Martin-Baker Mk 6AP6A zero/zero ejection seats and are provided with dual controls and good visibility, at least in the lateral and front quarters. The clean aerodynamic design allow the Pucará to reach relatively high speed, higher than the American OV-10 Bronco, another COIN aircraft. On the other hand, the IA 58 has no cargo bay inside the fuselage as requested for the American aircraft.

Armour plating is fitted to protect the crew and engines from ground fire. The aircraft is powered by a pair of Turbomeca Astazou engines, driving sets of three-bladed Ratier-Forest 23LF propellers; the propellers are also capable of being used as air brakes.

The Pucará was designed for operations from short, rough airstrips.''Air International'' October 1977, pp. 167–168. The retractable tricycle landing gear, with a single nosewheel and twin mainwheels retracting into the engine nacelles, is fitted with low pressure tyres to suit operations on rough ground, while the undercarriage legs are tall to give good clearance for underslung weapons loads.Donald ''World Air Power Journal'' Volume 6, p. 138. Three JATO rockets can be fitted under the fuselage to allow extra short takeoffs. Fuel is fed from two fuselage tanks of combined capacity of and two self-sealing tanks of in the wings. The undercarriage, flaps and brakes are operated hydraulically, with no pneumatic systems. The spring suspension system is like the one used in the Junkers Ju 88, while the tail has a T configuration to improve take-off.

Fixed armament of the Pucará is about comparable with WWII era aircraft, directly comparable with the layout used in the German Bf 110. It consists of two Hispano 804 20 mm cannons mounted under the cockpit with 270 rounds each and four 7.62 mm Browning FN machine guns mounted on the sides of the fuselage with 900 rounds each. Three hardpoints are fitted for carrying external stores single or in clusters (as example up to six bombs under the fuselage or two rockets under each wing) such as bombs, rockets or external fuel tanks, with one of capacity mounted under the fuselage and the remaining two, of capacity beneath the wings. Total external weapons load is limited to .''Air International'' October 1977, pp. 170–171. Onboard armaments are aimed by a simple reflector sight.Donald ''World Air Power Journal'' Volume 6, p. 139.

Operational history

The first units were delivered in May 1975 to the Argentine Air Force ( es, Fuerza Aérea Argentina, FAA), equipping the 2° ''Escuadron de Exploración y Ataque'', part of the 3rd Air Brigade ( es, III Brigada Aérea) in Reconquista, northern Santa Fe province. They had their operational debut late in 1975, when a number of Pucarás carried out counter-insurgency strikes from Córdoba against Communist ERP guerillas in Tucumán Province as part of Operativo Independencia.''Air International'' October 1977, p. 167.

1982 Falklands war

By the time of the Falklands War, about 60 Pucarás had been deliveredHuertas ''Air International'' April 1996, p. 248. As one of the few aircraft of the Argentine service capable of flying operationally from the small airfields in the Falklands, as the runway at Port Stanley Airport was not long enough for FAA Skyhawks and Mirages to be deployed,Burden et al. 1986, p. 95. it was decided to deploy a number of Pucarás to the Falklands, with four arriving at Port Stanley on 2 April 1982, and a further eight arriving on 9 April. Many of the Pucarás remaining on the mainland were moved to Puerto Santa Cruz or Comodoro Rivadavia in southern Argentina where they were closer to the Falklands if needed for reinforcements, and were used to perform coastal surveillance.Burden et al. 1986, pp. 95, 97.Huertas ''Air International'' April 1996, pp. 248–249.

Most aircraft used in combat were armed with unguided bombs, 2.75 inch rocket pods, or 7.62 mm machine gun pods. Pucarás operated from Port Stanley airport and two small grass improvised airfields at Goose Green and Pebble Island. They were used in the reconnaissance and light-attack role.

Three Pucarás were destroyed and one of their pilots killed at Goose Green by cluster bombs dropped by 800 NAS Sea Harriers on 1 May 1982. Six more were destroyed in the SAS Raid on Pebble Island on 15 May 1982.

On 21 May a Pucará was lost to a Stinger SAM fired by D Squadron SAS (the first Stinger launched in combat) and another to 30 mm cannon rounds from Cmdr Nigel Ward's RN Sea Harrier, the latter after leading a successful two-aircraft raid on a shed allegedly used as an observation post by British forces. The aircraft was surprisingly tough, as Ward observed no fewer than 20 cannon hits before the target started to fall to earth. The other Pucará, piloted by Lt Juan Micheloud, made good its escape after being chased by Lt Cdr Alasdair Craig's Sea Harrier. Major Carlos Tomba, the pilot of the aircraft shot down by Cmdr Ward, survived the ejection and was recovered by friendly forces.

Up to 161 4.5 in (113 mm) shells, fired by the frigate HMS ''Arrow'', struck the airfield at Goose Green on 28 May. ''Arrow'' was assisting 2 Parachute Regiment as it attempted to retake the area. These shells reportedly destroyed two Pucaras at the airfield.

Two Pucarás shot down a Royal Marines Scout helicopter with 7.62 mm machine gun fire on 28 May, while it was on a casualty evacuation mission during the battle of Goose Green. This was the only confirmed Argentine air-to-air victory of the war. One of these Pucarás crashed into Blue Mountain on the return flight to Port Stanley and was destroyed—the body of the pilot (Lt Miguel Gimenez) was found in 1986, and was buried with military honours at Port Darwin by his family, the first Argentine relatives to visit the Falklands since the end of the war.

Also on the 28 May 2 Para shot down a Pucará with small arms fire after it launched rockets on British troops (without causing any casualties), during the Battle of Goose Green. Lt Miguel Cruzado ejected and became a POW.

Captured aircraft

After the Argentine surrender, eleven Pucarás (four of them in flying condition) were captured by British forces. Six were taken back to the United Kingdom, as follows:
*A-515 (ZD485) – Royal Air Force Museum Cosford.
*A-517 – Privately owned. Currently for sale in Asheville, North Carolina, USA.
*A-522 (8768M) – North East Aircraft Museum (on loan from the Fleet Air Arm Museum, Yeovilton).
*A-528 (8769M) – Norfolk and Suffolk Aviation Museum (on loan from Museum of Army Flying, Middle Wallop).
*A-533 (ZD486) – Boscombe Down Aviation Collection (Cockpit Section only).
*A-549 (ZD487) – Imperial War Museum Duxford.

Sri Lankan Civil War

The Sri Lanka Air Force in search for an aircraft for counter-insurgency operations and facing refusal of military supplies from western countries who were its traditional military suppliers, purchased two Pucarás from the Argentine Air Force. These two were attached to the No 1 Flying Training based at SLAF Anuradhapura and were issued SLAF serials CA-601 and CA-602. Following initial training, Pucarás were used in a dual role of pilot training with dual pilots for advance training and combat sorties with a single pilot. In 1993, two more aircraft CA-604 and CA-605 were added. Pucarás were found to be highly effective for the Sri Lanka Air Force as these had high payload capacity and cruising speed for close air support. Operating mainly out of SLAF Anuradhapura, at times Pucarás were detached to its forward base at SLAF Palaly, providing close air support for the Sri Lanka Army notably during Operation Riviresa. Sri Lanka Air Force also deployed Pucarás for maritime patrolling. CA-605 was hit by ground fire over the Kilaly lagoon, but manage to land at SLAF Palaly. It is on display at the Sri Lanka Air Force Museum. During fierce fighting in the Northern Province amides Operation Leap Forward, CA-601 was shot down by a MPADS in July 1995, killing its pilot Flight Lieutenant Dilhan Perera, his body was recovered by an air force rescue team that had reached the crash site. CA-604 was destroyed while on a night bombing sortie from what appears to have been a premature ordnance detonation, its pilot ejected safely. Following the accident the sole remaining aircraft CA-602 was retired in 1997 with Mil Mi-24 helicopter gunships taking over the role of close air support, followed by Mikoyan MiG-27s. Pucarás lack of oxygen system limiting it to low altitudes and lack of counter measure against SAMs proved it be its main limitations.

Upgrades

In May 1982, at the peak of the Falklands War, the Argentine Air Force, in collaboration with the Navy, outfitted a prototype, AX-04, with pylons to mount Mark 13 torpedoes. The aim was its possible production as torpedo-carrying aircraft to enhance the anti-ship capabilities of the Argentine air forces. Several trials were performed off Puerto Madryn, over Golfo Nuevo, but the war ended before the technicians could evaluate the feasibility of the project.

Several attempts were made to upgrade the entire fleet, including the Pucará Charlie conversion, Pucará 2000 and Pucará Bravo (modernization of 40 units was ordered and later cancelled by the FAA, only one unit was converted). These were cancelled during the 1980s due to shortage of funds.

The Uruguayan Air Force updated its fleet with the incorporation of Litton LTN-211 and GPS omega navigation systems. Minor structure modifications were made in order to carry the Mk. 82 Snakeye bomb and 1000-litre drop tank. Other avionics incorporated were the WX-500 Stormscope by L3 Communications and LED Sandel SN3500 backlit display navigation.

In 2007 an IA-58 of the Argentine Air Force was converted to carry a modified engine operating on soy-derived bio-jet fuel. The project, financed and directed by the Argentine Government (''Secretaría de Ciencia Tecnología e Innovación Productiva de la Nación''), made Argentina the second nation in the world to propel an aircraft with biojet fuel. The project intends to make the FAA less reliant on fossil fuels.

Since 2009 an extensive upgrade of the avionics and major overhaul of the airframes has been carried out by the FAA and FAdeA, creating the IA-58D Pucará Delta. The avionics for the cockpit will be as close as possible to the FMA IA-63 Pampa Phase II. Some of the updated components will include a new set of communications hardware, DME, ELT, IFF, GPS, EADI, EHSI, RWR, HUD, DEFA 554 cannon and new powerplant PT6A-62 950shp instead of the original Turbomeca Astazou. The overhaul will keep Argentinian Pucarás active until 2045. Bureaucratic and economic issues are delaying the conversion of the entire fleet. The Uruguayan Air Force also showed interest on the maintenance, repair, and overhaul (MRO) program and installation of new engines offered by FAdeA.

As of April 2016, Fábrica Militar de Aviones is in the process of modernizing twenty of the Argentine Air Force's fleet of Pucaras. The first prototype flew in November 2015.

Failed contracts

The Peruvian Air Force was reported in mid 1972 to have shown great interest in acquiring up to 25 IA-58A for delivery in 1974.

The first foreign contract was in February 1978 with the Islamic Air Force of Mauritania for four IA-58A planes plus support and training at a full cost of U$10.8 million. Another eight units were also negotiated as options. When Mauritanian President Moktar Ould Daddah was ousted in a coup d'état, the contract was cancelled. The plane series n°015 to n°018 were built and ready to ship with Mauritanian registration numbers. Then were incorporated to the Argentine Air Force as A-515 to A-518 keeping the desert camouflage and configuration.IA-58A Pucará, Colección Fabrica Militar de Aviones-Fuerza Aerea Argentina N°3, Cettolo, Mosquera & Nuñez Padín, Jorge Nuñez Padín Editores, 1999

In March 1983, negotiations for two Pucarás were going with Central African Republic Air Force

HOME


Content is Copyleft
Website design, code, and AI is Copyrighted (c) 2014-2017 by Stephen Payne


Consider donating to Wikimedia



As an Amazon Associate I earn from qualifying purchases