USCGC Frank Drew

USCGC ''Frank Drew'' (WLM-557) is a Keeper-class coastal buoy tender of the United States Coast Guard. Launched in 1998, she is home-ported in Portsmouth, Virginia. Her primary mission is maintaining over 300 aids to navigation in lower Chesapeake Bay, the rivers that flow into it, and a potion of the North Carolina Coast. Secondary missions include marine environmental protection, light icebreaking, search and rescue, and security. She is assigned to the Fifth Coast Guard District.

Construction and characteristics

On 22 June 1993 the Coast Guard awarded the contract for the Keeper-class vessels to Marinette Marine Corporation in the form of a firm order for the lead ship and options for thirteen more. The Coast Guard exercised options for the 5th through 10th ships of the class, including ''Frank Drew,'' in February 1997. The ship was launched on 5 December 1998 into the Menominee River. Several of the grandchildren of the ship's namesake, Frank Drew, attended the event. ''Frank Drew'' is the seventh of the fourteen Keeper-class ships built.

Her hull was built of welded steel plates. She is long, with a beam of , and a full-load draft of . ''Frank Drew'' displaces 850 long tons fully loaded. Her gross register tonnage is 904, and her net register tonnage is 271. The top of the mast is above the waterline.

Rather than building the ship from the keel up as a single unit, Marinette Marine used a modular fabrication approach. Eight large modules, or "hull blocks" were built separately and then welded together.

The ship has two Caterpillar 3508 DITA ( direct-injection, turbocharged, aftercooled) 8-cylinder Diesel engines which produce 1000 horsepower each. These drive two Ulstein Z-drives. Keeper-class ships were the first Coast Guard cutters equipped with Z-drives, which markedly improved their maneuverability. The Z-drives have four-bladed propellers which are in diameter and are equipped with Kort nozzles. They can be operated in "tiller mode" where the Z-drives turn in the same direction to steer the ship, or in "Z-conn mode" where the two Z-drives can turn in different directions to achieve specific maneuvering objectives. An implication of the Z-drives is that there is no reverse gear or rudder aboard ''Frank Drew''. In order to back the ship, the Z-drives are turned 180 degrees which drives the ship stern-first even though the propellers are spinning in the same direction as they do when the ship is moving forward. Her maximum speed is 12 knots. Her tanks can hold 16,385 gallons of diesel fuel which gives her an unrefueled range of 2,000 nautical miles at 10 knots.

She has a 500-horsepower bow thruster. The Z-drives and bow thruster can be linked in a Dynamic Positioning System. This gives ''Frank Drew'' the ability to hold position in the water even in heavy currents, winds, and swells. This advanced capability is useful in bringing buoys aboard that can weigh more than 16,000 lbs.

Electrical power aboard is provided by three Caterpillar 3406 DITA generators which produce 285 Kw each. She also has a 210 Kw emergency generator, which is a Caterpillar 3406 DIT.

The buoy deck has of working area. A crane with a boom long lifts buoys and their mooring anchors onto the deck. The crane can lift up to .

The ships' fresh water tanks can hold 7,339 gallons. She has three ballast tanks that can be filled to maintain their trim, and tanks for oily waste water, sewage, gray water, new lubrication oil, and waste oil.

Accommodations were designed for mixed gender crews from the start. Crew size and composition has varied over the years. When she was commissioned, ''Frank Drew'' had a complement of 18, commanded by a chief warrant officer.

''Frank Drew'', as all Keeper-class ships, has a strengthened "ice belt" along the waterline so that she can work on aids to navigation in ice-infested waters. Not only is the hull plating in the ice belt thicker than the rest of the hull, but framing members are closer together in areas that experience greater loads when working in ice. Higher grades of steel were used for hull plating in the ice belt to prevent cracking in cold temperatures. Her bow is sloped so that rather than smashing into ice, she rides up over it to break it with the weight of the ship. ''Frank Drew'' is capable of breaking flat, 9-inch thick ice at 3 knots. Despite her relatively southern basing, the ship has been called upon for ice-breaking services in her area of operations.

The ship carries a cutter boat on davits. She was originally equipped with a CB-M boat which was replaced in the mid-2010s with a CB-ATON-M boat. This was built by Metal Shark Aluminum Boats and was estimated to cost $210,000. The boat is long and are equipped with a Mercury Marine inboard/outboard diesel engine.

The ship's namesake is lighthouse keeper Frank Drew. He had a life-long connection to the Green Island lighthouse in Green Bay, about five miles from the mouth of the Menominee River where the cutter named for him was launched. He was born there when his father, Samuel Drew, was lighthouse keeper. Frank became assistant keeper in 1903 and was promoted to keeper in 1909. He served in this position until his retirement in 1929. He is credited with saving the lives of more than thirty people during his tenure.

''Frank Drew'' replaced USCGC ''Red Cedar'', which was decommissioned in 1997.

Operational history

The Coast Guard took ownership of ''Frank Drew'' on 17 June 1999, and place her "in commission, special" status. She began her trip to Portsmouth on 28 June 1999. The trip took her from Lake Michigan through the Great Lakes and out into the Atlantic. She was placed in full commission at a ceremony at Nauticus in downtown Norfolk, Virginia on 5 April 2000.

''Frank Drew's'' buoy tending involves lifting them onto her deck where marine growth is scraped and pressure washed off, inspecting the buoy itself, and replacing lights, solar cells, and radar transponders. The mooring chain or synthetic cable is inspected and replaced as needed. The concrete block mooring anchor is also inspected. Aside from this routine maintenance, intense storms along the Atlantic coast create additional work for ''Frank Drew''. For instance, Hurricane Florence displaced nearly 200 buoys in North Carolina, and the ship was one of the Coast Guard vessels which reset them in their proper locations. Emergency maintenance is also required when accidents damage or sink buoys. In 2016, for instance, a buoy near the Chesapeake Bay Bridge Tunnel was hit by a vessel under tow and disappeared. The channel was closed to deep-draft shipping until a team, including ''Frank Drew'', could assess the situation. Seasonal exchanges between large summer buoys and simpler buoys with ice-resistant hulls is also required on rivers prone to freezing.

The bulk of ''Frank Drew's'' year is spent at sea tending its buoys, or in port maintaining the ship. She has been asked to perform other missions, as described below.

Search and rescue

''Frank Drew'' was dispatched to the 220-foot barge ''Dick Z'' near Lynnhaven Inlet in October 2010. The barge had taken on water and was almost completely sunk. In May 2018, ''Frank Drew'' was dispatched to search for a man whose boat capsized in the York River near Williamsburg.

Security

In the wake of the September 11, 2001 terrorist attacks, ''Frank Drew'' was dispatched to patrol sensitive areas in the Washington, D.C. area. In 2014 ''Frank Drew'' participated in training firefighters using simulated ship fires at the National Defense Reserve Fleet at Hampton Roads.

Public engagement

The Coast Guard has offered tours aboard ''Frank Drew'' on several occasions. These included stops during the ship's 1999 transit from Marinette to its new homeport in Portsmouth, in Green Bay, Wisconsin, and Charlevoix, Michigan

References

{{DEFAULTSORT:Frank Drew (WLM-557)
Ships built by Marinette Marine
Keeper-class cutters
1998 ships