Timeline Of STS-51-L

The STS-51-L mission started with the ignition of ''Challenger's'' main engines until the remote destruction of the two Solid rocket boosters (SRBs), and includes a transcript of crew conversations from the cockpit voice recorder on board the orbiter. STS-51-L was the twenty-fifth flight in the American Space Shuttle program, and marked the first time a civilian had flown aboard the Space Shuttle. The mission used Space Shuttle ''Challenger'', which lifted off from launch pad 39B (LC-39B) on January 28, 1986, from Kennedy Space Center, Florida. The mission ended in disaster following the destruction of ''Challenger'' 73 seconds after lift-off, because of the failure of an O-ring seals on ''Challenger''s right solid rocket booster, which led to the rapid disintegration of the Space Shuttle stack from overwhelming aerodynamic pressures. The seven-member crew was killed when the crew compartment hit the Atlantic Ocean at , after two and a half minutes of freefall.

Summary timeline

Following several days of lengthy delays, ''Challenger'' finally lifted off at 16:38:00 UTC on January 28, 1986. Her three main engines were ignited at T-6.6 seconds, and at T-0 the solid rocket boosters were ignited, lifting the shuttle stack off launchpad LC-39B at Kennedy Space Center. Almost immediately, cameras recording the launch registered the presence of smoke at the field joint next to the attachment strut on the right-hand SRB, indicating the failure of the O-rings that were supposed to seal the joint against the "blow-by" of hot gases from the boosters. However, sometime at around T+2 seconds, a piece of solid fuel from inside the booster moved inside the joint and provided a temporary seal against the blow-by, allowing the launch to proceed normally for around forty seconds.

However, at around T+36 seconds and an altitude of just over , ''Challenger'' experienced the strongest wind shear ever felt during a Space Shuttle launch. The pitch and yaw commanded by the shuttle's computers in order to counter this wind caused the solid fuel plug to become dislodged from the field joint on the right SRB.

At around T+58 seconds, cameras noted the creation of a plume on the aft attachment strut on the right-hand SRB, as ignited gas began to force itself through a rapidly growing hole in the field joint. Within a second, the plume became well defined and intense. Internal pressure in the right SRB began to drop because of the rapidly enlarging hole in the failed joint, and at T+60 seconds there was visual evidence of flame coming through the joint and impinging on the external tank (ET). As the mission clock passed up through T+64 seconds, the plume suddenly changed shape, showing that it had burned a hole in the liquid hydrogen tank in ''Challenger''s ET, causing the tank to leak. The pressure in the tank began to drop, and ''Challenger''s onboard computers began to pivot the nozzles of the SSMEs to counter the now-unbalanced thrust between the two SRBs.

At this stage, the situation still seemed normal both to the astronauts and to flight controllers. At T+68, the CAPCOM informed the crew – "Challenger, go at throttle up", and Commander Francis R. "Dick" Scobee confirmed the call. His response, "Roger, go at throttle up", was the last communication from ''Challenger'' on the air-to-ground loop.

At around T+72 seconds, the right SRB apparently pulled away from the aft strut attaching it to the external tank. Later analysis of telemetry data showed a sudden lateral acceleration to the right at T+72.525 seconds, which may have been felt by the crew. The last statement captured by the crew cabin recorder came just half a second after this acceleration, when Pilot Michael J. Smith said, "Uh oh". Smith may also have been responding to onboard indications of main engine performance or to falling pressures in the external fuel tank.

At T+73.124 seconds, the aft dome of the liquid hydrogen tank failed, producing a propulsive force that pushed the hydrogen tank into the liquid oxygen tank in the forward part of the external tank. At the same time, the right SRB rotated about the forward attach strut, and struck the intertank structure.

The breakup of the vehicle began at T+73.162 seconds, at an altitude of ). With the external tank disintegrating, ''Challenger'' veered from its correct attitude with respect to the local air flow and was immediately torn apart by aerodynamic forces, resulting in a load factor of up to 20 ''g'' – well over its design limit. The two SRBs, which could withstand greater aerodynamic loads, separated from the ET and continued in uncontrolled powered flight for another 37 seconds. The SRB casings were made of thick steel and were much stronger than the orbiter and ET; thus, both SRBs survived the breakup of the Space Shuttle stack, even though the right SRB was still suffering the effects of the joint burn-through that had set the destruction of ''Challenger'' in motion. The boosters were destroyed by the range safety system at around 110 seconds after launch.

Detailed timeline and transcript

The following timeline provides a detailed list of the major events of the launch of STS-51-L, culminating in the destruction of ''Challenger''. The list also contains a transcript from the shuttle's Cockpit Voice Recorder (CVR), from ignition of the main engines to T+73 seconds. Acronyms used in the timeline are as follows:

* APU – Auxiliary Power Unit
* CAPCOM – Capsule Communicator (Richard O. Covey)
* CDR – Commander ( Francis R. "Dick" Scobee)
* CVR – Cockpit Voice Recorder
* DPS - Data Processing Systems
* ET – External Tank
* FIDO – Flight Dynamics Officer
* GLS – Ground Launch Sequencer
* GPC – General Purpose Computer
* HPFT – High-Pressure Fuel Turbopump
* LH2 – Liquid Hydrogen
* LO2 – Liquid Oxygen (same as LOX)
* LVLH – Local Vertical Local Horizontal
* MCC – Mission Control Center
* MEC – Main Engine Controller
* MPS - Main Propulsion System
* MS1/MS2 – Mission Specialist ( Ellison S. Onizuka/Judith A. Resnik)
* PAO – Public Affairs Officer
* PIC – Pyrotechnics Initiator Controller
* PLT – Pilot (Michael J. Smith)
* psf – pounds per square foot
* psi – pounds per square inch
* RCS – Reaction Control System
* SRB – Solid Rocket Booster
* SSME - Space Shuttle Main Engine
* TVC - Thrust Vector Control

References

External links

NASA Transcript

* Spaceflight Now
The ''Challenger'' disaster timeline

{{Space Shuttle Challenger

Challenger
Space Shuttle Challenger disaster