Solar Impulse 2

Solar Impulse is a Swiss long-range experimental solar-powered aircraft project, and also the name of the project's two operational aircraft. The privately financed project is led by Swiss engineer and businessman André Borschberg and Swiss psychiatrist and balloonist Bertrand Piccard, who co-piloted ''Breitling Orbiter 3'', the first balloon to circle the world non-stop. The Solar Impulse project's goals were to make the first circumnavigation of the Earth by a piloted fixed-wing aircraft using only solar power and to bring attention to clean technologies.

The aircraft is a single-seated monoplane powered by photovoltaic cells; it is capable of taking off under its own power. The prototype, often referred to as ''Solar Impulse 1'', was designed to remain airborne up to 36 hours. It conducted its first test flight in December 2009. In July 2010, it flew an entire diurnal solar cycle, including nearly nine hours of night flying, in a 26-hour flight. Piccard and Borschberg completed successful solar-powered flights from Switzerland to Spain and then Morocco in 2012, and conducted a multi-stage flight across the US in 2013.

A second aircraft, completed in 2014 and named ''Solar Impulse 2'', carries more solar cells and more powerful motors, among other improvements. On 9 March 2015, Piccard and Borschberg began to circumnavigate the globe with ''Solar Impulse 2'', departing from Abu Dhabi in the United Arab Emirates. The aircraft was scheduled to return to Abu Dhabi in August 2015 after a multi-stage journey around the world. By June 2015, the plane had traversed Asia, and in July 2015, it completed the longest leg of its journey, from Japan to Hawaii. During that leg, the aircraft's batteries sustained thermal damage and took months to replace. A battery cooling system was installed and ''Solar Impulse 2'' resumed the circumnavigation in April 2016, when it flew on to California.Berger, Noah
"Solar-powered plane completes journey across Pacific Ocean"
, ''The Charlotte Observer'', 24 April 2016 It continued across the US until it reached New York City in June 2016. Later that month, the aircraft crossed the Atlantic Ocean to the city of Seville.Amos, Jonathan
"Solar Impulse completes Atlantic crossing with landing in Seville"
BBC, 23 June 2016 It stopped in EgyptAmos, Jonathan
"Solar Impulse: Zero-fuel plane lands in Cairo"
BBC News, 13 July 2016 before returning to Abu Dhabi on 26 July 2016, more than 16 months after it had left, completing the approximately 42,000-kilometre (26,000-mile) first circumnavigation of the Earth by a piloted fixed-wing aircraft using only solar power."Solar Impulse completes historic round-the-world trip"
BBC News, 26 July 2016

In 2019 the Solar Impulse 2 aircraft was sold to Skydweller, a Spanish-American company that is developing autonomous unmanned aerial vehicles capable of continuous flight. It plans to use the plane for research and development flights, after which the Solar Impulse 2 is planned to be on permanent display at the Swiss Museum of Transport.

Project development and funding

Bertrand Piccard initiated the Solar Impulse project in November 2003 after undertaking a feasibility study in partnership with the École Polytechnique Fédérale de Lausanne (EPFL). As a mechanical engineer, co-founder André Borschberg directed the construction of each aircraft and oversees the preparation of the flight missions. By 2009, they had assembled a multi-disciplinary team of 50 engineers and technical specialists from six countries, assisted by about 100 outside advisers and 80 technological partners.

The project is financed by a number of private companies and individuals, as well as receiving around CHF 6 million ( US$6.4 million) in funding from the Swiss government. The project's private financial backers include Omega SA, Solvay, Schindler, ABB and Peter Diamandis. The EPFL, the European Space Agency and Dassault have provided technical expertise, while SunPower provided the aircraft's photovoltaic cells.

Piccard stated that the entire project from its beginnings in 2003 until mid-2015 had cost €150 million. It raised another €20 million in late 2015 to continue the round-the-world flight.Al Wasmi, Naser
"Exclusive: Solar Impulse headed back to Abu Dhabi the long way round"
''The National'', 8 January 2016

Timeline

* 2002: Feasibility study at the École Polytechnique Fédérale de Lausanne
* 2004–2005: Development of the concept
* 2006: Simulation of long-haul flights
* 2006–09: Construction of first prototype (HB-SIA; ''Solar Impulse 1'')
* 2009: First flight of ''Solar Impulse 1''
* 2009–11: Manned test flights
* 2011–12: Further test flights through Europe and North Africa
* 2011–13: Construction of second prototype (HB-SIB; ''Solar Impulse 2'')
* 2013: Continental flight across the US by ''Solar Impulse 1''
* 2014: First flight of ''Solar Impulse 2''
* 2015–2016: Circumnavigation of the Earth by ''Solar Impulse 2'', conducted in seventeen stages over 16-1/2 months

''Solar Impulse 1'' (HB-SIA)

The first Solar Impulse aircraft, registered as HB-SIA, was primarily designed as a demonstration aircraft. It has a non-pressurized cockpit and a single wing with a wingspan similar to that of the Airbus A340 airliner. Under the wing are four nacelles, each with a set of lithium polymer batteries, a electric motor and one twin-bladed propeller. To keep the wing as light as possible, a customised carbon fibre honeycomb sandwich structure was used. 11,628 photovoltaic cells on the upper wing surface and the horizontal stabilizer generate electricity during the day to power the electric motors and to charge the batteries allowing flight at night, theoretically enabling the single-seat plane to stay in the air indefinitely.

The aircraft's major design constraint is the capacity of the lithium polymer batteries. Over an optimum 24-hour cycle, the motors can deliver a combined average of about , roughly the power used by the Wright brothers' Flyer, the first successful powered aircraft, in 1903. In addition to the charge stored in its batteries, the aircraft uses the potential energy of height gained during the day to power its night flights.

Specifications

Operational history

Maiden flight and other early flights

On 26 June 2009, ''Solar Impulse 1'' was first presented to the public at the Dübendorf Air Base, Switzerland. Following taxi testing, a short-hop test flight was made on 3 December 2009, piloted by Markus Scherdel. Borschberg, co-leader of the project team, said of the flight:

On 7 April 2010, the plane conducted an 87-minute test flight, piloted by Markus Scherdel. This flight reached an altitude of . On 28 May 2010, the aircraft made its first flight powered entirely by solar energy, charging its batteries in flight.

First overnight flight

On 8 July 2010, ''Solar Impulse 1'' achieved the world's first manned 26-hour solar-powered flight. The airplane was flown by Borschberg, and took off at 06:51 Central European Summer Time (UTC+2) on 7 July from Payerne Air Base, Switzerland. It returned for a landing the following morning at 09:00 local time. During the flight, the plane reached a maximum altitude of . At the time, the flight was the longest and highest ever flown by a manned solar-powered aircraft; these records were officially recognized by the Fédération Aéronautique Internationale (FAI) in October 2010.

International and intranational flights

=Belgium and France (2011)

=

On 13 May 2011 at 21:30 local time, the plane landed at Brussels Airport, after completing a 13-hour flight from its home base in Switzerland. It was the first international flight by the Solar Impulse, which flew at an average altitude of for a distance of , with an average speed of . The aircraft's slow cruising speed required operating at a mid-altitude, allowing much faster air traffic to be routed around it. The aircraft was piloted by Borschberg. The project's other co-founder, Piccard, said in an interview after the landing: "Our goal is to create a revolution in the minds of people...to promote solar energies – not necessarily a revolution in aviation."

A second international flight to the Paris Air Show was attempted on 12 June 2011, but the plane turned back and returned to Brussels because of adverse weather conditions. In a second attempt on 14 June, Borschberg successfully landed the aircraft at Paris' Le Bourget Airport after a 16-hour flight.

=First intercontinental flight (2012)

=
On 5 June 2012, the Solar Impulse successfully completed its first intercontinental flight, a 19-hour trip from Madrid, Spain, to Rabat, Morocco. During the first leg of the flight from Payerne Air Base to Madrid, the aircraft broke several further records for solar flight, including the longest solar-powered flight between pre-declared waypoints () and along a course ().

=United States (2013)

=

On 3 May 2013, the plane began its cross-US flight with a journey from Moffett Field in Mountain View, California, to Phoenix Goodyear Airport in Arizona. Successive legs of the flight ended at Dallas-Fort Worth airport, Lambert–St. Louis International Airport, Cincinnati Municipal Lunken Airport to change pilots and avoid strong winds, and Washington Dulles International Airport. On 6 July 2013, following a lengthy layover in Washington, Solar Impulse completed its cross-country journey, landing at New York City's JFK International Airport at 23:09 EDT. The landing occurred three hours earlier than originally intended, because a planned flyby of the Statue of Liberty was cancelled as a result of damage to the covering on the left wing.

Each flight leg took between 14 and 22 hours. The aircraft's second leg of its trip on 23 May to Dallas-Fort Worth covered and set several new world distance records in solar aviation. ''Solar Impulse 1'' was placed on public display at JFK after its landing. In August 2013, it was disassembled, then transported via a Cargolux B-747-400F to Dübendorf Air Base, where it was placed in storage in a hangar.

;Detailed route
''Source:''

Aircraft on display

In March 2015, the plane was transported by truck to Paris to be part of the permanent exhibition at Cité des Sciences et de l'Industrie.

''Solar Impulse 2'' (HB-SIB)

Construction history

Construction started in 2011 on the second aircraft, known as ''Solar Impulse 2'', which carries the Swiss registration HB-SIB. Completion was initially planned for 2013, with a 25-day circumnavigation of the globe planned for 2014. A structural failure occurred on the aircraft's main spar during static tests in July 2012, leading to delays in the flight testing schedule to allow repairs. ''Solar Impulse 2s first flight took place at Payerne Air Base on 2 June 2014.

Design

The wingspan of ''Solar Impulse 2'' is , slightly less than that of an Airbus A380, the world's largest passenger airliner, but compared with the 500-ton A380, the carbon-fibre Solar Impulse weighs only about , little more than an average SUV. It features a non-pressurized cockpit in sizeReisinger, Don
"Solar-powered plane embarks on longest leg of round-the-world flight"
CNET, 29 June 2015 and advanced avionics, including limited functionality of an autopilot that allows the pilot to sleep for up to 20 minutes at a time, enabling multi-day transcontinental and trans-oceanic flights. Supplemental oxygen and various other environmental support systems allow the pilot to cruise up to an altitude of .

Specifications

Operational history

''Solar Impulse 2'' was first publicly displayed on 9 April 2014. Its inaugural flight took place on 2 June 2014, piloted by Markus Scherdel. The aircraft averaged a ground speed of , and reached an altitude of . The first night flight was completed on 26 October 2014, and the aircraft reached its maximum altitude during a flight on 28 October 2014.

2015–16 circumnavigation of the Earth

The repair work to the aircraft's main spar delayed ''Solar Impulse 2s circumnavigation of the Earth from 2012 to 2015.Timeline: "Without a spar, what's next?"
, Solar Impulse, 19 July 2012. Retrieved 28 June 2013 The aircraft was delivered to Masdar City in Abu Dhabi for the World Future Energy Summit in late January 2015, and it began the journey from Al Bateen Executive Airport on 9 March 2015. It was scheduled to return to the same location in August 2015. A mission control centre for the circumnavigation was established in Monaco, using satellite links to gather real-time flight telemetry and remain in constant contact with the aircraft and the support team.
The route followed by ''Solar Impulse 2'' was entirely in the Northern Hemisphere. It left Abu Dhabi, then it headed east to nearby Oman and India. Twelve stops were originally planned along the route, with pilots Borschberg and Piccard alternating; at each stop, the crew awaited good weather conditions along the next leg of the route. For most of its time airborne, ''Solar Impulse 2'' cruised at a ground speed of between , usually at the slower end of that range at night to save power. Legs of the flight crossing the Pacific and Atlantic oceans were the longest stages of the circumnavigation, taking up to five days and nights. On multi-day flights, the pilots took 20-minute naps and used yoga or other exercises to promote blood flow and maintain alertness.

By the end of May 2015, the plane had traversed Asia. It made an unscheduled stop in Japan to await favourable weather over the Pacific, increasing the expected number of legs of the journey to 13. The aircraft began the flight from Japan to Hawaii on 28 June 2015 (29 June, Japan local time). Morelle, Rebecca
"Solar Impulse begins second bid to cross Pacific Ocean"
BBC News, 28 June 2015 With Borschberg in the cockpit, it reached Hawaii on 3 July, setting new records for the world's longest solar-powered flight both by time (117 hours, 52 minutes) and distance (7,212 km; 4,481 mi). The flight's duration was also a record for longest solo flight, by time, for any aircraft.Archangel, Amber.The Fédération Aéronautique Internationale (FAI) website states that the "Free distance along course" was 7,039.9 km
FAI Record ID #17595
, Fédération Aéronautique Internationale. Retrieved 29 July 2015 During that leg the plane's batteries were damaged by overheating because they were packed in too much insulation. New parts had to be ordered, and as it was late in the season, with days shortening in the northern hemisphere, the plane was grounded in Hawaii. The US Department of Transportation stored the aircraft in a hangar at Kalaeloa Airport on Oahu.Amos, Jonathan
"Solar Impulse grounded until 2016"
BBC, 15 July 2015Molko, Davis
"Solar Impulse: Plane's pilots ground record-setting attempt until 2016"
CNN, 15 July 2015
New batteries were made and installed in the plane. Test flights began in February 2016 to prepare for resumption of the circumnavigation once northern hemisphere days lengthened enough to permit multi-day solar-powered flights.Al Wasmi, Naser
"After months-long hiatus, Solar Impulse 2 gets set to fly again"
''The National'', 11 March 2016 A favourable weather window opened in April 2016, and the plane resumed its journey, landing at Moffett Field, in California, on 23 April. During that flight, Piccard, via a live videolink, spoke with Ban Ki-Moon and Doris Leuthard before the General Assembly of the United Nations, from the cockpit of ''Solar Impulse 2'', commenting on that day's historic signing of the Paris Agreement and discussing how using clean technologies can create jobs and fight global warming. Additional legs of the flight were added in the US as ''Solar Impulse 2'' flew to Phoenix, Arizona, Tulsa, Oklahoma, Dayton, Ohio,"Solar Impulse 2 Lands in Ohio to Complete Latest Leg of Global Trip"
NBC, 21 May 2016 Lehigh Valley, Pennsylvania"Solar Impulse 2 Lands in Pennsylvania in Latest Leg of Global Journey"
NBC, 25 May 2016 and New York City, arriving there on 11 June 2016.Rice, Doyle
"Solar Impulse 2 lands in New York City, final U.S. destination"
''USA Today'', 11 June 2016
Piccard piloted the aircraft across the Atlantic Ocean, arriving in Seville, Spain, on 23 June. The aircraft next stopped in Cairo, Egypt, on 13 July, and landed in Abu Dhabi on 26 July, completing the around-the-world trip in a total of 17 stages and 16-1/2 months; it was the first circumnavigation of the Earth by a piloted fixed-wing aircraft using only solar power.

Detailed route

:Notes:
* — Leg 7 was planned as a 144-hour flight from Nanjing, China to Hawaii (). Deteriorating weather forced a diversion to Nagoya, Japan.

Post-flight sale

In September 2019 the Solar Impulse 2 aircraft was sold to Skydweller, a Spanish-American company that is developing autonomous unmanned aerial vehicles capable of continuous flight and “carrying radar, electronic optics, telecommunications devices, telephone listening and interception systems”. As part of this sale, the Solar Impulse 2 aircraft was transferred from Switzerland to Spain though once Skydweller completes its research and development flights the Solar Impulse 2 will be transferred back to Switzerland for permanent display at the Swiss Museum of Transport.

Honours

In 2016, the Swiss Post edited a special stamp to honour the achievement of ''Solar Impulse 2''.

World Alliance for Clean Technologies

During the final flight of their circumnavigation of the globe, Borschberg and Piccard announced the creation of a World Alliance for Clean Technologies (later renamed World Alliance for Efficient Solutions). The aim of this non-governmental organisation is to promote green energy and sustainable technologies"International Committee for Clean Technologies launched from a solar airplane while flying over the Atlantic Ocean"
press release of Solar Impulse, 26 July 2016 (page visited on 7 August 2016). Olivier Dessibourg, "Vers un comité mondial pour les énergies « vertes »", ''Le temps'', Wednesday 27 July 2016, page 13. Box part of the large article of Fabien Goubet entitled "Un tour du monde, zéro carburant : Solar Impulse réécrit l'histoire de l'aviation", ''Le temps'', Wednesday 27 July 2016, pp. 12–13 by bringing together for-profit companies creating green solutions.

World Alliance was launched in November 2017.Wei-Haas, Maya
"Inside the First Solar-Powered Flight Around the World"
'' Smithsonian'' magazine, 31 January 2018 Patrons of the initiative included Albert II, Prince of Monaco and actor Arnold Schwarzenegger. Piccard said that he and his organization, Solar Impulse Foundation, formed the World Alliance to help draw investors' and businesses' attention to new cleantech startups. Piccard does not receive a salary for his leadership of the alliance, which is funded by donors including Air Liquide, Nestle and Solvay.

In November 2017 at COP23, Piccard tasked the World Alliance with a project to identify 1,000 technological solutions that are both profitable and good for the planet, with the goal to bring environmentalists and industrialists together. He noted in a 2018 ''Smithsonian'' article that technologies developed for the solar-powered flight were already being repurposed in new ways, including new ceiling fans based on the solar airplane engines and refrigerators using the cockpit insulation.

When speaking to government leaders, Piccard said he was consistently told that they wanted to protect the environment but it was too expensive. To provide reassurance, in May 2018 Piccard and the Solar Impulse Foundation announced the Efficient Solutions Label, a certification involving a rigorous Ernst and Young-certified evaluation by independent experts to assess each solution's quality and ability to turn a profit. According to Piccard, any Solar Impulse labeled solution must be the best in its class: the most environmentally friendly as well as economically viable and available for purchase today.

In 2021 in a ''Reuters'' interview Piccard stated that his organization had assembled a portfolio of 910 vetted and labeled solutions and expected to reach 1000 by mid-April 2021. Piccard told ''Reuters'' he plans to discuss the solutions with businesses and governments, especially those in the process of funding the global economic recovery from COVID-19.

See also

Notes and references

External links

Official website


Official YouTube channel

{{Portal bar, Aviation, Renewable energy, Energy, Switzerland

Aircraft manufactured in Switzerland
Solar-powered aircraft
Swiss experimental aircraft
Vehicles introduced in 2009
2009 in science
2013 in science
2013 in California
Solar power in Switzerland
Four-engined tractor aircraft
Electric aircraft
Circumnavigation