SpaceShipOne Flight 15P

Flight 15P of SpaceShipOne (X0) was the first privately funded human spaceflight. It took place on June 21, 2004. It was the fourth powered test flight of the Tier One program, the previous three test flights having reached much lower altitudes. The flight carried only its pilot, Mike Melvill, who thus became the first non-governmental astronaut.

This flight was a full-altitude test, but not itself a competitive flight for the Ansari X Prize, the prize for the first non-governmental reusable crewed spacecraft. Problems were encountered during the flight, but later corrected, paving the way for SpaceShipOne to make competitive flights later in 2004.

Crew

Flight profile

All times are in PDT, which is seven hours behind UTC. This was the local civil time at the spaceport on the day of the flight. All measurements are first stated in the U.S. customary units in which they were originally reported, with conversions to SI units also given.

Taxiing for takeoff from Mojave Spaceport was originally planned for 06:30, because the wind conditions in that area are most favorable in the early morning. Taxiing actually started at 06:37, and the flight took off at 06:47. After an ascent to 47,000 feet (14.3 km) coupled with the White Knight airplane, the SpaceShipOne craft separated at 07:50 and immediately ignited its rocket.

Shortly after ignition, at about 60,000 feet (18 km), the craft unexpectedly rolled 90 degrees to the left, due to wind shear. When the pilot attempted to correct it, it rolled 90 degrees to the right. The pilot levelled the craft out, and proceeded with the climb. The correction of the roll excursion, using full trim, caused a pitch trim tab to run up against a stop. This caused the trim actuator, as designed, to stop operating for a 3 s timeout. Not realising what had happened, the pilot and controllers interpreted this as failure of the trim actuator, and they switched to a backup system. Spacecraft attitude was problematic during the entire climb, and not corrected until the start of re-entry.

During the burn, a new aerodynamic fairing installed around the rocket nozzle overheated, became too soft, and crumpled inwards. This caused a loud bang, which the pilot reported, but did not cause a flight problem.

The rocket burn lasted for 76 seconds. At burn-out the altitude was 180,000 feet (54.9 km), the Mach number was 2.9, and the speed was 2150 mph (3460 km/h; 961 m/s).

The planned apogee altitude was 360,000 feet (110 km), but due to the attitude problem encountered during the climb the craft actually attained only 328,491 feet (100,124 m). In doing so it passed the boundary to space at 100 km, making the flight, as planned, officially a spaceflight. It can be calculated that the altitude exceeded 100 km for approximately 10.23 s.

Around apogee the craft experienced about 3 minutes of weightlessness. Pilot Mike Melvill opened a bag of M&M's and watched them float around the capsule in free fall.

The craft re-entered the atmosphere 22 miles (35 km) south of its planned 5 by 5 mile (8 by 8 km) re-entry zone. The pilot finally corrected the spacecraft attitude at this point, using a backup trim system. The craft reached Mach 2.9 and experienced deceleration of 5.0 ''g'' (49 m/s²) during descent. The craft switched to gliding configuration at an altitude of 57,000 feet (17.4 km), then returned to the spaceport and landed safely at 08:14.

Spectacle

Scaled Composites, the makers of SpaceShipOne, announced the planned spaceflight on June 2, 2004, and invited the public to watch. An estimated 11,000 people went to Mojave Spaceport to watch the flight, and millions more watched on television. Distinguished attendees included former astronaut Buzz Aldrin and the Commanding Officer of Edwards Air Force Base.

Because SpaceShipOne launches to the east of Mojave Spaceport early in the morning, the crowd at the spaceport found themselves looking into the sun when watching the aircraft. Nevertheless, the crowd was exuberant, cheering every milestone in the flight, including the double sonic boom following the thrust phase. After SpaceShipOne landed, White Knight and the chase planes made celebratory passes over the runway. Mike Melvill displayed great excitement, waving to the crowd while standing on top of SpaceShipOne. He also held up a sign reading "SpaceShipOne, GovernmentZero," given to him by a spectator - an apparent reference to the then-ongoing suspension of Space Shuttle flight operations following the loss of the Space Shuttle Columbia during STS-107. Melvill was greeted by Buzz Aldrin, the second person to have walked on the Moon.

Reactions

NASA administrator Sean O'Keefe issued a statement about the flight, saying:

The X Prize Foundation issued a press release about the flight:

The Federal Aviation Administration presented Melvill with astronaut wings in a ceremony at 10:22, two hours after landing.

Relation to the Ansari X Prize

As intended, the flight exceeded the 100 km threshold required for the X PRIZE. However, the flight was not intended as an X PRIZE competitive flight, and was not registered as such.

The flight did not carry any passengers, or equivalent ballast, as required for an X PRIZE flight, and so could not qualify as a competitive flight. Furthermore, the X PRIZE rules require a repeat flight within two weeks, which the Scaled Composites team had no intention of making.

Flight 15P was intended to be the final test flight before making the two X PRIZE flights later in 2004. Due to the problems encountered on this flight it was thought that an additional test flight might be needed. However, by July 7, 2004 Burt Rutan reported that the faults had been resolved and the next flights would be competitive.

See also

* Timeline of private spaceflight
* SpaceShipTwo
* Virgin Galactic

References

External links

Scaled Composites FAQ on June 21 launch







'' 'Anomalies' in first private spaceflight revealed'', New Scientist




- press release from the X PRIZE Foundation

SpaceShipOne Makes History: First Private Manned Mission to Space
- press release from Scaled Composites

More X-Prize News
from Starfighter's Model Blog

Space Ship One's First Flight into Space
- images of the flight, from Fred's Air Show Journal

{{Scaled Composites

SpaceShipOne
2004 in spaceflight
Scaled Composites Tier One program
Suborbital human spaceflights