Redruth and Chasewater Railway
   HOME

TheInfoList



OR:

The Redruth and Chasewater Railway, (otherwise called the ''Redruth and Chacewater Railway'' using modern spelling), was an early mineral railway line in
Cornwall Cornwall (; kw, Kernow ) is a historic county and ceremonial county in South West England. It is recognised as one of the Celtic nations, and is the homeland of the Cornish people. Cornwall is bordered to the north and west by the Atlantic ...
, England, UK. It opened in 1825 and was built to convey the output from copper mines in the
Gwennap Gwennap ( kw, Lannwenep (village), Pluw Wenep (parish)) is a village and civil parishes in England, civil parish in Cornwall, England. It is about five miles (8 km) southeast of Redruth. Hamlets of Burncoose, Comford, Coombe, Gwennap, Coomb ...
area to wharves on
Restronguet Creek Restronguet Creek is a tidal ria in south Cornwall, United Kingdom. It is a tributary of Carrick Roads, the estuary of the River Fal, and is situated approximately four miles (6.5 km) south of Truro and three miles (5 km) north o ...
(off the Fal Estuary) around
Devoran Devoran ( kw, Deveryon) is a village in south Cornwall, England, United Kingdom. It is southwest of Truro at .Ordnance Survey: Landranger map sheet 204 ''Truro & Falmouth'' Formerly an ecclesiastical parish, Devoran is now in the civil par ...
, and to bring in coal to fuel mine engines; later it carried timber for pit props and also house coal. A little over long, it was built to a
narrow gauge A narrow-gauge railway (narrow-gauge railroad in the US) is a railway with a track gauge narrower than standard . Most narrow-gauge railways are between and . Since narrow-gauge railways are usually built with tighter curves, smaller structu ...
and used horse traction at first, later using steam locomotives. Solely dependent on the economy of the mines it served, it prospered when they did, and when they declined, the railway declined too; it finally closed in 1915. It never carried passengers. Much of its route can still be traced, and part of it forms the course of the Redruth and Chasewater Railway Trail, an outdoor leisure facility.


History


Antecedents

Prior to the nineteenth century, much mineral extraction had taken place in the Cornish peninsula, but this had been limited by the non-existence of industrial methods; thus the depth to which shafts could be sunk, and at which water inundation overwhelmed the workings, and the cost of transporting extracted minerals to market, all proved limiting factors, and many mines were abandoned as exhausted using available methods. (Transport of minerals was chiefly done on the backs of mules.) As the industrial revolution gathered pace, steam engine power became available to overcome these limitations, and new seams were developed at greater depths, and in some cases abandoned mines were re-opened. Moreover copper began to supersede tin as the dominant mineral for exploitation. Because the process of smelting copper required large quantities of coal – in the proportion of 18 to 1 – the copper ore was transported by sea to South Wales, where
Swansea Swansea (; cy, Abertawe ) is a coastal city and the second-largest city of Wales. It forms a principal area, officially known as the City and County of Swansea ( cy, links=no, Dinas a Sir Abertawe). The city is the twenty-fifth largest in ...
was dominant. The focus, then, was on transporting copper and tin ore to a sea port for onward movement, and to bring in coal to fuel the increasing number of steam engines operating at the mines. In 1809 a privately owned tramway was constructed to connect the harbour at
Portreath Portreath ( kw, Porthtreth or ) is a civil parish, village and fishing port on the north coast of Cornwall, England, United Kingdom. The village is about three miles (5 km) northwest of Redruth. The village extends along both sides of a st ...
on the north coast, with mines around St Day and Scorrier; at first called the
Portreath Tramway The Portreath Tramroad, or alternatively the Portreath Tramway was opened in 1815, providing a wagonway route from mines near Scorrier in Cornwall, England, to a port at Portreath. From there, it could be transported to market by coastal shipp ...
, with later extensions it became known as the Poldice Tramway. It was a horse-worked
plateway A plateway is an early kind of railway, tramway or wagonway, where the rails are made from cast iron. They were mainly used for about 50 years up to 1830, though some continued later. Plateways consisted of "L"-shaped rails, where the flange ...
and it was an immediate success financially. However it was in private ownership, as was the harbour at Portreath, and was not made available to the proprietors of competing mines.''The Redruth and Chasewater Railway, 1824 - 1915'', D B Barton, D Bradford Barton Ltd, Truro, 2nd edition, 1966


Consolidated Mines

In 1819, the dynamic entrepreneur John Taylor took a lease on the dormant
Consolidated Mines Consolidated Mines, also known as Great Consolidated mine, but most commonly called Consols or Great Consols was a metalliferous mine about a mile ESE of the village of St Day, Cornwall, England. Mainly active during the first half of the 19th ...
(usually referred to as ''Consols''). These were a group of five mines that had been abandoned in 1811 and flooded, and Taylor installed two 90-inch pumping engines – then the largest of their kind in the world – and within a year opened a long copper lode, itself the largest in the world. Consols had become the prime copper mine in Cornwall, and remained so until 1840, gaining its shareholders huge capital gains. The issue of transporting the extracted minerals to market had always been prominent, and canal and other schemes had been proposed but never implemented, and Taylor now promoted a railway to transport his mine's output to Point on Restronguet Creek. He obtained financial backing in London without any support from Cornish interests.


The Railway gets its Act

Notwithstanding obstruction from the Portreath interests, Taylor got his Act of Parliament on 17 June 1824, with a capital of £22,500, and authority to increase this by another £10,000 if necessary.Joseph Priestley, A Historical Account of the Navigable Rivers, Canals, and Railways, of Great Britain, Longman, Rees Orme, Brown and Green, London, 1831 The railway was to be a toll operation, allowing any carrier to convey his vehicles on the line on payment of the toll, and the terms of the Act did not envisage actual train operation by the Company itself. The Act specified the main line to be from Redruth (15 14 02 N, 5 13 21 W) to Point (50 12 29 N, 5 04 06 W), with several branches, including one from Twelveheads to Chacewater. There were also to be improvements to the harbour at Narabo (near Devoran). (citing Plymouth Institute (1887–90), 90, etc.) The route went via
Carharrack Carharrack ( kw, Karardhek) is a civil parish and village in west Cornwall, England, United Kingdom. It is situated two miles (3 km) east of Redruth in a former mining area. The parish is of a rural/residential character, albeit with an ...
and down the Carnon Valley, via Bissoe.


Construction and opening

Actual construction of the railway proceeded swiftly, being conducted by William Brunton, son of the Scottish inventor of the same name. Considerable earthworks were necessary in places – crossing the Carnon Valley in particular – in order to avoid excessive gradients, and there was a 600 feet vertical interval between the summit of the line and the wharves at Devoran. In fact there was a gradient of 1 in 35 falling from Lanner to Carharrack. The track gauge was this was commonly employed in South Wales, with which the engineering of the mines had close contact at that time, and edge rails were used: a considerable technical advance, and the first such use in Cornwall. (The Poldice and other tramways had used plateways, in which the plates are flanged and the wagon wheels are plain; in an edge rail system, the flanges are on the wheels of the vehicles.) The rails were
wrought iron Wrought iron is an iron alloy with a very low carbon content (less than 0.08%) in contrast to that of cast iron (2.1% to 4%). It is a semi-fused mass of iron with fibrous slag Inclusion (mineral), inclusions (up to 2% by weight), which give it a ...
, carried in
cast iron Cast iron is a class of iron–carbon alloys with a carbon content more than 2%. Its usefulness derives from its relatively low melting temperature. The alloy constituents affect its color when fractured: white cast iron has carbide impuriti ...
chairs supported on granite blocks. As parts of the line were completed, hauliers were allowed to use them forthwith, and this took place from 1824; it was not until 30 January 1826 that the line was considered substantially complete (although the Chacewater branch had not been started, and in fact was never built) and an official opening took place, when some of the proprietors travelled from Wheal Buller to Devoran (by gravity) and then back to Redruth (pulled by a horse). In 1827 extensions were constructed and opened; from Wheal Buller junction to Redruth itself, serving the Pen-an-Drea mine and the town itself, and an additional from Devoran to Point Quay.


Operation: first years

Built as a horse-operated tramway, the early operations followed that model, with short groups of wagons hauled by horses. Although the line had been designed with a view to gravitational operation for loaded traffic towards Devoran, it appears that this was not done, and the wagons were hauled in both directions. The line was single throughout, with numerous passing places. In the event of two "trains" meeting between passing places, the advantage was to be decided by lot. Tonnages carried exceeded expectations, at over 58,000 tons annually and the company was financially very successful, with annual profits of over £2,000. Additional passing places were installed in 1831 and the wharves at Devoran were much extended. Renewal of rails became necessary in 1831 – this on a railway with no locomotive traction – and considerable difficulty was experienced with displacement of the stone blocks, causing gauge widening problems. Inwards traffic of coal steadily increased as the mines mechanised: by 1835 Consols and United mines had sixteen engines working, consuming 15,000 tons of coal annually.


First challenges

In 1839, the
West Cornwall Railway The West Cornwall Railway was a railway company in Cornwall, Great Britain, formed in 1846 to construct a railway between Penzance and Truro. It purchased the existing Hayle Railway, and improved its main line, and built new sections between Penz ...
opened its lines, to Tresavean, near the mines served by the Redruth company, and to Portreath, giving improved access to that port, which gave easier access to Welsh ports as it lay on the north coast of Cornwall. In the same year, Taylor's lease of the Consols mines came to an end; in the final months he extracted as much material as possible without the development work normally used to maintain future extraction, and when the new lessees took over, they found it impossible to maintain the volume of extraction that Taylor had achieved. This directly affected the railway's carryings and its profitability. In 1840 profits fell by 20%, though with increased tonnages carried, reflecting the downward pressure of rates. In the following year, a severe winter led to great difficulties with displacement of the stone blocks, and with embankment subsidence, costing considerable expenditure on repairs. In 1848 Thomas Hall was appointed engineer and superintendent of the railway for the next 20 years.


Locomotive operation

By the early 1850s, trade in general was more buoyant, and the company decided to apply for parliamentary authority to build a branch line to Wheal Busy (a little over long). The junction was to be near Hale Mills, and the Act was obtained on 9 May 1853. (This line was never completed.) The Act also permitted the use of locomotives. This necessitated the relaying of much of the track, and this was done with 50 lb per yard bullhead rails, re-using the original stone blocks. Two locomotives were acquired from Neilson & Co; they were named ''Miner'' and ''Smelter''; they were 0-4-0 saddle tanks and they were delivered in November 1854. New larger capacity wagons were also acquired with a payload of over 4 tons. The new locomotives and wagons cost £5,565. Although crude in appearance, the locomotives were successful operationally, being able to take 8 loaded wagons (50 tons gross) up to Wheal Fortune loop. However locomotive operation caused considerable friction with the existing horse hauliers, who operated the upper part of the line; in addition the weight of the locomotives caused subsidence problems in the weaker parts of the track. In 1855 the Company made a loss, of £548. This was taken hard, although it was brought about by the considerable expenditure on one-off items (charged to current account) — the locomotives and rolling stock, the work on the Wheal Busy extension, and major repairs to the company's steam tug, kept at Devoran. The locomotives were now regularly working up to Tingtang (west of the Consols); traffic was increasing markedly on the Wheal Buller branch (and declining on the Redruth main line) and the decision was taken to operate the locomotives to Wheal Buller, involving relaying the track, as soon as the traffic justified it. In fact this was done by 1857, and they took over operation of the whole line. The locomotives were worked very hard and continuously, and in 1858 a decision was taken to acquire a third: in September 1859 ''Spitfire'', an 0-6-0 saddle tank from Neilson started work. She usually operated the section above Nangiles loop, making four round trips daily, with the earlier locomotives feeding traffic up to her. The traffic was almost entirely coal upwards and copper ore downwards. Shunting on the quays at Devoran, and on the eastward extension to Point, was in the charge of horses.


Decline of copper extraction

By the late 1860s copper mining in the area was declining, and by 1870 it became a depression, when the Clifford Amalgamated Mines closed. This resulted in a disastrous loss of income, and decline continued. Catastrophe struck in the heavy winter of 1876–77 when the
Great County Adit The Great County Adit, sometimes called the County Adit, or the Great Adit was a system of interconnected adits that helped drain water from the tin and copper mines in the Gwennap area of Cornwall, in the United Kingdom. Construction started in 1 ...
(a common drainage system formerly used by several deep mines) which had fallen into disrepair and become blocked, suddenly burst and caused the instant silting of Devoran Harbour, forcing vessels to discharge by tender. It was plain that the company had no trading future, and on 18 July 1879 it passed into receivership, continuing to trade, however.


Miscellaneous

Today the restored Count House of Old Wheal Buller Mine overlooks the trackbeds of two early and unrecorded sidings, and beyond, to the Buller branch of the railway).


Route

Writing in 1831, Priestley said:
The main line of this railway commences at the extensive tin works on the east side of the town of Redruth, whence it takes a south-easterly course round the mountain of Cam Marth; thence north-easterly by Carrarath to Twelve Heads, whence it takes a south-eastward course by Nangiles and Carnon Gate to Point Quay, situate on an estuary branching out of Carreg Road. Its length is nine miles, two furlongs and four chains; in the first mile and seven chains of which, to Wheel icBeauchamp, there is a rise of 103 feet; from thence to its termination it is one gradual inclination with a fall of 555 feet to high-water-mark. From Carnon Gate there is a branch to Narrabo of one mile one furlong; another branch from Nangiles to Wheel Fortune of three furlongs and five chains; another from Twelve Heads to Wheel Bissey, two miles, two furlongs and five chains in length; and another from Wheel Beauchamp to Wheel Buller, of two furlongs four chains in length. The total length of main line and branches is thirteen miles, three furlongs and eight chains.
Reference Kidner * Redruth (Gwennap pit) 0m * Lanner 1½m ** branch to Wheal Bassett mine *
Carharrack Carharrack ( kw, Karardhek) is a civil parish and village in west Cornwall, England, United Kingdom. It is situated two miles (3 km) east of Redruth in a former mining area. The parish is of a rural/residential character, albeit with an ...
3m * Hale Mills ** uncompleted branch to Chacewater * Bissoe 6m * Devoran 8m * Penpol 9m


Success

Initially the line was generally successful. It served both
Great Consols Consolidated Mines, also known as Great Consolidated mine, but most commonly called Consols or Great Consols was a metalliferous mine about a mile ESE of the village of St Day, Cornwall, England. Mainly active during the first half of the 19th ...
and
United Mines United may refer to: Places * United, Pennsylvania, an unincorporated community * United, West Virginia, an unincorporated community Arts and entertainment Films * ''United'' (2003 film), a Norwegian film * ''United'' (2011 film), a BBC Two fi ...
, the two largest in the area, and traffic by the 1830s was well in excess of 60,000 tons annually with the company reporting profits approaching £3,000.
Copper ore Following is a list of minerals that serve as copper ores in the copper mining Copper extraction refers to the methods used to obtain copper from its ores. The conversion of copper consists of a series of physical and electrochemical proces ...
transported down to ships for onward movement to South Wales was supplemented by coal carried in the other direction to serve the ever-deeper mines. Initially the railway company had not been carriers, and up to 1854 the line was worked throughout by horses, but in November 1854 two tank engines, ''Miner'' and ''Smelter'' were delivered and began working between Devoran and Carharrack, making the Redruth and Chasewater one of the first narrow gauge railways to introduce steam locomotives. They were delivered as 0-4-0ST's, but were rough riders due to excessive overhang at the rear, so were soon rebuilt as 0-4-2ST's. At this time the remainder of the railway was operated by the company's own horses. By 1859 traffic had increased to 90,000 tons annually leading to the acquisition of a third engine, ''Spitfire''. Spitfire was named after an incident where ''Miner'' and ''Smelter'' working hard uphill would scatter cinders and sparks. As a result, a nearby thatched cottage was in danger. The company was persuaded to rebuild it at a safe distance from the line and replace the thatch with slates. The owner was a valued shareholder in the company. The acquisition of ''Spitfire'' enabled the whole line from Devoran to Redruth to be worked by steam except the final from Devoran to Point Quay which remained horse-worked until final closure.


Decline

The railway workshops, like the offices, were located in Devoran, and ''Miner'' was substantially rebuilt here in 1869, but traffic began to decline as the copper mines closed and in 1879 a receiver was appointed. ''Smelter'' was relegated to the status of reserve engine; but lack of maintenance meant that the line deteriorated and derailments were common. Spitfire was rebuilt, but this was a disaster compared to that of Miner. A new firebox was ordered, it was slightly too big, and apparently the frames were forced apart to accommodate it, with subsequent wear on the rear springs and bearings. The coming of the Great Western Railway eventually ended the R&C as the last major customer of the R&C, Basset Mines, switched to using the GWR. The R&C, in the following six months only carried around 6,500 tons of goods as opposed to some 22,000 for the previous year. The extension to Chacewater that gave the railway its name was never completed despite works starting in 1853. Closure of the line finally came on 25 September 1915 when ''Miner'' took the last train down to Devoran. The line was dismantled, locomotives, wagons and rails became scrap. As the line depended on the mines, so did the port of Devoran rely on the railway, less than a year after its closure, the last commercial vessel called at Devoran.


Locomotives

The three locomotives were very similar to look at, being described as "odd-looking". The boiler was surmounted by a square tank from which projected a tall chimney; the cabs were open with sides lower than the top of the tanks.


Ships

In 1848, the company purchased the
steam Steam is a substance containing water in the gas phase, and sometimes also an aerosol of liquid water droplets, or air. This may occur due to evaporation or due to boiling, where heat is applied until water reaches the enthalpy of vaporization ...
tug ''Sydney''. On 6 March, she sprang a leak and sank at Falmouth.


Today

Most of the route of the railway is now followed by the ''Redruth and Chacewater Railway Trail'' which links up with the
Great Flat Lode Trail The Great Flat Lode is a mineral-bearing body of rock under the southern granite slopes of Carn Brea south of Camborne in west Cornwall, England, UK. Mining The Great Flat Lode lies under the southern granite slopes of Carn Brea and so named ...
at Redruth. It featured in the BBC TV programme "Railway Walks", first broadcast on BBC Four on 16 October 2008.


See also

*
British industrial narrow gauge railways British industrial narrow-gauge railways are narrow-gauge railways in the United Kingdom and the Isle of Man that were primarily built to serve one or more industries. Some offered passenger services for employees or workmen, but they did not run p ...


References

*

The History of the Count House of Old Wheal Buller mine which overlooks the Buller branch of the Redruth and Chasewater Railway. {{Authority control 4 ft gauge railways in England Early British railway companies Industrial railways in England Pre-grouping British railway companies Rail transport in Cornwall Railway companies established in 1824 Railway lines opened in 1826 Railway companies disestablished in 1915 Horse-drawn railways 1824 establishments in England British companies established in 1824