The Rotax 912 is a horizontally-opposed four-cylinder,

naturally aspirated Naturally may refer to: ;Albums * ''Naturally!'', an album by Nat Adderley * ''Naturally'' (Houston Person album) * ''Naturally'' (J. J. Cale album) * ''Naturally'' (John Pizzarelli album) * ''Naturally'' (Sharon Jones album) * ''Naturally'' ...

four-stroke A four-stroke (also four-cycle) engine is an internal combustion (IC) engine in which the piston completes four separate strokes while turning the crankshaft. A stroke refers to the full travel of the piston along the cylinder, in either directio ...

aircraft engine An aircraft engine, often referred to as an aero engine, is the power component of an aircraft propulsion system. Most aircraft engines are either piston engines or gas turbines, although a few have been rocket powered and in recent years many ...

with a reduction gearbox. It features

liquid-cooled Liquid cooling refers to cooling by means of the convection or circulation of a liquid. Examples of liquid cooling technologies include: * Cooling by convection or circulation of coolant, including water cooling * Liquid cooling and ventilatio ...

cylinder heads and air-cooled cylinders. Originally equipped with

carburetor A carburetor (also spelled carburettor) is a device used by an internal combustion engine to control and mix air and fuel entering the engine. The primary method of adding fuel to the intake air is through the venturi tube in the main meteri ...

s, later versions are fuel injected. Dominating the market for small aircraft and kitplanes, Rotax produced its 50,000th 912-series engine in 2014. Originally available only for light sport aircraft,

ultralight aircraft Ultralight aviation (called microlight aviation in some countries) is the flying of lightweight, 1- or 2-seat fixed-wing aircraft. Some countries differentiate between weight-shift control and conventional three-axis control aircraft with ailer ...

, autogyros and

drones Drone most commonly refers to: * Drone (bee), a male bee, from an unfertilized egg * Unmanned aerial vehicle * Unmanned surface vehicle, watercraft * Unmanned underwater vehicle or underwater drone Drone, drones or The Drones may also refer to: ...

, the 912-series engine was approved for

certified Certification is the provision by an independent body of written assurance (a certificate) that the product, service or system in question meets specific requirements. It is the formal attestation or confirmation of certain characteristics of a ...

aircraft in 1995.

Design and development

The Rotax 912 was first sold in 1989 in non- certificated form for use in ultralights and motorgliders. The original 912 UL engine has a capacity of and a compression ratio of 9.1:1. The engine differs from previous generation aircraft engines (such as the Lycoming O-235) in that it has air-cooled cylinders with liquid-cooled heads and uses a 2.43:1 PSRU reduction gearbox to reduce the engine's relatively high 5,800 rpm shaft speed to a more conventional 2,400 rpm for the

propeller A propeller (colloquially often called a screw if on a ship or an airscrew if on an aircraft) is a device with a rotating hub and radiating blades that are set at a pitch to form a helical spiral which, when rotated, exerts linear thrust upon ...

. The gearbox has proven to be generally trouble-free. On the 912A, F and UL the standard reduction ratio is 2.27:1 with 2.43:1 optional. Lubrication is dry sump, and fuelling is via dual CV carburetors or fully redundant electronic fuel injection. The electronic fuel injected Rotax 912iS is a recent development. The 912's lubrication system differs from most dry-sump designs in that oil is forced into the storage tank by

crankcase In a piston engine, the crankcase is the housing that surrounds the crankshaft. In most modern engines, the crankcase is integrated into the engine block. Two-stroke engines typically use a crankcase-compression design, resulting in the fuel/a ...

pressure rather than by a separate scavenge pump. This requires a novel

preflight inspection In aviation, an outside check or walk around is the air crew inspecting certain elements of an aircraft prior to boarding for security, safety, and operational reasons. The pilot primarily inspects outside parts of the aircraft they will ste ...

procedure: before checking the oil level with the

dipstick A dipstick is one of several measurement devices. Some dipsticks are dipped into a liquid to perform a chemical test or to provide a measure of quantity of the liquid. Since the late 20th century, a flatness/levelness measuring device trademarke ...

, the engine is "burped" by removing the oil filler cap and turning the propeller until a gurgling sound is heard, which indicates that all oil has been forced into the tank and the oil level can now be checked accurately. The 912 is more fuel efficient and lighter than comparable older engines, ''e.g.'', Continental O-200, but originally had a shorter time between overhaul (TBO). On introduction, the TBO was only 600 hours, which was double that of previous Rotax engines but far short of existing engines of comparable size and power. The short TBO and lack of certification for use in factory-built type certificated aircraft initially restricted its worldwide market potential. However, the engine received US Federal Aviation Administration (FAA) certification in 1995, and by 1999, the TBO had increased to 1,200 hours; on 14 December 2009, the TBO was raised from 1,200 hours to 1,500 hours, or 1,500 hours to 2,000 hours, depending on serial number. In addition to the lower fuel consumption, the 912 is certified to run on automotive fuel (mogas), further reducing running costs, especially in areas where leaded

avgas Avgas (aviation gasoline, also known as aviation spirit in the UK) is an aviation fuel used in aircraft with spark-ignited internal combustion engines. ''Avgas'' is distinguished from conventional gasoline (petrol) used in motor vehicles, w ...

is not readily available. The 912 may be operated using leaded fuel, but this is not recommended as lead sludge tends to accumulate in the oil tank and reduction gearbox. Also, avgas is incompatible with the recommended

synthetic oil Synthetic oil is a lubricant consisting of chemical compounds that are artificially modified or synthesised. Synthetic lubricants can be manufactured using chemically modified petroleum components rather than whole crude oil, but can also be syn ...

which cannot hold lead in suspension; consequently, the use of leaded fuel mandates additional maintenance. A

turbocharged In an internal combustion engine, a turbocharger (often called a turbo) is a forced induction device that is powered by the flow of exhaust gases. It uses this energy to compress the intake gas, forcing more air into the engine in order to pro ...

variant rated at , the Rotax 914, was introduced in 1996. In 1999, the 912S / ULS were introduced; enlarged to with a compression ratio of 10.8:1, yielding . The 912S is certified, as are the A and F, which are used in the Diamond DA20, which is quite popular in Europe. The 912's popularity was greatly enhanced by the introduction of the

light-sport aircraft A light-sport aircraft (LSA), or light sport aircraft, is a fairly new category of small, lightweight aircraft that are simple to fly. LSAs tend to be heavier and more sophisticated than ultralight (aka "microlight") aircraft, but LSA restrictio ...

category in Europe and the United States, which resulted in the introduction of many factory-built aircraft designed to fully exploit the engine's small size and light weight. The versions are used in many light sport aircraft, such as the Zenith STOL CH 701 and the Tecnam P2002 Sierra. The versions are sufficient to power the new generation of efficient motorgliders, such as the

Pipistrel Sinus The Pipistrel Sinus is a two-seat, single-engine ultralight motor glider, developed and manufactured by Pipistrel in Slovenia and Italy.Vandermeullen, Richard: ''2012 Kit Aircraft Buyer's Guide'', Kitplanes, Volume 28, Number 12, December 2011 ...

and the

Urban Air Lambada The Distar UFM-13 Lambada (named for the Brazilian dance) is a Czech shoulder-wing, two-seat motor glider originally designed and produced by Urban Air and now built by Distar Air of Ústí nad Orlicí.Bayerl, Robby; Martin Berkemeier; et a ...

. It is also fitted to some light twins, such as the Tecnam P2006T. On 8 March 2012 the company displayed its 912 iS variant, a version with

fuel injection Fuel injection is the introduction of fuel in an internal combustion engine, most commonly automotive engines, by the means of an injector. This article focuses on fuel injection in reciprocating piston and Wankel rotary engines. All comp ...

and an electronic engine management unit. The version weighs , which is more than the standard 912S. The non-certified 912 iS targets the light sport and homebuilt aircraft market and 912 iSc will be

. Production started in March 2012 and the engine has a 2000-hour recommended time-between-overhaul to start. On 1 April 2014 the company announced its new 912 iS Sport upgrade with greater power and torque and reduced fuel consumption. A further derivative, the

Rotax 915 iS The Rotax 915 iS is an Austrian aircraft engine, produced by Rotax of Gunskirchen for use in ultralight aircraft, homebuilt aircraft, light-sport aircraft, small helicopters and gyroplanes. The engine was type certified in 2017. The engine was ...

, was announced in July 2015.

Rotax's warnings to flyers

Unusually for a manufacturer of small aero-engines, Rotax publishes extensive warnings in the owner's manual about both the certified and non-certified versions of the engine design. Pilots are cautioned that the 912 engine is not suitable for: *use in situations where a safe landing cannot be made *use in rotorcraft *night flying (unless equipped with redundant electrical power), or *

aerobatic Aerobatics is the practice of flying maneuvers involving aircraft attitudes that are not used in conventional passenger-carrying flights. The term is a portmanteau of "aerial" and "acrobatics". Aerobatics are performed in aeroplanes and glid ...

s. The manual states that Rotax gives no assurances that the engine is suitable for use in any aircraft, and that the engine may seize or stall at any time, which could lead to a crash landing. The manual adds that non-compliance with such warnings could lead to serious injury or death.

Variants

The engine is available in the following versions: ;912 A# :Certified to

JAR 22 The Joint Aviation Requirements (JAR) were a set of common comprehensive and detailed aviation requirement issued by the Joint Aviation Authorities, intended to minimise Type Certification problems on joint ventures, and also to facilitate the exp ...

, , with dual carburetors and electronic ignition ;912 F# :Certified to FAR 33, , with dual carburetors and electronic ignition ;912 iS :Uncertified, with direct fuel injection and an electronic engine management unit ;912 iSc :Certified, with direct fuel injection and an electronic engine management unit ;912 iS Sport :Uncertified, aluminum airbox, longer intake runners and eco-mode when operated below 97% power setting. ;912 S# :Certified to FAR 33, with larger bore than 912A/F/UL, with dual carburetors and electronic ignition ;912 UL# :Uncertified, , similar to the 912A/F ;912 ULS# :Uncertified, , similar to the 912S ;912 ULSFR# :Uncertified French Authority specification. The # in the designation stands for: # Shaft with flange for fixed pitch propeller, P.C.D. 100 mm # Shaft with flange for fixed pitch propeller, P.C.D. 75 mm, P.C.D. 80 mm and P.C.D. 4 inches # Shaft with flange for constant speed propeller P.C.D. 75 mm, P.C.D. 80 mm, P.C.D. 4 inches and drive for hydraulic governor for constant speed propeller # Shaft with flange for fixed pitch propeller P.C.D. 75 mm, P.C.D. 80 mm, P.C.D. 4 inches also can be fitted with an adaptor, drive and governor for a constant speed propeller.

Applications

Specifications (Rotax 912 UL/A/F)

References

External links

The aircraft engines section of the official Rotax company websiteFAA Type Certificate Data Sheet E00051EN

912 UL 80 hp Engine Datasheet912 ULS 100 hp Engine Datasheet914 UL 115 hp Turbocharged Engine Datasheet
{{Rotax aeroengines Boxer engines Rotax engines 1980s aircraft piston engines