![SwissKeroseneLamp](https://upload.wikimedia.org/wikipedia/commons/9/91/SwissKeroseneLamp.jpg)
A kerosene lamp (also known as a paraffin lamp in some countries) is a type of
lighting
Lighting or illumination is the deliberate use of light to achieve practical or aesthetic effects. Lighting includes the use of both artificial light sources like lamps and light fixtures, as well as natural illumination by capturing daylig ...
device that uses
kerosene
Kerosene, paraffin, or lamp oil is a combustible hydrocarbon liquid which is derived from petroleum. It is widely used as a fuel in aviation as well as households. Its name derives from el, κηρός (''keros'') meaning "wax", and was regi ...
as a
fuel
A fuel is any material that can be made to react with other substances so that it releases energy as thermal energy or to be used for work. The concept was originally applied solely to those materials capable of releasing chemical energy but ...
. Kerosene lamps have a
wick
Wick most often refers to:
* Capillary action ("wicking")
** Candle wick, the cord used in a candle or oil lamp
** Solder wick, a copper-braided wire used to desolder electronic contacts
Wick or WICK may also refer to:
Places and placenames ...
or
mantle as light source, protected by a glass chimney or globe; lamps may be used on a table, or hand-held
lantern
A lantern is an often portable source of lighting, typically featuring a protective enclosure for the light sourcehistorically usually a candle or a wick in oil, and often a battery-powered light in modern timesto make it easier to carry and h ...
s may be used for portable lighting. Like
oil lamp
An oil lamp is a lamp used to produce light continuously for a period of time using an oil-based fuel source. The use of oil lamps began thousands of years ago and continues to this day, although their use is less common in modern times. Th ...
s, they are useful for lighting without electricity, such as in regions without
rural electrification
Rural electrification is the process of bringing electrical power to rural and remote areas. Rural communities are suffering from colossal market failures as the national grids fall short of their demand for electricity. As of 2017, over 1 billion ...
, in
electrified
Electrification is the process of powering by electricity and, in many contexts, the introduction of such power by changing over from an earlier power source.
The broad meaning of the term, such as in the history of technology, economic history ...
areas during
power outage
A power outage (also called a powercut, a power out, a power failure, a power blackout, a power loss, or a blackout) is the loss of the electrical power network supply to an end user.
There are many causes of power failures in an electricit ...
s, at
campsite
A campsite, also known as a campground or camping pitch, is a place used for overnight stay in an outdoor area. In British English, a ''campsite'' is an area, usually divided into a number of pitches, where people can camp overnight using te ...
s, and on
boat
A boat is a watercraft of a large range of types and sizes, but generally smaller than a ship, which is distinguished by its larger size, shape, cargo or passenger capacity, or its ability to carry boats.
Small boats are typically found on inl ...
s. There are three types of kerosene lamp: flat-wick, central-draught (tubular round wick), and mantle lamp. Kerosene lanterns meant for portable use have a flat wick and are made in dead-flame, hot-blast, and cold-blast variants.
Pressurized kerosene lamps use a
gas mantle
A Coleman white gas lantern mantle glowing at full brightness
An incandescent gas mantle, gas mantle or Welsbach mantle is a device for generating incandescent bright white light when heated by a flame. The name refers to its original heat sou ...
; these are known as
Petromax
Petromax is a brand name for a type of pressurised paraffin lamp ( US: kerosene lamp) that uses a mantle. They are as synonymous with the paraffin lamp in Continental Europe as Tilley lamps are in Britain and Coleman lanterns are in the United ...
,
Tilley lamp
The Tilley lamp is a kerosene pressure lamp.
History
In 1813, John Tilley invented the hydro-pneumatic blowpipe. In 1818, William Henry Tilley, gas fitters, was manufacturing gas lamps in Stoke Newington, and, in the 1830s, in Shoreditch.
...
s, or
Coleman lamps, among other manufacturers. They produce more light per unit of fuel than wick-type lamps, but are more complex and expensive in construction and more complex to operate. A hand-pump pressurizes air, which forces liquid fuel from a reservoir into a gas chamber. Vapor from the chamber burns, heating a mantle to incandescence and also providing heat.
Kerosene lamps are widely used for lighting in rural areas of Africa and Asia, where electricity is not distributed or is too costly. As of 2005, kerosene and other fuel-based illumination methods consume an estimated of fuel per year, equivalent to per day. This is comparable to annual U.S. jet-fuel consumption of per year.
History
In 1813, John Tilley invented the hydro-pneumatic blowpipe.
In 1818, William Henry Tilley, gas fitters, was manufacturing gas lamps in
Stoke Newington
Stoke Newington is an area occupying the north-west part of the London Borough of Hackney in north-east London, England. It is northeast of Charing Cross. The Manor of Stoke Newington gave its name to Stoke Newington the ancient parish.
The ...
.
In 1846,
Abraham Pineo Gesner
Abraham Pineo Gesner, ONB (; May 2, 1797 – April 29, 1864) was a Canadian physician and geologist who invented kerosene. Gesner was born in Cornwallis, Nova Scotia (now called Chipmans Corner) and lived much of his life in Saint John, New Bru ...
invented a substitute for
whale oil
Whale oil is oil obtained from the blubber of whales. Whale oil from the bowhead whale was sometimes known as train oil, which comes from the Dutch word ''traan'' ("tears, tear" or "drop").
Sperm oil, a special kind of oil obtained from the ...
for lighting, distilled from coal. Later made from petroleum,
paraffin lamp
A kerosene lamp (also known as a paraffin lamp in some countries) is a type of lighting device that uses kerosene as a fuel. Kerosene lamps have a wick or mantle as light source, protected by a glass chimney or globe; lamps may be used on a t ...
became a popular lighting fuel. Modern and most popular versions of the
paraffin lamp
A kerosene lamp (also known as a paraffin lamp in some countries) is a type of lighting device that uses kerosene as a fuel. Kerosene lamps have a wick or mantle as light source, protected by a glass chimney or globe; lamps may be used on a t ...
were later constructed by
Polish
Polish may refer to:
* Anything from or related to Poland, a country in Europe
* Polish language
* Poles, people from Poland or of Polish descent
* Polish chicken
*Polish brothers (Mark Polish and Michael Polish, born 1970), American twin screenwr ...
inventor and pharmacist
Ignacy Łukasiewicz
Jan Józef Ignacy Łukasiewicz (; 8 March 1822 – 7 January 1882) was a Polish pharmacist, engineer, businessman, inventor, and philanthropist. He was one of the most prominent philanthropists in the Kingdom of Galicia and Lodomeria, crown land o ...
, in
Lviv
Lviv ( uk, Львів) is the largest city in western Ukraine, and the seventh-largest in Ukraine, with a population of . It serves as the administrative centre of Lviv Oblast and Lviv Raion, and is one of the main cultural centres of Ukraine ...
in 1853. It was a significant improvement over lamps designed to burn vegetable or sperm oil.
In 1914, the
Coleman Lantern
The Coleman Lantern is a line of pressure lamps first introduced by the Coleman Company in 1914. This led to a series of lamps that were originally made to burn kerosene or gasoline. Current models use kerosene, gasoline, Coleman fuel (white ga ...
pressure lamp
A kerosene lamp (also known as a paraffin lamp in some countries) is a type of lighting device that uses kerosene as a fuel. Kerosene lamps have a wick or mantle as light source, protected by a glass chimney or globe; lamps may be used on a t ...
was introduced by the
Coleman Company
The Coleman Company, Inc. is an American brand of outdoor recreation products, especially camping gear, now owned by Newell Brands. The company's new headquarters are in Chicago, and it has facilities in Wichita, Kansas, and in Texas. There are ...
.
In 1919, Tilley High-Pressure Gas Company started using kerosene as a fuel for lamps.
Types
Flat-wick lamp
![Railway Lamp](https://upload.wikimedia.org/wikipedia/commons/5/56/Railway_Lamp.jpg)
A flat-wick lamp is a simple type of
kerosene
Kerosene, paraffin, or lamp oil is a combustible hydrocarbon liquid which is derived from petroleum. It is widely used as a fuel in aviation as well as households. Its name derives from el, κηρός (''keros'') meaning "wax", and was regi ...
lamp, which burns kerosene drawn up through a wick by
capillary action
Capillary action (sometimes called capillarity, capillary motion, capillary rise, capillary effect, or wicking) is the process of a liquid flowing in a narrow space without the assistance of, or even in opposition to, any external forces li ...
. If this type of lamp is broken, it can easily start a fire. A flat-wick lamp has a fuel tank (fount), with the lamp burner attached. Attached to the fuel tank, four prongs hold the glass chimney, which acts to prevent the flame from being blown out and enhances a thermally induced
draft
Draft, The Draft, or Draught may refer to:
Watercraft dimensions
* Draft (hull), the distance from waterline to keel of a vessel
* Draft (sail), degree of curvature in a sail
* Air draft, distance from waterline to the highest point on a vessel ...
. The glass chimney needs a "throat", or slight constriction, to create the proper draft for complete
combustion
Combustion, or burning, is a high-temperature exothermic redox chemical reaction between a fuel (the reductant) and an oxidant, usually atmospheric oxygen, that produces oxidized, often gaseous products, in a mixture termed as smoke. Combusti ...
of the fuel; the draft carries more air (oxygen) past the flame, helping to produce a smokeless light, which is brighter than an open flame would produce.
The chimney is used for a more important duty. The mantle/wick holder has holes around the outer edges. When the lantern is lit and a chimney is attached, the thermally induced draft draws air through these holes and passes over the top of the mantle, just as a chimney in your house. This has a cooling effect and keeps the mantle from over heating. Without a properly installed chimney, a definite safety condition exists. This is even more important if using Aladdin lamps. They also have a thinner chimney to induce a faster air-flow. This information should be adhered to regardless of the type of lantern in use.
The lamp burner has a flat wick, usually made of
cotton
Cotton is a soft, fluffy staple fiber that grows in a boll, or protective case, around the seeds of the cotton plants of the genus ''Gossypium'' in the mallow family Malvaceae. The fiber is almost pure cellulose, and can contain minor perce ...
. The lower part of the wick dips into the fount and absorbs the kerosene; the top part of the wick extends out of the wick tube of the lamp burner, which includes a wick-adjustment mechanism. Adjusting how much of the wick extends above the wick tube controls the flame. The wick tube surrounds the wick and ensures that the correct amount of air reaches the lamp burner. Adjustment is usually done by means of a small knob operating a cric, which is a toothed metal
sprocket
A sprocket, sprocket-wheel or chainwheel is a profiled wheel with teeth that mesh with a chain, track or other perforated or indented material. The name 'sprocket' applies generally to any wheel upon which radial projections engage a chain passi ...
bearing against the wick. If the wick is too high, and extends beyond the burner cone at the top of the wick tube, the lamp will produce
smoke
Smoke is a suspension of airborne particulates and gases emitted when a material undergoes combustion or pyrolysis, together with the quantity of air that is entrained or otherwise mixed into the mass. It is commonly an unwanted by-product ...
and
soot
Soot ( ) is a mass of impure carbon particles resulting from the incomplete combustion of hydrocarbons. It is more properly restricted to the product of the gas-phase combustion process but is commonly extended to include the residual pyrolysed ...
(unburned carbon). When the lamp is lit, the kerosene that the wick has absorbed burns and produces a clear, bright, yellow
flame
A flame (from Latin ''flamma'') is the visible, gaseous part of a fire. It is caused by a highly exothermic chemical reaction taking place in a thin zone. When flames are hot enough to have ionized gaseous components of sufficient density they ...
. As the kerosene burns,
capillary action
Capillary action (sometimes called capillarity, capillary motion, capillary rise, capillary effect, or wicking) is the process of a liquid flowing in a narrow space without the assistance of, or even in opposition to, any external forces li ...
in the wick draws more kerosene up from the fuel tank. All kerosene flat-wick lamps use the dead-flame burner design, where the flame is fed cold air from below, and hot air exits above.
This type of lamp was very widely used by railways, both on the front and rear of trains and for hand signals, due to its reliability. At a time when there were few competing light sources at night outside major towns, the limited brightness of these lamps was adequate and could be seen at sufficient distance to serve as a warning or signal.
Central-draft (tubular round wick) lamp
![Idealbrenner](https://upload.wikimedia.org/wikipedia/commons/1/1b/Idealbrenner.JPG)
A central-draught lamp, or
Argand lamp
The Argand lamp is a type of oil lamp invented in 1780 by Aimé Argand. Its output is 6 to 10 candelas, brighter than that of earlier lamps. Its more complete combustion of the candle wick and oil than in other lamps required much less frequent ...
, works in the same manner as the flat-wick lamp. The burner is equipped with a tall glass chimney, of around tall or taller, to provide the powerful draft this lamp requires to burn properly. The burner uses a wick, usually made of
cotton
Cotton is a soft, fluffy staple fiber that grows in a boll, or protective case, around the seeds of the cotton plants of the genus ''Gossypium'' in the mallow family Malvaceae. The fiber is almost pure cellulose, and can contain minor perce ...
, that is made of a wide, flat wick rolled into a tube, the seam of which is then stitched together to form the complete wick. The tubular wick is then mounted into a "carrier", which is some form of a toothed rack that engages into the gears of the wick-raising mechanism of the burner and allows the wick to be raised and lowered. The wick rides in between the inner and outer wick tubes; the inner wick tube (central draft tube) provides the "central draft" or draft that supplies air to the flame spreader. When the lamp is lit, the central draft tube supplies air to the flame spreader that spreads out the flame into a ring of
fire
Fire is the rapid oxidation of a material (the fuel) in the exothermic chemical process of combustion, releasing heat, light, and various reaction Product (chemistry), products.
At a certain point in the combustion reaction, called the ignition ...
and allows the lamp to burn cleanly.
Mantle lamp
![Sumburgh Lighthouse Lamp](https://upload.wikimedia.org/wikipedia/commons/7/71/Sumburgh_Lighthouse_Lamp.jpg)
A variation on the "central-draught" lamp is the mantle lamp. The mantle is a roughly pear-shaped mesh made of fabric placed over the burner. The mantle typically contains
thorium
Thorium is a weakly radioactive metallic chemical element with the symbol Th and atomic number 90. Thorium is silvery and tarnishes black when it is exposed to air, forming thorium dioxide; it is moderately soft and malleable and has a high me ...
or other
rare-earth
The rare-earth elements (REE), also called the rare-earth metals or (in context) rare-earth oxides or sometimes the lanthanides (yttrium and scandium are usually included as rare earths), are a set of 17 nearly-indistinguishable lustrous silve ...
salts
In chemistry, a salt is a chemical compound consisting of an ionic assembly of positively charged cations and negatively charged anions, which results in a compound with no net electric charge. A common example is table salt, with positively cha ...
; on first use the cloth burns away, and the rare-earth salts are converted to oxides, leaving a very fragile structure, which
incandesces (glows brightly) upon exposure to the heat of the burner flame. Mantle lamps are considerably brighter than flat- or round-wick lamps, produce a whiter light and generate more
heat
In thermodynamics, heat is defined as the form of energy crossing the boundary of a thermodynamic system by virtue of a temperature difference across the boundary. A thermodynamic system does not ''contain'' heat. Nevertheless, the term is al ...
. Mantle lamps typically use fuel faster than a flat-wick lamp, but slower than a center-draught round-wick, as they depend on a small flame heating a mantle, rather than having all the light coming from the flame itself.
Mantle lamps are nearly always bright enough to benefit from a lampshade, and a few mantle lamps may be enough to heat a small building in cold weather. Mantle lamps, because of the higher
temperature
Temperature is a physical quantity that expresses quantitatively the perceptions of hotness and coldness. Temperature is measured with a thermometer.
Thermometers are calibrated in various temperature scales that historically have relied o ...
at which they operate, do not produce much odor, except when first lit or extinguished. Like flat- and round-wick lamps, they can be adjusted for brightness; however, caution must be used, because if set too high, the lamp chimney and the mantle can become covered with black areas of soot. A lamp set too high will burn off its soot harmlessly if quickly turned down, but if not caught soon enough, the soot itself can ignite, and a "runaway lamp" condition can result.
All unpressurized mantle lamps are based on the Argand lamp that was improved by the
Clamond basket A Clamond basket is a kind of gas mantle, invented in the 1880s by the Paris, Parisian Charles Clamond, and which he later patented in the United States of America, United States. It was the first economically practical gas mantle, since prior mantl ...
mantle. These lamps were popular from 1882 until shortly after WWII, when rural electrification made them obsolete. Aladdin Lamps is the only maker of this style lamp today. Even they, are now marketing electric fixtures that fit the old style lamps.
Large fixed pressurized kerosene mantle lamps were used in
lighthouse
A lighthouse is a tower, building, or other type of physical structure designed to emit light from a system of lamps and lenses and to serve as a beacon for navigational aid, for maritime pilots at sea or on inland waterways.
Lighthouses mar ...
beacons for navigation of ships, brighter and with lower fuel consumption than oil lamps used before. An early version of the
gas mantle
A Coleman white gas lantern mantle glowing at full brightness
An incandescent gas mantle, gas mantle or Welsbach mantle is a device for generating incandescent bright white light when heated by a flame. The name refers to its original heat sou ...
lamp, kerosene was vaporized by a secondary burner, which pressurized the kerosene tank that supplied the central draught. Like all gas mantle lamps, the only purpose of the burner is to hold the flame that heats the mantle, which is 4-5 times as bright as the wick itself. The
Coleman camping lantern is the direct descendant of this type lamp.
Kerosene lantern
![Kerosene-lamp-01](https://upload.wikimedia.org/wikipedia/commons/1/19/Kerosene-lamp-01.JPG)
A kerosene lantern, also known as a "barn lantern" or "hurricane lantern", is a flat-wick lamp made for portable and outdoor use. They are made of soldered or crimped-together sheet-metal stampings, with tin-plated sheet steel being the most common material, followed by brass and copper. There are three types: dead-flame, hot-blast, and cold-blast. Both hot-blast and cold-blast designs are called tubular lanterns and are safer than dead-flame lamps, as tipping over a tubular lantern cuts off the oxygen flow to the burner and will extinguish the flame within seconds.
![Kerosine lamp](https://upload.wikimedia.org/wikipedia/commons/e/e5/Kerosine_lamp.jpg)
The earliest portable kerosene "glass globe" lanterns, of the 1850s and 1860s, were of the dead-flame type, meaning that it had an open wick, but the airflow to the flame was strictly controlled in an upward motion by a combination of vents at the bottom of the burner and an open topped chimney. This had the effect of removing side-to-side drafts and thus significantly reducing or even eliminating the flickering that can occur with an exposed flame.
Later lanterns, such as the hot-blast and cold-blast lanterns, took this airflow control even further by partially or fully enclosing the wick in a "deflector" or "burner cone" and then channeling the air to be supplied for combustion at the wick while at the same time pre-heating the air for combustion.
The hot-blast design, also known as a "tubular lantern" due to the metal tubes used in its construction, was invented by John H. Irwin and was .
As noted in the patent, the "novel mode of constructing a lantern whereby the wind, instead of acting upon the flame in such a manner as to extinguish it, serves to support or sustain and prevent the extinguishment thereof." This improvement essentially redirected wind which might normally tend to extinguish the flame of an unprotected dead-flame lantern, instead is redirected, slowed, pre-heated, and supplied to the burner to actually support and promote the combustion of the fuel.
Later, Irwin improved upon this design by inventing and .
This design is similar to his earlier "hot-blast" design, except that the oxygen-depleted hot combustion byproducts are redirected and prevented from recirculating back to the burner by redesigning the intake products, so that only oxygen-rich, fresh air is drawn from the atmosphere into the lamp ("the inlets for fresh air are placed out of the ascending current of products of combustion, and said products are thereby prevented from entering
he air intake). The primary benefit of this design compared to the earlier "hot-blast" design was to maximize the amount of oxygen available for combustion by ensuring that only fresh air is supplied to the burner, thereby increasing the brightness and stability of the flame.
Safety
Combustion
Contamination of lamp fuel with even a small amount of gasoline results in a lower flash point and higher vapor pressure for the fuel, with potentially dangerous consequences. Vapors from spilled fuel may ignite; vapor trapped above liquid fuel may lead to excess pressure and fires. Kerosene lamps are still extensively used in areas without electrical lighting; the cost and dangers of combustion lighting are a continuing concern in many countries.
Inhalation
The
World Health Organization
The World Health Organization (WHO) is a specialized agency of the United Nations responsible for international public health. The WHO Constitution states its main objective as "the attainment by all peoples of the highest possible level of h ...
considers kerosene to be a polluting fuel and recommends that “governments and practitioners immediately stop promoting its household use”. Kerosene smoke contains high levels of harmful
particulate matter
Particulates – also known as atmospheric aerosol particles, atmospheric particulate matter, particulate matter (PM) or suspended particulate matter (SPM) – are microscopic particles of solid or liquid matter suspended in the air. The ter ...
, and household use of kerosene is associated with higher risks of cancer, respiratory infections, asthma, tuberculosis,
cataract
A cataract is a cloudy area in the lens of the eye that leads to a decrease in vision. Cataracts often develop slowly and can affect one or both eyes. Symptoms may include faded colors, blurry or double vision, halos around light, trouble w ...
, and adverse pregnancy outcomes.
Performance
Flat-wick lamps have the lowest light output, center-draft round-wick lamps have 3–4 times the output of flat-wick lamps, and pressurized lamps have higher output yet; the range is from 8 to 100
lumens. A kerosene lamp producing 37 lumens for 4 hours per day consumes about of kerosene per month.
[Narasimha Desirazu Rao ''Distributional Impacts of Energy Policies in India: Implications for Equity'' Stanford University, 2011 page 36.]
12.57 lumens = 1 CP
See also
*
Candles
A candle is an ignitable wick embedded in wax, or another flammable solid substance such as tallow, that provides light, and in some cases, a fragrance. A candle can also provide heat or a method of keeping time.
A person who makes candles i ...
*
List of light sources
This is a list of sources of light, the visible part of the electromagnetic spectrum. Light sources produce photons from another energy source, such as heat, chemical reactions, or conversion of mass or a different frequency of electromagnetic ener ...
*
Robert Edwin Newbery
*
Safe bottle lamp
Notes
References
External links
*
Information on blinking kerosene lampsInformation on Dietz Kerosene Lamps and LanternsMaking and Repairing Kerosene Lamps
{{Authority control
Austrian inventions
History of the petroleum industry
Fireplaces
Polish inventions
Rural society
Oil lamp
Iranian inventions