The General Electric H-Series is a family of
turboprop
A turboprop is a turbine engine that drives an aircraft propeller.
A turboprop consists of an intake, reduction gearbox, compressor, combustor, turbine, and a propelling nozzle. Air enters the intake and is compressed by the compressor. ...
aircraft engines produced by
GE BGA Turboprops. The initial H80 is an updated derivative of the
Walter M601
The Walter M601 is a turboprop aircraft engine produced by Walter Aircraft Engines of the Czech Republic. The company's first turboprop, the M601 is used in business, agricultural and military training aircraft.
Development
The turboprop wa ...
, while the H75 and H85 are later derivatives.
Development
![Silnik Walter M601T](https://upload.wikimedia.org/wikipedia/commons/b/b8/Silnik_Walter_M601T.jpg)
The H80 was launched in 2009 based on the M601. GE added a new compressor,
blisk
A blisk (portmanteau of bladed disk) is a turbomachine component comprising both rotor disk and blades. It serves as a critical component of the engine compressor to allow a sufficient quantity of compressed air to enter the engine for combustion ...
s, blades and new stators to enhance power by 3% and boost efficiency by 10%.
It reaches (
shaft horsepower
Horsepower (hp) is a unit of measurement of power, or the rate at which work is done, usually in reference to the output of engines or motors. There are many different standards and types of horsepower. Two common definitions used today are the ...
) from the M601-F's , and improves
hot and high
In aviation, hot and high is a condition of low air density due to high ambient temperature and high airport elevation. Air density decreases with increasing temperature and altitude. The lower air density reduces the power output from the airc ...
performance.
The H80 was certificated by EASA at 13 December 2011, followed by the FAA at 13 March 2012. Its Russian type certificate was received in October 2012, and the engine also approved by Brazilian Civil Aviation agency (ANAC) and the Argentine Administración Nacional de Aviación Civil.
Its
Electronic Engine and Propeller Control (EEPC) system received EASA type certification in late 2016.
The
Diamond Dart 550
The Diamond DART is a series of tandem, two-seat civilian and military turboprop trainers manufactured by Austrian Diamond Aircraft, "DART" meaning ''Diamond Aircraft Reconnaissance Trainer''.
Development
The DART-450 made its first flight o ...
military trainer is due to fly it in early 2018 and it will be certified on the
Thrush 510G crop duster in this year.
[
]
Design
The two-shaft, reverse flow design is derived from the Walter M601
The Walter M601 is a turboprop aircraft engine produced by Walter Aircraft Engines of the Czech Republic. The company's first turboprop, the M601 is used in business, agricultural and military training aircraft.
Development
The turboprop wa ...
: its core features a two-stage axial and single-stage centrifugal compressor
Centrifugal compressors, sometimes called impeller compressors or radial compressors, are a sub-class of dynamic axisymmetric work-absorbing turbomachinery.
They achieve pressure rise by adding energy to the continuous flow of fluid through t ...
, an annular combustor
A combustor is a component or area of a gas turbine, ramjet, or scramjet engine where combustion takes place. It is also known as a burner, combustion chamber or flame holder. In a gas turbine engine, the ''combustor'' or combustion chamber is fe ...
and a single turbine
A turbine ( or ) (from the Greek , ''tyrbē'', or Latin ''turbo'', meaning vortex) is a rotary mechanical device that extracts energy from a fluid flow and converts it into useful work. The work produced by a turbine can be used for generating ...
stage, and its propulsion section is powered by a single-stage turbine driving a two-stage planetary gearbox
An epicyclic gear train (also known as a planetary gearset) consists of two gears mounted so that the center of one gear revolves around the center of the other. A carrier connects the centers of the two gears and rotates the planet and sun gea ...
.
GE redesigned the compressor with 3D aero to improve its pressure ratio and upgraded the hot section and turbine stages with modern metal alloys for higher temperatures with the same durability.
The H75-100 weighs more than the equivalent PT6
The Pratt & Whitney Canada PT6 is a turboprop aircraft engine produced by Pratt & Whitney Canada.
Its design was started in 1958, it first ran in February 1960, first flew on 30 May 1961, entered service in 1964 and has been continuously up ...
but pioneers single lever electronic propeller and engine control in general aviation, for an initial TBO of 4,000 hr which could be increased with experience.[
It promises 10% better fuel burn, 10% longer overhaul and lower maintenance costs than the PT6A-135 for the ]Nextant G90XT
Nextant Aerospace is a United States-based company specializing in the remanufacturing of business jets.The Economist, “Business Jets for an Austere Age,” October 5, 201 Founded in 2007, Nextant is the first company to introduce the concept ...
.
Variants
;H80: formerly the M601H-80
;H75: 750 shp or 550 shp derivatives
;H75-A: 550 shp derivative with aerobatic modifications
;H85: 850 shp derivative
Applications
* CAIGA Primus 150
The AVIC Leadair AG300, previously called Primus 150, built by the China Aviation Industry General Aircraft, is a development of the Epic LT aircraft built using the international rights to Epic Aircraft bought in bankruptcy in 2010. As part of ...
(H85)
* Diamond Dart 550
The Diamond DART is a series of tandem, two-seat civilian and military turboprop trainers manufactured by Austrian Diamond Aircraft, "DART" meaning ''Diamond Aircraft Reconnaissance Trainer''.
Development
The DART-450 made its first flight o ...
(H75-100)
* Dornier Do-28 G92 (H75-200)
* Let L-410 Turbolet
The Let L-410 Turbolet is a twin-engine short-range transport aircraft, manufactured by the Czech aircraft manufacturer Let Kunovice (named Aircraft Industries since 2005), often used as an airliner. The aircraft is capable of landing on short a ...
UVP-E20 (H80-200) and L-410NG (H85)
* Nextant G90XT
Nextant Aerospace is a United States-based company specializing in the remanufacturing of business jets.The Economist, “Business Jets for an Austere Age,” October 5, 201 Founded in 2007, Nextant is the first company to introduce the concept ...
(H75-100)
* Technoavia Rysachok
The Technoavia Rysachok (Ru:Рысачок, en, Trotter) is a general purpose, twin turboprop-powered engined light utility aircraft, designed and built in Russia by Technoavia. Certification was expected by 2012 and by autumn 2011 three flight ...
(H80)
* Thrush Model 510 (H80)
Specification (H80)
See also
References
External links
H-Series , GE Aviation
EASA type certification data sheet
* ttp://www.leteckemotory.cz/motory/h80 H80 on LeteckeMotory.cz(cs)
{{GE aeroengines
2000s turboprop engines