HOME

TheInfoList



OR:

An enhanced geothermal system (EGS) generates
geothermal electricity Geothermal power is electrical power generated from geothermal energy. Technologies in use include dry steam power stations, flash steam power stations and binary cycle power stations. Geothermal electricity generation is currently used in 26 ...
without the need for natural
convective Convection is single or multiphase fluid flow that occurs spontaneously due to the combined effects of material property heterogeneity and body forces on a fluid, most commonly density and gravity (see buoyancy). When the cause of the convect ...
hydrothermal resources. Until recently, geothermal power systems have exploited only resources where naturally occurring heat, water, and rock permeability are sufficient to allow energy extraction. However, by far the most geothermal energy within reach of conventional techniques is in dry and impermeable rock. EGS technologies enhance and/or create geothermal resources in this hot dry rock (HDR) through a variety of stimulation methods, including 'hydraulic stimulation'.


Overview

When natural cracks and pores do not allow economic flow rates, the permeability can be enhanced by pumping high-pressure cold water down an
injection well An injection well is a device that places fluid deep underground into porous rock formations, such as sandstone or limestone, or into or below the shallow soil layer. The fluid may be water, wastewater, brine (salt water), or water mixed with indus ...
into the rock. The injection increases the fluid pressure in the naturally fractured rock, triggering shear events that enhance the system's permeability. As long as the injection pressure is maintained, a high matrix permeability is not required, nor are
hydraulic fracturing proppants A proppant is a solid material, typically sand, treated sand or man-made ceramic materials, designed to keep an induced hydraulic fracture open, during or following a fracturing treatment, most commonly for unconventional reservoirs. It is added ...
required to maintain the fractures in an open state. This process is termed hydro-shearing, perhaps to differentiate it from hydraulic tensile fracturing, used in the oil and gas industry, which can create new fractures through the rock in addition to expanding the existing fractures. Water travels through fractures in the rock, capturing the rock's heat until forced out of a second borehole as very hot water. The water's heat is converted into
electricity Electricity is the set of physical phenomena associated with the presence and motion of matter that has a property of electric charge. Electricity is related to magnetism, both being part of the phenomenon of electromagnetism, as described ...
using either a
steam turbine A steam turbine is a machine that extracts thermal energy from pressurized steam and uses it to do mechanical work on a rotating output shaft. Its modern manifestation was invented by Charles Parsons in 1884. Fabrication of a modern steam turbin ...
or a binary power plant system. All of the water, now cooled, is injected back into the ground to heat up again. EGS technologies can function as
baseload The base load (also baseload) is the minimum level of demand on an electrical grid over a span of time, for example, one week. This demand can be met by unvarying power plants, dispatchable generation, or by a collection of smaller intermittent en ...
resources that produce power 24 hours a day. Unlike hydrothermal, EGS may be feasible anywhere in the world, depending on the economic limits of drill depth. Good locations are over deep
granite Granite () is a coarse-grained (phaneritic) intrusive igneous rock composed mostly of quartz, alkali feldspar, and plagioclase. It forms from magma with a high content of silica and alkali metal oxides that slowly cools and solidifies underg ...
covered by a layer of insulating sediments that slow heat loss. An EGS plant is expected to have an economical lifetime of 20–30 years using current technology. EGS systems are currently being developed and tested in Australia, France, Germany,
Japan Japan ( ja, 日本, or , and formally , ''Nihonkoku'') is an island country in East Asia. It is situated in the northwest Pacific Ocean, and is bordered on the west by the Sea of Japan, while extending from the Sea of Okhotsk in the north ...
,
Switzerland ). Swiss law does not designate a ''capital'' as such, but the federal parliament and government are installed in Bern, while other federal institutions, such as the federal courts, are in other cities (Bellinzona, Lausanne, Luzern, Neuchâtel ...
, and the
United States The United States of America (U.S.A. or USA), commonly known as the United States (U.S. or US) or America, is a country primarily located in North America. It consists of 50 states, a federal district, five major unincorporated territo ...
. The largest EGS project in the world is a 25-
megawatt The watt (symbol: W) is the unit of power or radiant flux in the International System of Units (SI), equal to 1 joule per second or 1 kg⋅m2⋅s−3. It is used to quantify the rate of energy transfer. The watt is named after James Watt ...
demonstration plant currently being developed in
Cooper Basin The Cooper Basin is a Permian-Triassic sedimentary geological basin in Australia. The basin is located mainly in the southwestern part of Queensland and extends into northeastern South Australia. It is named after the Cooper Creek which is an ...
, Australia. Cooper Basin has the potential to generate 5,000–10,000 MW.


Research and development


Australia

The Australian government has provided research funding for the development of Hot Dry Rock technology.


European Union

The EU's EGS R&D project at
Soultz-sous-Forêts Soultz-sous-Forêts () is a commune in the Bas-Rhin department in Grand Est in north-eastern France. It is the site of the European Hot Dry Rocks energy research project. Notable people * George Abert, member of the Wisconsin State Assemb ...
, France, has recently connected its 1.5 MW demonstration plant to the grid. The Soultz project has explored the connection of multiple stimulated zones and the performance of triplet well configurations (1 injector/2 producers).
Induced seismicity in Basel Induced seismicity in Basel led to suspension of its hot dry rock enhanced geothermal systems project. A seismic-hazard evaluation was then conducted, resulting in the cancellation of the project in December 2009. Basel, Switzerland sits atop a his ...
led to the cancellation of the EGS project there. The Portuguese government awarded, in December 2008, an exclusive license to Geovita Ltd to prospect and explore geothermal energy in one of the best areas in continental Portugal. An area of about 500 square kilometers is being studied by Geovita together with the Earth Sciences department of the University of Coimbra's Science and Technology faculty, and the installation of an Enhanced Geothermal System (EGS) is foreseen.


South Korea

The Pohang EGS project was started in December 2010, with the goal of producing 1 MW. Deep drilling experience gained under the drilling of the first of two wells from the project, was shared at a conference in 2015. The 2017 Pohang earthquake may have been linked to the activity of the Pohang EGS project. All research activities on the site was stopped in 2018.


United Kingdom

Cornwall is set to host a 3MW demonstration project, based at the Eden Project, that could pave the way for a series of 50-MW commercial-scale geothermal power stations in suitable areas across the country. A commercial-scale project near Redruth is also planned. The plant, which has been granted planning permission, would generate 10 MW of electricity and 55 MW of thermal energy and is scheduled to become operational in 2013–2014.


United States


Early days — Fenton Hill

The first EGS effort — then termed Hot Dry Rock — took place at Fenton Hill, New Mexico with a project run by the federal Los Alamos Laboratory. It was the first attempt to make a deep, full-scale EGS reservoir. The EGS reservoir at Fenton Hill was first completed in 1977 at a depth of about 2.6 km, with rock temperatures of 185°C. In 1979 the reservoir was enlarged with additional hydraulic stimulation and was operated for about 1 year. The results demonstrated that heat could be extracted at reasonable rates from a hydraulically stimulated region of low-permeability hot crystalline rock. In 1986, a second reservoir was prepared for initial hydraulic circulation and heat extraction testing. In a 30-day flow test with a constant reinjection temperature of 20°C, the production temperature steadily increased to about 190°C, corresponding to a thermal power level of about 10MW. Due to budget cuts, further study at Fenton Hill was discontinued.


Working at the edges—using EGS technology to improve hydrothermal resources

EGS funding languished for the next few years, and by the next decade, US efforts focused on the less ambitious goal of improving the productivity of existing hydrothermal resources. In fiscal year 2002, preliminary designs for five projects employing EGS technology were completed and the Coso Hot Springs geothermal field at the US Naval Weapons Air Station in China Lake, California was selected for full-scale development. Two additional projects were selected for preliminary analysis at Desert Peak in Nevada and Glass Mountain in California. Funding for this effort totaled $1.5 million. The effort was continued in 2003 with an additional $3.5 million. In 2009, The US Department of Energy (
USDOE The United States Department of Energy (DOE) is an executive department of the U.S. federal government that oversees U.S. national energy policy and manages the research and development of nuclear power and nuclear weapons in the United States ...
) issued two Funding Opportunity Announcements (FOAs) related to enhanced geothermal systems. Together, the two FOAs offered up to $84 million over six years. The DOE followed up with another FOA in 2009, of stimulus funding from the American Reinvestment and Recovery Act for $350 million, including $80 million aimed specifically at EGS projects,


FORGE

In February 2014, the Department of Energy (DOE) announced the intent to establish "a dedicated subsurface laboratory called the Frontier Observatory for Research in Geothermal Energy (FORGE)" in order to investigate and develop enhanced geothermal technology. In August 2016, it was announced that the proposed sites had been narrowed to two (in Utah and Nevada), expected to be reduced to one the following year. In June 2018 the Department of Energy announced that a location outside of Milford, Utah had been selected to host the FORGE laboratory. Over a five-year period, the University of Utah will receive up to $140 million for cutting edge geothermal research and development. The FORGE site is located 350 km south of Salt Lake City, Utah along the
Colorado Plateau The Colorado Plateau, also known as the Colorado Plateau Province, is a physiographic and desert region of the Intermontane Plateaus, roughly centered on the Four Corners region of the southwestern United States. This province covers an area ...
and
Basin and Range Province The Basin and Range Province is a vast physiographic region covering much of the inland Western United States and northwestern Mexico. It is defined by unique basin and range topography, characterized by abrupt changes in elevation, alternatin ...
transitional zone. The underlying geology is primarily composed of intrusive
Oligocene The Oligocene ( ) is a geologic epoch of the Paleogene Period and extends from about 33.9 million to 23 million years before the present ( to ). As with other older geologic periods, the rock beds that define the epoch are well identified but the ...
through
Miocene The Miocene ( ) is the first geological epoch of the Neogene Period and extends from about (Ma). The Miocene was named by Scottish geologist Charles Lyell; the name comes from the Greek words (', "less") and (', "new") and means "less recent" ...
batholith rock emplaced into
Precambrian The Precambrian (or Pre-Cambrian, sometimes abbreviated pꞒ, or Cryptozoic) is the earliest part of Earth's history, set before the current Phanerozoic Eon. The Precambrian is so named because it preceded the Cambrian, the first period of the P ...
metamorphic (
Gneiss Gneiss ( ) is a common and widely distributed type of metamorphic rock. It is formed by high-temperature and high-pressure metamorphic processes acting on formations composed of igneous or sedimentary rocks. Gneiss forms at higher temperatures an ...
) and
Paleozoic The Paleozoic (or Palaeozoic) Era is the earliest of three geologic eras of the Phanerozoic Eon. The name ''Paleozoic'' ( ;) was coined by the British geologist Adam Sedgwick in 1838 by combining the Greek words ''palaiós'' (, "old") and '' ...
sedimentary rocks. This site is west of the Mineral Mountains and about two km east of the north–south trending Opal Mond Fault (OMF), perpendicular to the east–west trending Negro Mag Fault (NMF). The FORGE is dominated by a fault-fracture mesh system with Opal Mound Fault one of the most active features of the FORGE site. The fault structures vary from steeply dipping faults west of the Mineral Mountains to more gently steeping faults to the east of the FORGE site. The Enhanced Geothermal System (EGS) reservoir of the FORGE site is located approximately between 1525 and 2896 meters (~5,000-10,000 ft) depth and lies between a temperature range of 175-225 degrees Celsius. The EGS reservoir is in rock aged from 8 Ma to 25.4 Ma. Located east of the FORGE site is Roosevelt Hot Springs, a hydrothermal area with temperatures ranging from about 100 degrees Celsius at the surface to over 250 degrees Celsius at a depth of roughly 4000 meters (13,123.4 ft). The temperatures of Roosevelt Hot Springs (RHS) indicate the presence of cooling
magma Magma () is the molten or semi-molten natural material from which all igneous rocks are formed. Magma is found beneath the surface of the Earth, and evidence of magmatism has also been discovered on other terrestrial planets and some natural s ...
in the shallow crust. More than 80 shallow gradient wells (less than 500 m depth) and 20 deeps wells (greater than 500 m depth) have been drilled at and near the FORGE site since the 1970s. Analyses from the shallow well data shows that the encountered granitic rocks are dry, or not producing fluids, but are elevated in temperature. A lack of fluid production by the underlying granitic rocks indicates these rocks are impermeable and that the FORGE site is a classic example of a hot dry rock energy producing system. The thermal grounds of the FORGE site covers most of the northern Milford valley. The highest temperature wells (greater than 80 degrees Celsius) are located east of the OMF above the RHS
hydrothermal Hydrothermal circulation in its most general sense is the circulation of hot water ( Ancient Greek ὕδωρ, ''water'',Liddell, H.G. & Scott, R. (1940). ''A Greek-English Lexicon. revised and augmented throughout by Sir Henry Stuart Jones. with t ...
system. Near-surface profiles (less than 80 m depth) of
temperature gradient A temperature gradient is a physical quantity that describes in which direction and at what rate the temperature changes the most rapidly around a particular location. The temperature gradient is a dimensional quantity expressed in units of degree ...
are similar in central, southern and western sectors of the FORGE site at roughly 70 degrees Celsius per km and do not exceed 270 drees Celsius, even at higher temperature wells west of the FORGE site.


Cornell University — Ithaca, NY

Developing EGS in conjunction with a
district heating District heating (also known as heat networks or teleheating) is a system for distributing heat generated in a centralized location through a system of insulated pipes for residential and commercial heating requirements such as space heating ...
system is a part in
Cornell University Cornell University is a private statutory land-grant research university based in Ithaca, New York. It is a member of the Ivy League. Founded in 1865 by Ezra Cornell and Andrew Dickson White, Cornell was founded with the intention to teac ...
's Climate Action Plan for their Ithaca campus. The project began in 2018 with the preparatory phase to determine feasibility, gain funding and monitor baseline seismicity. The project received $7.2 million in funding from the
USDOE The United States Department of Energy (DOE) is an executive department of the U.S. federal government that oversees U.S. national energy policy and manages the research and development of nuclear power and nuclear weapons in the United States ...
. A test well will be drilled in spring of 2021, at a depth of 2.5 –5 km targeting rock with a temperature > 85 °C. The site is planned to supply 20% of the campus' annual heating load. Promising geological locations for reservoir have been proposed in the Trenton- Black River formation (2.2 km) or in basement crystalline rock (3.5 km).


Summary of EGS projects around the world

EGS technologies use a variety of methods to create additional flow paths inside reservoir rocks. Past EGS projects around the world have used combinations of hydraulic, chemical, thermal, and explosive stimulation methods. EGS projects also include those at the edges of current hydrothermal geothermal sites where drilled wells intersected hot, yet impermeable, reservoir rocks and stimulation methods were used to enhance that permeability. The table below shows both large and small EGS projects around the world.


Induced seismicity

Some induced seismicity is inevitable and expected in EGS, which involves pumping fluids at pressure to enhance or create permeability through the use of hydro-shearing and hydraulic fracturing techniques. Hydro-shear stimulation methods seek to expand and extend the connectivity of the rock's existing fractures to create a better fluid network for the transfer of heat from the rock to the fluid. Seismicity events at the Geysers geothermal field in California have been strongly correlated with injection data. The case of
induced seismicity in Basel Induced seismicity in Basel led to suspension of its hot dry rock enhanced geothermal systems project. A seismic-hazard evaluation was then conducted, resulting in the cancellation of the project in December 2009. Basel, Switzerland sits atop a his ...
merits special mention; it led the city (which is a partner) to suspend the project and conduct a seismic hazard evaluation, which resulted in the cancellation of the project in December 2009. According to the Australian government, risks associated with "hydrofracturing induced seismicity are low compared to that of natural earthquakes, and can be reduced by careful management and monitoring" and "should not be regarded as an impediment to further development of the Hot Rock geothermal energy resource". However, the risks of induced seismicity vary from site to site and should be considered before large scale fluid injection is begun.


EGS

The Geothermal Energy Centre of Excellence at the University of Queensland has been awarded
AUD The Australian dollar ( sign: $; code: AUD) is the currency of Australia, including its external territories: Christmas Island, Cocos (Keeling) Islands, and Norfolk Island. It is officially used as currency by three independent Pacific Isla ...
18.3 million for EGS research, a large portion of which will be used to develop EGS technologies. Research conducted at Los Alamos National Laboratories and Lawrence Berkeley National Laboratories examined the use of supercritical , instead of water, as the geothermal working fluid, with favorable results. has numerous advantages for EGS: :#Greater power output :#Minimized parasitic losses from pumping and cooling :#
Carbon sequestration Carbon sequestration is the process of storing carbon in a carbon pool. Carbon dioxide () is naturally captured from the atmosphere through biological, chemical, and physical processes. These changes can be accelerated through changes in lan ...
:#Minimized water use :# has a much lower tendency to dissolve minerals and other substances than water, which greatly reduces scaling and corrosion of system components is, however, much more expensive and somewhat more difficult to work with than water.


EGS potential in the United States

A 2006 report by
MIT The Massachusetts Institute of Technology (MIT) is a private land-grant research university in Cambridge, Massachusetts. Established in 1861, MIT has played a key role in the development of modern technology and science, and is one of the m ...
, and funded by the
U.S. Department of Energy The United States Department of Energy (DOE) is an executive department of the U.S. federal government that oversees U.S. national energy policy and manages the research and development of nuclear power and nuclear weapons in the United Stat ...
, conducted the most comprehensive analysis to date on the potential and technical status of EGS. The 18-member panel, chaired by Professor Jefferson Tester of MIT, reached several significant conclusions: # Resource size: The report calculated the United States total EGS resources from 3–10 km of depth to be over 13,000  zettajoules, of which over 200 ZJ would be extractable, with the potential to increase this to over 2,000 ZJ with technology improvements — sufficient to provide all the world's current energy needs for several
millennia A millennium (plural millennia or millenniums) is a period of one thousand years, sometimes called a kiloannum (ka), or kiloyear (ky). Normally, the word is used specifically for periods of a thousand years that begin at the starting point (ini ...
. The report found that total geothermal resources, including hydrothermal and geo-pressured resources, to equal 14,000 ZJ — or roughly 140,000 times the total U.S. annual primary energy use in 2005. # Development potential: With an R&D investment of $1 billion over 15 years, the report estimated that 100 GWe (gigawatts of electricity) or more could be installed by 2050 in the United States. The report further found that "recoverable" resources (accessible with today's technology) were between 1.2 and 12.2 TW for the conservative and moderate recovery scenarios respectively. # Cost: The report found that EGS could be capable of producing electricity for as low as 3.9 cents/kWh. EGS costs were found to be sensitive to four main factors: ## Temperature of the resource ## Fluid flow through the system measured in liters/second ## Drilling costs ## Power conversion efficiency


Hot dry rock (HDR)

Hot dry rock (HDR) is an extremely abundant source of
geothermal energy Geothermal energy is the thermal energy in the Earth's crust which originates from the formation of the planet and from radioactive decay of materials in currently uncertain but possibly roughly equal proportions. The high temperature and pres ...
that is difficult to access. A vast store of thermal energy is contained within hot – but essentially dry and impervious crystalline
basement A basement or cellar is one or more floors of a building that are completely or partly below the ground floor. It generally is used as a utility space for a building, where such items as the furnace, water heater, breaker panel or fuse box ...
rocks found almost everywhere deep beneath Earth's surface. A method for the extraction of useful amounts of geothermal energy from HDR originated at the
Los Alamos National Laboratory Los Alamos National Laboratory (often shortened as Los Alamos and LANL) is one of the sixteen research and development laboratories of the United States Department of Energy (DOE), located a short distance northwest of Santa Fe, New Mexico, in ...
in 1970, and Laboratory researchers were awarded a US patent covering it. This technology has been tested extensively with multiple deep wells drilled in several field areas around world including the US, Japan, Australia, France, and the UK and investment of billions of research funds. It continues to be the focus, along with a related technique called Enhanced Geothermal System (EGS), for sizable government-led research studies involving costly deep drilling and rock studies. Thermal energy has been recovered in reasonably sustainable tests over periods of years and in some cases electrical power generation was also achieved. However no commercial projects are ongoing or likely due to the high cost and limited capacity of the engineered reservoirs, associated wells, and pumping systems. Commonly tests have opened just one or more fractures such that the reservoir surface heat exchange areas are limited. For this technology to successfully compete with other energy sources, drilling costs would have to drop drastically or new approaches that result in much more extensive, complex, and higher rate flow paths through actual fracture networks would have to be established. The enthusiasm in the research community is justified by the vast extent of the energy supply and the low environmental impact of the method, however significant breakthroughs will be required to make this a commercial energy resource.


Overview

Although often confused with the relatively limited hydrothermal resource already commercialized to a large extent, HDR geothermal energy is very different. Whereas hydrothermal energy production can exploit hot fluids already in place in
Earth's crust Earth's crust is Earth's thin outer shell of rock, referring to less than 1% of Earth's radius and volume. It is the top component of the lithosphere, a division of Earth's layers that includes the crust and the upper part of the mantle. The ...
, an HDR system (consisting of the pressurized HDR reservoir, the boreholes drilled from the surface, and the surface injection pumps and associated plumbing) recovers Earth's heat from hot but dry regions via the closed-loop circulation of pressurized fluid. This fluid, injected from the surface under high pressure, opens pre-existing joints in the basement rock, creating a man-made reservoir which can be as much as a cubic kilometer in size. The fluid injected into the reservoir absorbs thermal energy from the high-temperature rock surfaces and then conveys the heat to the surface for practical use.


History

The idea of deep hot dry rocks heat mining was described by
Konstantin Tsiolkovsky Konstantin Eduardovich Tsiolkovsky (russian: Константи́н Эдуа́рдович Циолко́вский , , p=kənstɐnʲˈtʲin ɪdʊˈardəvʲɪtɕ tsɨɐlˈkofskʲɪj , a=Ru-Konstantin Tsiolkovsky.oga; – 19 September 1935) ...
(1898), Charles Parsons (1904), and
Vladimir Obruchev Vladimir Afanasyevich Obruchev (russian: Влади́мир Афана́сьевич О́бручев; , Klepenino near Rzhev, Tver Oblast, Russian Empire – June 19, 1956, Moscow, USSR) was a Russian and Soviet geologist who specialized ...
(1920). In 1963 in
Paris Paris () is the capital and most populous city of France, with an estimated population of 2,165,423 residents in 2019 in an area of more than 105 km² (41 sq mi), making it the 30th most densely populated city in the world in 2020. S ...
, a geothermal heating system that used the heat of natural fractured rocks was built. The Fenton Hill project was the first system for extracting HDR geothermal energy from an artificial formed reservoir; it was created in 1977.


Technology


Planning and control

As the reservoir is formed by the pressure-dilation of the joints, the elastic response of the surrounding rock mass results in a region of tightly compressed, sealed rock at the periphery—making the HDR reservoir totally confined and contained. Such a reservoir is therefore fully engineered, in that the physical characteristics (size, depth at which it is created) as well as the operating parameters (injection and production pressures, production temperature, etc.) can be pre-planned and closely controlled. On the other hand the tight compression and confined nature of the reservoir severely limits that amount and the rate at which energy can be extracted.


Drilling and pressurization

As described by Brown, an HDR geothermal energy system is developed, first, by using conventional drilling to access a region of deep, hot basement rock. Once it has been determined the selected region contains no open faults or joints (by far the most common situation), an isolated section of the first borehole is pressurized at a level high enough to open several sets of previously sealed joints in the rock mass. By continuous pumping (hydraulic stimulation), a very large region of stimulated rock is created (the HDR reservoir) which consists of an interconnected array of joint flow paths within the rock mass. The opening of these flow paths causes movement along the pressure-activated joints, generating seismic signals (microearthquakes). Analysis of these signals yields information about the location and dimensions of the reservoir being developed.


Production wells

Typically, an HDR reservoir forms in the shape of an
ellipsoid An ellipsoid is a surface that may be obtained from a sphere by deforming it by means of directional scalings, or more generally, of an affine transformation. An ellipsoid is a quadric surface;  that is, a surface that may be defined as the z ...
, with its longest axis
orthogonal In mathematics, orthogonality is the generalization of the geometric notion of ''perpendicularity''. By extension, orthogonality is also used to refer to the separation of specific features of a system. The term also has specialized meanings in ...
to the least principal Earth stress. This pressure-stimulated region is then accessed by two production wells, drilled to intersect the HDR reservoir near the elongated ends of the stimulated region. In most cases, the initial borehole becomes the injection well for the three-well, pressurized water-circulating system.


Operation

In operation, fluid is injected at pressures high enough to hold open the interconnected network of joints against the Earth stresses, and to effectively circulate fluid through the HDR reservoir at a high rate. During routine energy production, the injection pressure is maintained at just below the level that would cause further pressure-stimulation of the surrounding rock mass, in order to maximize energy production while limiting further reservoir growth. However, the limited reservoir size limits reservoir energy. Meanwhile high pressure operation adds significant cost to piping and pumping systems.


Productivity

The volume of the newly created array of opened joints within the HDR reservoir is much less than 1% of the volume of the pressure-stimulated rock mass. As these joints continue to pressure and cooling -dilate, the overall flow impedance across the reservoir is reduced, leading to a high thermal productivity. If the cooling leads to cooling fractures in a way that exposes more rock then it is possible that these reservoirs may improve over time. To date reservoir energy growth is only reported to come from new expensive high pressure well stimulation efforts.


Feasibility studies

The feasibility of mining heat from the deep Earth was proven in two separate HDR reservoir flow demonstrations—each involving about one year of circulation—conducted by the Los Alamos National Laboratory between 1978 and 1995. These groundbreaking tests took place at the Laboratory's Fenton Hill HDR test site in the
Jemez Mountains The Jemez Mountains are a group of mountains in Rio Arriba, Sandoval, and Los Alamos counties, New Mexico, United States. Numerous Puebloan Indian tribes have lived in the Jemez Mountains region since before the Spanish arrived in New Mexico. ...
of north-central
New Mexico ) , population_demonym = New Mexican ( es, Neomexicano, Neomejicano, Nuevo Mexicano) , seat = Santa Fe, New Mexico, Santa Fe , LargestCity = Albuquerque, New Mexico, Albuquerque , LargestMetro = Albuquerque metropolitan area, Tiguex , Offi ...
, at depths of over and rock temperatures in excess of 180 °C.Brown, D. W., Duchane, D. V., Heiken, G., and Hriscu, V. T., 2012. ''Mining the Earth’s Heat: Hot Dry Rock Geothermal Energy,'' Springer-Verlag, Berlin and Heidelberg, 655 pp The results of these tests demonstrated conclusively the engineering viability of the revolutionary new HDR geothermal energy concept. The two separate reservoirs created at Fenton Hill are still the only truly confined HDR geothermal energy reservoirs flow-tested anywhere in the world. Although these tests demonstrated that HDR systems could be constructed, the flow rates and energy extractions rates did not justify the cost of the wells.


Fenton Hill tests


Phase I

The first HDR reservoir tested at Fenton Hill, the Phase I reservoir, was created in June 1977 and then flow-tested for 75 days, from January to April 1978, at a thermal power level of 4 MW. The final water loss rate, at a surface injection pressure of , was (2% of the injection rate). This initial reservoir was shown to essentially consist of a single pressure-dilated, near-vertical joint, with a vanishingly small flow impedance of . The initial Phase I reservoir was enlarged in 1979 and further flow-tested for almost a year in 1980.Brown, D. W., and Duchane, D. V., 1999. "Scientific progress on the Fenton Hill HDR project since 1983,” Geothermics 28(4/5) special issue: Hot Dry Rock/Hot Wet Rock Academic Review (Abe, H., Niitsuma, H., and Baria, R., eds.), pp. 591–601 Of greatest importance, this flow test confirmed that the enlarged reservoir was also confined, and exhibited a low water loss rate of 6 gpm. This reservoir consisted of the single near-vertical joint of the initial reservoir (which, as noted above, had been flow-tested for 75 days in early 1978) augmented by a set of newly pressure-stimulated near-vertical joints that were somewhat oblique to the strike of the original joint.


Phase II

A deeper and hotter HDR reservoir (Phase II) was created during a massive hydraulic fracturing (MHF) operation in late 1983. It was first flow-tested in the spring of 1985, by an initial closed-loop flow test (ICFT) that lasted a little over a month. Information garnered from the ICFT provided the basis for a subsequent long-term flow test (LTFT), carried out from 1992 to 1995. The LTFT comprised several individual steady-state flow runs, interspersed with numerous additional experiments. In 1992–1993, two steady-state circulation periods were implemented, the first for 112 days and the second for 55 days. During both tests, water was routinely produced at a temperature of over 180 °C and a rate of , resulting in continuous thermal energy production of approximately 4 MW. Over this time span, the reservoir pressure was maintained (even during shut-in periods) at a level of about 15 MPa. Beginning in mid-1993, the reservoir was shut in for a period of nearly two years and the applied pressure was allowed to drop to essentially zero. In the spring of 1995, the system was re-pressurized and a third continuous circulation run of 66 days was conducted. Remarkably, the production parameters observed in the two earlier tests were rapidly re-established, and steady-state energy production resumed at the same level as before. Observations during both the shut-in and operational phases of all these flow-testing periods provided clear evidence that the rock at the boundary of this man-made reservoir had been compressed by the pressurization and resultant expansion of the reservoir region. As a result of the LTFT, water loss was eliminated as a major concern in HDR operations. Over the period of the LTFT, water consumption fell to just 7% of the quantity of water injected; and data indicated it would have continued to decline under steady-state circulation conditions. Dissolved solids and gases in the produced fluid rapidly reached equilibrium values at low concentrations (about one-tenth the salinity of sea water), and the fluid remained geochemically benign throughout the test period. Routine operation of the automated surface plant showed that HDR energy systems could be run using the same economical staffing schedules that a number of unmanned commercial hydrothermal plants already employ.


Test results

The Fenton Hill tests clearly demonstrated advantages of a fully engineered HDR reservoir over naturally occurring hydrothermal resources, including EGS. With all the essential physical characteristics of the reservoir—including rock volume, fluid capacity, temperature, etc.—established during the engineered creation of the reservoir zone, and the entire reservoir volume enclosed by a hyperstressed periphery of sealed rock, any variations in operating conditions are totally determined by intentional changes made at the surface. In contrast, a natural hydrothermal “reservoir”—which is essentially open and therefore unconfined(having boundaries that are highly variable)—is inherently subject to changes in natural conditions. On the other hand the less confined, more complex, lower pressure, and more pervasively fractured natural systems support much higher well flow rates and low cost development of energy generation. Another advantage of an HDR reservoir is that its confined nature makes it highly suitable for load-following operations, whereby the rate of energy production is varied to meet the varying demand for electric power—a process that can greatly increase the economic competitiveness of the technology. This concept was evaluated near the end of the Phase II testing period, when energy production was increased by 60% for 4 hours each day, by a programmed vent-down of the high-pressure reservoir regions surrounding the production borehole. Within two days it became possible to computerize the process, such that production was automatically increased and decreased according to the desired schedule for the rest of the test period. The transitions between the two production levels took less than 5 minutes, and at each level steady-state production was consistently maintained. Such load-following operations could not be implemented in a natural hydrothermal system or even in an EGS system because of the unconfined volume and boundary conditions. Load following almost never improves economics for geothermal development because the fuel cost is effectively paid up front, so delaying use just hurts the economics. Normal geothermal systems have also (by necessity) been applied to follow loads but this kind of generation increases maintenance costs and generally reduces revenue (in spite of the higher prices for some of the load). The experiments at Fenton Hill have clearly demonstrated that HDR technology is unique, not only with respect to how the pressurized reservoir is created and then circulated, but also because of the management flexibility it offers. It has in common with normal hydrothermal technology only that both are based on wells that produce hot water that runs generators.


Soultz tests

In 1986 the HDR system project of France and Germany in
Soultz-sous-Forêts Soultz-sous-Forêts () is a commune in the Bas-Rhin department in Grand Est in north-eastern France. It is the site of the European Hot Dry Rocks energy research project. Notable people * George Abert, member of the Wisconsin State Assemb ...
was started. In 1991 wells were drilled to 2.2 km depth and were stimulated. However, the attempt to create a reservoir was unsuccessful as high water losses was observed. In 1995 wells were deepened to 3.9 km and stimulated. A reservoir was created successfully in 1997 and a four-month circulation test with flow rate without water loss was attained. In 2003 wells were deepened to 5.1 km. Stimulations were done to create a third reservoir, during circulation tests in 2005-2008 water was produced at a temperature of about 160 °C with low water loss. Construction of a power plant was begun. The power plant started to produce electricity in 2016, it was installed with a gross capacity of 1.7 MWe. The 1.7 MW test plant is purely a demonstration plant. In comparison normal geothermal power plant development typically involves initial plants from 10 to 100 MW. These plants can be commercially successful but are much cheaper than HDR system, with shallower wells, that produce orders of magnitude more energy, into inexpensive pipelines and power plants. It seems possible that breakthroughs will occur that allow us to access the tremendous amounts of stored heat energy in deep rock using HDR technology but very few breakthroughs appear to be on the horizon especially when compared to the rapid progress being made on much lower risk solar/battery combinations.


Unconfirmed systems

There have been numerous reports of the testing of unconfined geothermal systems pressure-stimulated in crystalline basement rock: for instance at the Rosemanowes quarry in Cornwall, England; at the Hijiori and Ogachi
caldera A caldera ( ) is a large cauldron-like hollow that forms shortly after the emptying of a magma chamber in a volcano eruption. When large volumes of magma are erupted over a short time, structural support for the rock above the magma chamber i ...
s in Japan; and in the
Cooper Basin The Cooper Basin is a Permian-Triassic sedimentary geological basin in Australia. The basin is located mainly in the southwestern part of Queensland and extends into northeastern South Australia. It is named after the Cooper Creek which is an ...
, Australia. However, all these “engineered” geothermal systems, while developed under programs directed toward the investigation of HDR technologies, have proven to be open—as evidenced by the high water losses observed during pressurized circulation. In essence, they are all EGS or hydrothermal systems, not true HDR reservoirs.


Related terminology


Enhanced geothermal systems

The EGS concept was first described by Los Alamos researchers in 1990, at a geothermal symposium sponsored by the
United States Department of Energy The United States Department of Energy (DOE) is an executive department of the U.S. federal government that oversees U.S. national energy policy and manages the research and development of nuclear power and nuclear weapons in the United States ...
(DOE)—many years before the DOE coined the term EGS in an attempt to emphasize the geothermal aspect of heat mining rather than the unique characteristics of HDR.


HWR versus HDR

Hot Wet Rock (HWR) hydrothermal technology makes use of hot fluids found naturally in basement rock; but such HWR conditions are rare. By far the bulk of the world's geothermal resource base (over 98%) is in the form of basement rock that is hot but dry—with no naturally available water. This means that HDR technology is applicable almost everywhere on Earth (hence the claim that HDR geothermal energy is ubiquitous). On the other hand an uneconomic resource is actually just energy storage and not useful. Typically, the temperature in those vast regions of the accessible crystalline basement rock increases with depth. This geothermal gradient, which is the principal HDR resource variable, ranges from less than 20 °C/km to over 60 °C/km, depending upon location. The concomitant HDR economic variable is the cost of drilling to depths at which rock temperatures are sufficiently high to permit the development of a suitable reservoir. The advent of new technologies for drilling hard crystalline basement rocks, such as new PDC (polycrystalline diamond compact) drill bits, drilling turbines or fluid-driven percussive technologies (such as Mudhammer Souchal, R., 2017, High-Power Mudhammer Drilling: A promising solution for deep geothermal reservoirs, Geotherm Deep Geothermal Energy Congress proceedings) may significantly improve HDR economics in the near future.


Further reading

A definitive book on HDR development, including a full account of the experiments at Fenton Hill, was published by Springer-Verlag in April 2012.


Glossary

* DOE, Department of Energy (United States) * EGS, Enhanced geothermal system * HDR, Hot dry rock * HWR, Hot wet rock * ICFT, Initial closed-loop flow test * LTFT, Long-term flow test * MHF, Massive hydraulic fracturing * PDC, Polycrystalline diamond compact (drill bit)


See also

*
Caprock Caprock or cap rock is a more resistant rock type overlying a less resistant rock type,Kearey, Philip (2001). ''Dictionary of Geology'', 2nd ed., Penguin Reference, London, New York, etc., p. 41.. . analogous to an upper crust on a cake that is ha ...
*
Drilling Drilling is a cutting process where a drill bit is spun to cut a hole of circular cross-section in solid materials. The drill bit is usually a rotary cutting tool, often multi-point. The bit is pressed against the work-piece and rotated at ...
*
Drilling rig A drilling rig is an integrated system that drills wells, such as oil or water wells, or holes for piling and other construction purposes, into the earth's subsurface. Drilling rigs can be massive structures housing equipment used to drill w ...
* Geothermal energy exploration in Central Australia *
Geothermal energy in the United States Geothermal energy was first used for electric power production in the United States in 1960. The Geysers in Sonoma and Lake counties, California was developed into the largest geothermal steam electrical plant in the world, at 1,517 megawatt ...
*
Geothermal exploration Geothermal exploration is the exploration of the subsurface in search of viable active geothermal regions with the goal of building a geothermal power plant, where hot fluids drive turbines to create electricity. Exploration methods include a bro ...
*
Iceland Deep Drilling Project The Iceland Deep Drilling Project (IDDP) is a geothermal project established in 2000 by a consortium of the National Energy Authority of Iceland (Orkustofnun/OS) and four of Iceland's leading energy companies: Hitaveita Sudurnesja (HS), Landsvir ...
*
Laser drilling Laser drilling is the process of creating thru-holes, referred to as “popped” holes or “percussion drilled” holes, by repeatedly pulsing focused laser energy on a material. The diameter of these holes can be as small as 0.002” (~50 μm). ...
* Rosemanowes Quarry


References


External links

*
EERE The Office of Energy Efficiency and Renewable Energy (EERE) is an office within the United States Department of Energy. Formed from other energy agencies after the 1973 energy crisis, EERE is led by the Assistant Secretary of Energy Efficiency an ...
: *
Geothermal basics
*
Hot Dry Rock (HDR)
*

*
NREL The National Renewable Energy Laboratory (NREL) in the US specializes in the research and development of renewable energy, energy efficiency, energy systems integration, and sustainable transportation. NREL is a federally funded research and ...

Interactive Data Map - Geothermal Prospector Tool
(see Geothermal - Deep Enhanced Geothermal Potential)
Geothermal investment rocks says DLA Phillips Fox

MEGSorg

EGS
{{DEFAULTSORT:Enhanced Geothermal System Power station technology Geothermal energy Machining