A circulation control wing (CCW) is a form of high-lift device for use on the main wing of an aircraft to increase the maximum lift coefficient. CCW technology has been in the research and development phase for over sixty years.

Blown flaps Blown flaps, or jet flaps, are powered aerodynamic high-lift devices used on the wings of certain aircraft to improve their low-speed flight characteristics. They use air blown through nozzles to shape the airflow over the rear edge of the wing, d ...

were an early example of CCW. The CCW works by increasing the velocity of the airflow over the leading edge and trailing edge of a specially designed aircraft wing using a series of blowing slots that eject jets of high-pressure air. The wing has a rounded trailing edge to tangentially eject the air through the

Coandă effect The Coandă effect ( or ) is the tendency of a fluid jet to stay attached to a convex surface. ''Merriam-Webster'' describes it as "the tendency of a jet of fluid emerging from an orifice to follow an adjacent flat or curved surface and to ent ...

thus causing lift. The increase in velocity of the airflow over the wing also adds to the lift force through conventional

airfoil An airfoil (American English) or aerofoil (British English) is the cross-sectional shape of an object whose motion through a gas is capable of generating significant lift, such as a wing, a sail, or the blades of propeller, rotor, or turbine. ...

lift production.

Purpose

The main purpose of the circulation control wing is to increase the

lifting force A fluid flowing around an object exerts a force on it. Lift is the component of this force that is perpendicular to the oncoming flow direction. It contrasts with the drag force, which is the component of the force parallel to the flow directi ...

of an aircraft at times when large lifting forces at low speeds are required, such as takeoff and landing. Wing flaps and

slats Super Low Altitude Test Satellite (SLATS) or Tsubame was a JAXA satellite intended to demonstrate operations in very low Earth orbit (VLEO, below 200 km), using ion engines to counteract aerodynamic drag from the Earth's atmosphere which i ...

are currently used during landing on almost all aircraft and on takeoff by larger jets. While flaps and slats are effective in increasing lift, they do so at a high cost of drag. The benefit of the circulation control wing is that no extra drag is created and the lift coefficient is greatly increased. It is being claimed that such a system could increase the maximum coefficient of lift in the landing configuration of a Boeing 737 by 150% to 250%, thus reducing approach speeds by 35% to 45% and landing distances by 55% to 75%; such advances in wing design could allow for a dramatic reduction in the size of the wing of a large jet airplane.

Other uses

Increased maneuverability

At low speeds, an aircraft has reduced airflow over the wing and vertical stabilizer. This causes the control surfaces ( ailerons, elevators and rudder) to be less effective. The CCW system increases the airflow over these surfaces and consequently can allow much higher maneuverability at low speeds.{{cite web, url=http://www.airspacemag.com/issues/2007/april-may/custer_channel_wing.php?page=2, archive-url=https://archive.today/20120716165638/http://www.airspacemag.com/issues/2007/april-may/custer_channel_wing.php?page=2, url-status=dead, archive-date=2012-07-16, title=Circulation Control Technology, accessdate=2007-12-15 However, if one of the CCW systems should fail at low speed, the affected wing is likely to stall which could result in an inescapable

spin Spin or spinning most often refers to: * Spinning (textiles), the creation of yarn or thread by twisting fibers together, traditionally by hand spinning * Spin, the rotation of an object around a central axis * Spin (propaganda), an intentionally b ...

. Finally, the CCW system could be used on multi-engine aircraft in the result of an engine failure to cancel the

asymmetric forces Asymmetric may refer to: *Asymmetry in geometry, chemistry, and physics Computing *Asymmetric cryptography, in public-key cryptography *Asymmetric digital subscriber line, Internet connectivity *Asymmetric multiprocessing, in computer architectur ...

from the loss of power on one wing.

Noise reduction

The use of a CCW system eliminates the need for large complex components in the free stream such as flaps and

, greatly reducing the noise pollution of modern aircraft. Additionally, a much shorter ground roll coupled with steeper climb outs and approaches reduces the ground noise footprint. The blowing slots themselves will contribute very little to the noise of the aircraft as each slot is just a fraction of an inch wide.

Powering the wing

The main problem with the circulation control wing is the need for high energy air to be blown over the wing's surface. Such air is often bled from the engine; however, this drastically reduces engine power production and consequently counteracts the purpose of the wing. Other options are taking the exhaust gases (which must first be cooled) or using multiple, lightweight gas generators, which are separate from the main aircraft engines.

Purpose

Other uses

Increased maneuverability

Noise reduction

Powering the wing

References

See also