BAe Sea Harrier FRS.1

The British Aerospace Sea Harrier is a naval short take-off and vertical landing/ vertical take-off and landing jet fighter, reconnaissance and attack aircraft. It is the second member of the Harrier family developed. It first entered service with the Royal Navy in April 1980 as the Sea Harrier FRS1 and became informally known as the "''Shar''". Unusual in an era in which most naval and land-based air superiority fighters were large and supersonic, the principal role of the subsonic Sea Harrier was to provide air defence for Royal Navy task groups centred around the aircraft carriers.

The Sea Harrier served in the Falklands War and the Balkans conflicts; on all occasions it mainly operated from aircraft carriers positioned within the conflict zone. Its usage in the Falklands War was its most high profile and important success, when it was the only fixed-wing fighter available to protect the British Task Force. The Sea Harriers shot down 20 enemy aircraft during the conflict; 2 Sea Harriers were lost to enemy ground fire. They were also used to launch ground attacks in the same manner as the Harriers operated by the Royal Air Force.

The Sea Harrier was marketed for sales abroad, but India was the only other operator after attempts to sell the aircraft to Argentina and Australia were unsuccessful. A second, updated version for the Royal Navy was made in 1993 as the Sea Harrier FA2, improving its air-to-air abilities and weapons compatibilities, along with a more powerful engine; this version was manufactured until 1998. The aircraft was withdrawn from service early by the Royal Navy in 2006, but remained in service with the Indian Navy for a further decade until its retirement in 2016.

Development

In the post-World War II era, the Royal Navy began contracting in size. By 1960, the last battleship, , was retired from the Navy, having been in service for less than fifteen years. In 1966 the planned CVA-01 class of large aircraft carriers was cancelled. During this time, requirements within the Royal Navy began to form for a vertical and/or short take-off and landing (V/STOL) carrier-based interceptor to replace the de Havilland Sea Vixen. The first V/STOL tests on a ship began with a Hawker Siddeley P.1127 landing on in 1963.

A second concept for the future of naval aviation emerged in the early 1970s when the first of a new class of "through deck cruisers" was planned. These were very carefully and politically designated as cruisers, deliberately avoiding the term "aircraft carrier"Nordeen 2006, p. 11. to increase the chances of funding in a hostile political climate against expensive capital ships.Grove 1987, pp. 319–320. The resulting carriers were considerably smaller than the CVA-01 design, but came to be widely recognised as aircraft carriers.Moore 1987, pp. 22.Moore RN, Capt. John E. ''Warships of the Royal Navy''. Jane's Publishing, 1981, . Almost immediately upon their construction, a ski-jump was added to the end of the 170-metre deck, enabling the carriers to effectively operate a small number of V/STOL jets.

The naval staff were able to build an effective political argument for acquiring V/STOL aircraft, on the grounds that anti-submarine groups operating in the NATO Atlantic area, the intended main role of the through deck cruisers, would be vulnerable to attack by Soviet anti-ship missiles. These could be launched at a considerable distance by a submarine or surface ship, but needed to be guided in by a maritime patrol aircraft; fast jets carried onboard would be able to shoot these down. No mention was made of the other capabilities that these aircraft would have.

The Royal Air Force's Hawker Siddeley Harrier GR1s had entered service in April 1969. A navalised variant of the Harrier was developed by Hawker Siddeley to serve on the upcoming ships; this became the Sea Harrier. In 1975, the Royal Navy ordered 24 Sea Harrier ''FRS.1'' (standing for 'Fighter, Reconnaissance, Strike'Bull 2004, p. 120.) aircraft, the first of which entered service in 1978. During this time Hawker Siddeley became part of British Aerospace through nationalisation in 1977. By the time the prototype Sea Harrier was flown at Dunsfold on 20 August 1978, the order had been increased to 34. The Sea Harrier was declared operational in 1981 on board the first ''Invincible''-class ship , and further aircraft joined the ageing aircraft carrier later that year.

In 1984, approval was given to upgrade of the fleet to ''FRS.2'' standard (later known as ''FA2'') following the lessons learned during the aircraft's deployment in the 1982 Falklands War. The first flight of the prototype took place in September 1988 and a contract was signed for 29 upgraded aircraft in December that year. In 1990, the Navy ordered 18 new-build FA2s, at a unit cost of around £12 million, four further upgraded aircraft were ordered in 1994. The first aircraft was delivered on 2 April 1993.

Design

The Sea Harrier is a subsonic aircraft designed for strike, reconnaissance and fighter roles.Jenkins 1998, p. 52. It features a single Rolls-Royce Pegasus turbofan engine with two intakes and four vectorable nozzles. It has two landing gear on the fuselage and two outrigger landing gear on the wings. The Sea Harrier is equipped with four wing and three fuselage pylons for carrying weapons and external fuel tanks.Spick 2000, pp. 366–370, 387–392. Use of the ski jump allowed the aircraft to take off from a short flight deck with a heavier payload than would otherwise be possible, although it can also take off like a conventional loaded fighter without thrust vectoring from a normal airport runway.Bull 2004, p. 121.

The Sea Harrier was largely based on the Harrier GR3, but was modified to have a raised cockpit with a " bubble" canopy for greater visibility, and an extended forward fuselage to accommodate the Ferranti Blue Fox radar. Parts were changed to use corrosion resistant alloys, or coatings were added, to protect against the marine environment.Jenkins 1998, pp. 51–55. After the Falklands War, the Sea Harrier was fitted with the Sea Eagle anti-ship missile.

The Blue Fox radar was seen by some critics as having comparatively low performance for what was available at the time of procurement. The Sea Harrier FA2 was fitted with the Blue Vixen radar, which was described as one of the most advanced pulse doppler radar systems in the world; The Blue Vixen formed the basis of the Eurofighter Typhoon's CAPTOR radar. The Sea Harrier FA2 carried the AIM-120 AMRAAM missile, the first UK aircraft with this capability. An upgraded model of the Pegasus engine, the Pegasus Mk 106, was used in the Sea Harrier FA2. In response to the threat of radar-based anti aircraft weapons electronic countermeasures were added. Other improvements included an increased air-to-air weapons load, look-down radar, increased range, and improved cockpit displays.

The Sea Harrier's cockpit includes a conventional centre stick arrangement and left-hand throttle. In addition to normal flight controls, the Harrier has a lever for controlling the direction of the four vectorable nozzles. The nozzles point rearward with the lever in the forward position for horizontal flight. With the lever back, the nozzles point downward for vertical takeoff or landing.Markman and Holder 2000, pp. 74–77.Jenkins 1998, p. 25. The utility of the vertical landing capability of the Sea Harrier was demonstrated in an incident on 6 June 1983, when Sub Lieutenant Ian Watson lost contact with the aircraft carrier and had to land Sea Harrier ZA176 on the foredeck of the Spanish cargo ship ''Alraigo''.

In 1998, the UK Defence Evaluation and Research Agency test-fitted an FA2 with AVPRO UK Ltd's Exint pods, small underwing compartments intended to be used for deployment of special forces.

In 2005, a Sea Harrier was modified with an ' Autoland' system to allow the fighter to perform a safe vertical landing without any pilot interaction. Despite the pitching of a ship posing a natural problem, the system was designed to be aware of such data, and successfully performed a landing at sea in May 2005.

Operational history

Royal Navy

Entry into service

The first three Sea Harriers were a development batch and were used for clearance trials. The first production aircraft was delivered to RNAS Yeovilton in 1979 to form an Intensive Flying Trials Unit, 700A Naval Air Squadron. In March 1980 the Intensive Flying Trials Unit became 899 Naval Air Squadron and would act as the landborne headquarters unit for the type. The first operational squadron, 800 Naval Air Squadron, was also formed in March 1980 initially to operate from HMS ''Invincible'' before it transferred to HMS ''Hermes''. In January 1981, a second operation squadron 801 Naval Air Squadron was formed to operate from HMS ''Invincible''.

Falklands War

Sea Harriers took part in the Falklands War ( es, Guerra de las Malvinas) of 1982, flying from HMS ''Invincible'' and HMS ''Hermes''. The Sea Harriers performed the primary air defence role with a secondary role of ground attack; the RAF Harrier GR3 provided the main ground attack force. A total of 28 Sea Harriers and 14 Harrier GR3s were deployed in the theatre. The Sea Harrier squadrons shot down 20 Argentine aircraft in air-to-air combat with no air-to-air losses, although two Sea Harriers were lost to ground fire and four to accidents. Out of the total Argentine air losses, 28% were shot down by Harriers. One Sea Harrier alone, flown by RAF Flight Lieutenant David Morgan, shot down two Skyhawks in a single encounter.

A number of factors contributed to the failure of the Argentinian fighters to shoot down a Sea Harrier. Although the Mirage III and Dagger jets were faster, the Sea Harrier was considerably more manoeuvrable. Moreover, the Harrier employed the latest AIM-9L Sidewinder missiles and the Blue Fox radar. Contrary to contemporary reports that " viffing" proved decisive in dogfights, the maneuver was not used by RN pilots in the Falklands as it was only used in emergencies against enemies unfamiliar with the aircraft. The British pilots noticed Argentinian pilots occasionally releasing weapons outside of their operating parameters. This is now thought to have been Mirages ( IAI Neshers) releasing external fuel tanks to improve their maneuverability for air combat.

British aircraft received fighter control from warships in San Carlos Water, although its effectiveness was limited by their being stationed close to the islands, which severely limited the effectiveness of their radar. The differences in tactics and training between 800 Squadron and 801 Squadron have been a point of criticism, suggesting that the losses of several ships were preventable had Sea Harriers from ''Hermes'' been used more effectively.

Both sides' aircraft were operating in adverse conditions. Argentine aircraft were forced to operate from the mainland because airfields on the Falklands were only suited for propeller-driven aircraft. The bombing of Port Stanley airport by a British Vulcan bomber was also a consideration in the Argentinians' decision to operate them from afar. As most Argentine aircraft lacked in-flight refuelling capability, they were forced to operate at the limit of their range. The Sea Harriers also had limited fuel reserves due to the tactical decision to station the British carriers out of Exocet missile range and the dispersal of the fleet. The result was that an Argentine aircraft only had five minutes over the islands to search for and attack an objective, while a Sea Harrier could stay near to 30 minutes waiting in the Argentine approach corridors and provide Combat Air Patrol coverage for up to an hour.

The Sea Harriers were outnumbered by the available Argentinian aircraft, and were on occasion decoyed away by the activities of the '' Escuadrón Fénix'' or civilian jet aircraft used by the Argentine Air Force. They had to operate without a fleet airborne early warning and control (AEW&C) system that would have been available to a full NATO fleet in which the Royal Navy had expected to operate, which was a significant weakness in the operational environment. It is now known that British units based in Chile did provide early radar warning to the Task Force. Nonetheless, the lack of AEW&C cover resulted in air superiority as opposed to air supremacy; the Sea Harriers could not prevent Argentine attacks during day or night nor could they completely stop the daily C-130 Hercules transports' night flights to the islands.

Operations in the 1990s

The Sea Harrier saw action in war again when it was deployed in the 1992–1995 Bosnian War. It launched raids on Serb forces and provided air-support for the international taskforce units conducting Operations Deny Flight and Deliberate Force against the Army of Republika Srpska. On 16 April 1994, a Sea Harrier of the 801 Naval Air Squadron, operating from the aircraft carrier HMS ''Ark Royal'', was brought down by an Igla-1 surface-to-air missile fired by the Army of Republika Srpska while attempting to bomb two Bosnian Serb tanks. The pilot, Lieutenant Nick Richardson, ejected and landed in territory controlled by friendly Bosnian Muslims.

It was used again in the 1999 NATO campaign against the Federal Republic of Yugoslavia in Operation Allied Force, where Sea Harriers operating from ''Invincible'' frequently patrolled the airspace to keep Yugoslavian MiGs on the ground. They were also deployed on board ''Illustrious'' in 2000 as part of Operation Palliser, the British intervention in Sierra Leone.

Retirement

The UK is procuring the STOVL F-35B to be operated from the Royal Navy's s."Securing Britain in an Age of Uncertainty: The Strategic Defence and Security Review."
''HM Government'', 19 October 2010. Retrieved 19 October 2010.

The Sea Harrier was withdrawn from service in 2006 and the last remaining aircraft from 801 Naval Air Squadron were decommissioned on 29 March 2006. The MoD argued that significant expenditure would be required to upgrade the fleet for only six years of service to meet the F-35s then planned in-service date.

Both versions of Harrier experienced reduced engine performance (Pegasus Mk 106 in FA2 – Mk 105 in GR7) in the higher ambient temperatures of the Middle East, which restricted the weight of payload that the Harrier could return to the carrier in 'vertical' recoveries. This was due to the safety factors associated with aircraft landing weights. The option to install higher-rated Pegasus engines would not have been as straightforward as on the Harrier GR7 upgrade and would have likely been an expensive and slow process. Furthermore, the Sea Harriers were subject to a generally more hostile environment than land-based Harriers, with corrosive salt spray a particular problem. A number of aircraft were retained by the School of Flight Deck Operations at RNAS ''Culdrose''.

The Royal Navy's Fleet Air Arm would continue to share the other component of Joint Force Harrier. Harrier GR7 and the upgraded Harrier GR9 were transferred to Royal Navy squadrons in 2006, but were retired prematurely in 2010 due to budget cuts.

Although withdrawn from active Royal Navy service, Sea Harriers are used to train naval aircraft handlers at the Royal Navy School of Flight Deck Operations.

Indian Navy

In 1977, the Indian government approved plans to acquire the Sea Harrier for the Indian Navy. In November 1979, India placed its first order for six Sea Harrier FRS Mk 51 fighters and two T Mk 60 Trainers; the first three Sea Harriers arrived at Dabolim Airport on 16 December 1983, and were inducted the same year.Hiranandani 2000, p. 276. Ten more Sea Harriers were purchased in November 1985; eventually a total of 30 Harriers were procured, 25 for operational use and the remainder as dual-seat trainer aircraft. Until the 1990s, significant portions of pilot training was carried out in Britain due to limited aircraft availability.

The introduction of the Sea Harrier allowed for the retirement of India's previous carrier fighter aircraft, the Hawker Sea Hawk, as well as for the Navy's aircraft carrier, , to be extensively modernised between 1987 and 1989. India has operated Sea Harriers from both the aircraft carriers INS ''Vikrant'' and INS ''Viraat''.Nordeen 2006, p. 14. The Sea Harrier allowed several modern missiles to be introduced into naval operations, such as the Sea Eagle anti-ship missile,Hiranandani 2000, p. 287. and the Matra Magic air-to-air missile.Hiranandani 2012, p. 154. Other ordnance has included 68 mm rockets, runway-denial bombs, cluster bombs, and podded 30 mm cannons.

There have been a significant number of accidents involving the Sea Harrier; this accident rate has caused approximately half the fleet to be lost with only 11 fighters remaining in service. Following a crash in August 2009, all Sea Harriers were temporarily grounded for inspection. Since the beginning of operational service in the Indian Navy, seven pilots have died in 17 crashes involving the Sea Harrier, usually during routine sorties.

In 2006, the Indian Navy expressed interest in acquiring up to eight of the Royal Navy's recently retired Sea Harrier FA2s in order to maintain their operational Sea Harrier fleet. Neither the Sea Harrier FA2's Blue Vixen radar, the radar warning receiver or AMRAAM capability would have been included; certain US software would also be uninstalled prior to shipment. By October 2006, reports emerged that the deal had not materialised due to the cost of airframe refurbishment.

In 2006, the Indian Navy started upgrading up to 15 Sea Harriers, installing the Elta EL/M-2032 radar and the Rafael 'Derby' medium-range air-to-air BVR missile. This enabled the Sea Harrier to remain in Indian service beyond 2012. By 2009, crashes had reduced India's fleet to 12 (from original 30).

India purchased the deactivated Russian aircraft carrier Admiral ''Gorshkov'' in 2004. After refurbishment and trials, the ship was formally inducted into the Indian Navy as INS ''Vikramaditya'' in June 2014. Sea Harriers operated from INS ''Viraat'' for the last time on 6 March 2016.

On 11 May 2016, a ceremony was held at INS Hansa, Dabolim, Goa to commemorate the phasing out of Sea Harriers from INAS 300 "White Tigers" and their replacement by the MiG-29K/KUB fighters. Aircraft of both types performed an air display at the ceremony, marking the final flight of the Sea Harriers after 33 years of service in the Indian Navy. The Indian Navy operates MiG-29K/KUB STOBAR fighters from ''Vikramaditya''.

Variants

;Sea Harrier FRS.1
: 57 FRS1s were delivered between 1978 and 1988; most survivors converted to Sea Harrier FA2 specifications from 1988.
;Sea Harrier FRS.51
: Single-seat fighter, reconnaissance, and attack aircraft made for the Indian Navy, similar to the British FRS1. Unlike the FRS1 Sea Harrier, it is fitted with Matra R550 Magic air-to-air missiles. These aircraft were later upgraded with the Elta EL/M-2032 radar and the Rafael Derby BVRAAM missiles.

;Sea Harrier F(A).2
: Upgrade of FRS1 fleet in 1988, featuring the Blue Vixen pulse-doppler radar and the AIM-120 AMRAAM missile.

Operators

;
: Indian Navy
:: Indian Naval Air Arm (1983–2016)
;
: Royal Navy
:: Fleet Air Arm (1978–2006)

Surviving aircraft

Several surviving Sea Harriers are held by museums and private owners, and some others are at the Royal Navy School of Flight Deck Operations at RNAS Culdrose and other military bases for training.A. Horrex, M. Ray, M. Boulanger, R. Dunn, T. McGhee & T. Wood
"Sea Harrier". Demobbed – Out of Service British Military Aircraft
. demobbed.org.uk The following is list of those not used by the military for training.

India

;On display
*Sea Harrier FRS 51 (IN-621) at the Naval Aviation Museum (India) in Goa, India
*Sea Harrier T Mk.60 (IN-654) at the Rashtriya Indian Military College in Dehradun, India

United Kingdom

;In use
*The Royal Navy School of Flight Deck Operations still uses Harriers to train Aircraft Handlers who train on the dummy deck at RNAS Culdrose.Airshow Review - RNAS Culdrose Air Day 2014 https://www.globalaviationresource.com/v2/2014/08/06/airshow-review-rnas-culdrose-air-day-2014/ Many are in a working condition, although in a limited-throttle setting. Although they are unable to fly, they still produce a loud sound to aid training.

;On display
*Sea Harrier FA.2 ''ZD610'' at Aerospace Bristol
*Sea Harrier FA.2 ''XZ457'' at the Boscombe Down Aviation Collection, Old Sarum, Wiltshire
*Sea Harrier FRS.1 ''XZ493'' at the Fleet Air Arm Museum, Yeovilton, Somerset
*Sea Harrier FA.2 ''XZ494'' at the Castle Farm Camping and Caravanning, Wedmore, Somerset
*Sea Harrier FA.2 ''ZA175'' at the Norfolk & Suffolk Aviation Museum, Flixton, Norfolk.
*Sea Harrier FA.2 ''ZA176'' at the Newark Air Museum, Newark, Nottinghamshire
*Sea Harrier FA.2 ''ZD607'' at the Defence Storage and Distribution Agency, Bicester, Oxfordshire
*Sea Harrier FA.2 ''ZD613'' on the roof of a building at the Cross Green Industrial Estate, Leeds, West Yorkshire
*Sea Harrier FA.2 ''ZE691'' at Woodford Park Industrial Estate, Winsford, Cheshire
*Sea Harrier FA.2 ''ZE694'' at the Midland Air Museum, Coventry, Warwickshire
*Sea Harrier FA.2 ''XZ459'' at Tangmere Military Aviation Museum in West Sussex, arrived in 2020

;Stored or under restoration
*Sea Harrier FA.2 ''ZH803'', formerly at SFDO at RNAS Culdrose, is owned by FLY HARRIER LTD, and gained civil registration with the CAA on 7 August 2019 as ''G-RNFA''. As of July 2020, it is listed as being at St Athan Airport in Wales.
*Sea Harrier FA.2 ''XZ497'' with a private collection at Charlwood, SurreyEllis 2016, p. 264
*Sea Harrier FA.2 ''XZ499'' with the Fleet Air Arm Museum storage facility Cobham Hall, Yeovilton
*Sea Harrier FA.2 ''ZD582'' with a private collection at Aynho, Northamptonshire
*Sea Harrier FA.2 ''ZD612'' with a private collection at Topsham, Devon
*Sea Harrier FA.2 ''ZD614'' with a private collection Walcott, Lincolnshire
*Sea Harrier FA.2 ''ZE697'' at the former RAF Binbrook, Lincolnshire (as of 2016)
*Sea Harrier FA.2 ''ZE698'' with a private collection at Charlwood, Surrey
*Sea Harrier FA.2 ''ZH798'', formerly at RNAS Culdrose, was auctioned off in 2020 to Jet Art Aviation, who restored the aircraft to be taxi- and ground-run capable.
*Sea Harrier FA.2 ''ZH799'' with a private collection at Tunbridge Wells, Kent
*Sea Harrier FA.2 ''ZH806'', ''ZH810'', and ''ZH812'' with a dealer near Ipswich, Suffolk

United States

;Airworthy
*Sea Harrier FA2 registered N94422 (formerly Royal Navy serial number XZ439) Nalls Aviation St Mary's County, Maryland. The former Royal Navy Sea Harrier FA2 was purchased in 2006 by Art Nalls, who spent the next two years restoring it to flying condition. In December 2007, it was damaged in a hard landing, while undergoing testing at Naval Air Station Patuxent River and had to be repaired. The aircraft made its first public appearance at an air show in Culpeper, Virginia, in October 2008. The aircraft is the only privately owned, civilian-flown Harrier in the world.

Specifications (Sea Harrier FA.2)

Notable appearances in media

The Harrier's unique characteristics have led to it being featured a number of films and video games.

See also

References

Notes

Bibliography

*
*
* Chant, Chris. ''Air War in the Falklands 1982 (Osprey Combat Aircraft #28)''. Oxford, UK: Osprey Publishing, 2001. .
*
*
*
*
*
*
*
*
*

*
*
*
*
*
*
*
*
*
*

;Further reading
*

External links

British Aerospace Sea Harrier



List of surviving Sea Harriers: Demobbed – Out of Service British Military Aircraft

{{Authority control

Sea Harrier
1970s British attack aircraft
1970s British fighter aircraft
Carrier-based aircraft
V/STOL aircraft by thrust vectoring
Harrier Jump Jet
Single-engined jet aircraft
Aircraft first flown in 1978
Shoulder-wing aircraft
Fourth-generation jet fighter