The Buccaneer (also known in some of its many incarnations as the Mallard) is a one- or two-seat
ultralight high-wing
amphibious
Amphibious means able to use either land or water. In particular it may refer to:
Animals
* Amphibian, a vertebrate animal of the class Amphibia (many of which live on land and breed in water)
* Amphibious caterpillar
* Amphibious fish, a fish ...
flying boat
A flying boat is a type of fixed-winged seaplane with a hull, allowing it to land on water. It differs from a floatplane in that a flying boat's fuselage is purpose-designed for floatation and contains a hull, while floatplanes rely on fusela ...
of
pusher configuration
In an aircraft with a pusher configuration (as opposed to a tractor configuration), the propeller(s) are mounted behind their respective engine(s). Since a pusher propeller is mounted behind the engine, the drive shaft is in compression in nor ...
marketed as a
kit aircraft.
The aircraft was manufactured by a number of U.S. firms in slightly different forms, including
Arnet Pereyra Inc
Aero Adventure LLC (formerly Aero Adventure Aviation and before that Arnet Pereyra Inc.) is an American aircraft manufacturer based in DeLand, Florida.
In 1996, the firm acquired the assets and production rights of Keuthan Aircraft.
List of ...
,
[Downey, Julia: ''1999 Kit Aircraft Directory'', Kitplanes, Volume 15, Number 12, December 1998, page 37. Primedia Publications. ISSN 0891-1851] HighCraft AeroMarine
Advanced Aeromarine (later HighCraft AeroMarine) was an aircraft manufacturer based in Ocoee, Florida. It built light aircraft and sailplanes, developing a number of successful designs that have been produced by a number of different firms over th ...
,
Advanced Aviation
Advanced Aviation was a manufacturer of ultralight aircraft in kit form based in Orlando, Florida. It marketed designs by HighCraft AeroMarine under licence.Cliche, Andre: ''Ultralight Aircraft Shopper's Guide'' 8th Edition, page B-109 and E-19. ...
and
Keuthan Aircraft
Keuthan Aircraft was a US aircraft manufacturer located in Merritt Island, Florida. The firm marketed ultralights in kit form. It ceased business in 1996 and its assets were acquired by Arnet Pereyra Inc
Aero Adventure LLC (formerly Aero Adv ...
.
Development
The original single-seat model Buccaneer XA was introduced in 1984 and qualified for the US
FAR 103 Ultralight Vehicle category. The aircraft was commercial success and sold well until being replaced by the Buccaneer SX in 1988. The SX remained available on the market until general production ended in 1998, although in 2001 the model was still available as a special order from
Aero Adventure Aviation
Aero Adventure LLC (formerly Aero Adventure Aviation and before that Arnet Pereyra Inc.) is an American aircraft manufacturer based in DeLand, Florida.
In 1996, the firm acquired the assets and production rights of Keuthan Aircraft.
List of ...
. The SX was replaced by the improved derivative
Aero Adventure Aventura UL and HP single seaters.
The Buccaneer II was a two-seat side-by-side configuration model introduced in 1988 and intended as an ultralight trainer. This model was replaced by the
Aero Adventure Aventura II, which is an improved model developed from the Buccaneer II.
Design
The original XA model is constructed from bolted together anodized
aluminum
Aluminium (aluminum in American and Canadian English) is a chemical element with the symbol Al and atomic number 13. Aluminium has a density lower than those of other common metals, at approximately one third that of steel. It has ...
tubing, with a
fiberglass
Fiberglass (American English) or fibreglass (Commonwealth English) is a common type of fiber-reinforced plastic using glass fiber. The fibers may be randomly arranged, flattened into a sheet called a chopped strand mat, or woven into glass cloth ...
hull. The wire-braced wing is supported by a
king post and is of aluminum structure, covered with pre-sewn
Dacron
Polyethylene terephthalate (or poly(ethylene terephthalate), PET, PETE, or the obsolete PETP or PET-P), is the most common thermoplastic polymer resin of the polyester family and is used in fibres for clothing, containers for liquids and foods ...
covers. The wing features 2/3 span
ailerons and no
flaps. The tail wheel is retractable via a cable control, while the main landing gear is removed by the pilot in flight and stowed in the cockpit for landing on water after a land take-off.
The model SX was introduced to provide incremental design improvements over the XA. Primarily the SX eliminated the cable-bracing and replaced it with V-
struts featuring
jury struts
In aeronautics, bracing comprises additional structural members which stiffen the functional airframe to give it rigidity and strength under load. Bracing may be applied both internally and externally, and may take the form of strut, which act in ...
. The wings feature full-span ailerons. The fuselage was completely redesigned and features a new hull shape that can better handle higher wave conditions. The landing gear can be pivoted up for water landings, rather than removed.
The Buccaneer II is similar to the SX, but with a wider hull to accommodate two seats, in side-by-side configuration. The ailerons are 2/3 span. The landing gear is repositioned by a lever control and moves the tailwheel in concert with the main wheels. The main gear includes mechanical brakes.
Operational use
The original model XA remains popular on the used aircraft market and aircraft for sale command high prices. Long operational use and the rigours of land and water operation have resulted in weak points in the design being identified as many older aircraft have suffered from bent
wing trailing edges,
wing root tube brackets, flying wire shackles and tail boom tubes. Cracked aft vertical stabilizer tubes and main bulkheads are also common. All of these deficiencies can be repaired in used aircraft.
Variants
;Buccaneer XA
:Single seat, wired-braced Part 103 ultralight flying boat. Engines available were the
Rotax 277
The Rotax 277 is a , single-cylinder, two-stroke aircraft engine, that was built by BRP-Rotax GmbH & Co. KG of Austria for use in ultralight aircraft.Raisner, William: ''LEAF catlog'', pages 6-105. Leading Edge Airfoils, 1995.
Development
The ...
and the
Rotax 377.
;Buccaneer SX
:Single seat, strut-braced flying boat. Engines available were the
Rotax 447 and the
Rotax 503.
;Buccaneer II
:Two seat, strut-braced flying boat. Engines available were the
Rotax 582 and the
Rotax 912
The Rotax 912 is a horizontally-opposed four-cylinder, naturally aspirated, four-stroke aircraft engine with a reduction gearbox. It features liquid-cooled cylinder heads and air-cooled cylinders. Originally equipped with carburetors, late ...
.
;Mallard M2-A
:Extensively modified Buccaneer, with the wing lowered. Was sold as a modification package and as a complete kit.
[Purdy, Don: ''AeroCrafter - Homebuilt Aircraft Sourcebook'', page 92. BAI Communications, 15 July 1998. ]
Specifications (Buccaneer XA)
See also
References
External links
{{Advanced Aviation aircraft
Buccaneer
Buccaneers were a kind of privateers or free sailors particular to the Caribbean Sea during the 17th and 18th centuries. First established on northern Hispaniola as early as 1625, their heyday was from Stuart Restoration, the Restoration in 16 ...
Buccaneer
Buccaneers were a kind of privateers or free sailors particular to the Caribbean Sea during the 17th and 18th centuries. First established on northern Hispaniola as early as 1625, their heyday was from Stuart Restoration, the Restoration in 16 ...
1980s United States ultralight aircraft
Amphibious aircraft
Single-engined pusher aircraft
High-wing aircraft
Homebuilt aircraft
Flying boats